Search

A NADPH-dependent (S)-imine reductase (SIR) was purified to be homogeneous from the cell-free extract of Streptomyces sp. GF3546. SIR appeared to be a homodimer protein with subunits of 30.5 kDa based on SDS-polyacrylamide gel electrophoresis and HPLC gel filtration. It also catalyzed the (S)-enantioselective reduction of not only 2-methyl-1-pyrroline (2-MPN) but also 1-methyl-3,4-dihydroisoquinoline and 6,7-dimethoxy-1-methyl-3,4-dihydroisoquinoline. Specific activities for their imines were 130, 44, and 2.6 nmol min(-1) mg(-1), and their optical purities were 92.7 % ee, 96.4 % ee, and >99 % ee, respectively. Using a NADPH-regenerating system, 10 mM 2-MPN was converted to amine with 100 % conversion and 92 % ee after 24 h. The amino acid sequence analysis revealed that SIR showed about 60 % identity to 6-phosphogluconate dehydrogenase. However, it showed only 37 % identity with Streptomyces sp. GF3587 (R)-imine reductase. Expression of SIR in Escherichia coli was achieved, and specific activity of the cell-free extract was about two times higher than that of the cell-free extract of Streptomyces sp. GF3546.

Alkane-assimilating microorganisms were isolated from enrichment cultures using n-octane, n-dodecane, n-hexadecane, or pristane (2,6,10,14-tetramethylpentadecane) as a sole carbon source to find microbial catalysts oxidizing methyl groups of 2,6-dimethylpyridine. The cells of Exophiala dermatitidis (Kano) de Hoog DA5501, an n-dodecane-assimilating fungus, oxidized a single methyl group of 2,6-dimethylpyridine to produce 6-methylpicolinic acid (6-methylpyridine-2-carboxylic acid) without the formation of dipicolinic acid (pyridine-2,6-dicarboxylic acid); 67 mM 6-methylpicolinic acid (9.2 g/l) accumulated with a molar conversion yield of 89% by 54-h incubation. The fungus cells also oxidized the methyl group of 2,6-dimethylpyrazine and 2,4,6-trimethylpyridine regioselectively.

The tandem conversion process involving nitrile hydratase- and amidase-producing microorganisms has potential for use in the treatment of acetonitrile-containing wastes. In that process, the acetamide hydrolysis step catalyzed by amidase is very slow compared with the acetonitrile hydration step catalyzed by nitrile hydratase, and a small amount of acetamide remains in the resulting solution. This study aimed to improve the efficiency of the acetamide hydrolysis step. An amidase-producing microorganism, Rhodococcus sp. S13-4, was newly obtained, whose use enabled rapid acetamide degradation. Though residual acetamide was still detected, it was successfully reduced by the addition of cation/anion mixed ion exchange resin or calcium hydroxide after the acetamide hydrolysis reaction using Rhodococcus sp. S13-4 cells. This result implies that acetamide hydrolysis and acetamide formation are in equilibrium. The incubation of Rhodococcus sp. S13-4 cells with high concentrations of ammonium acetate produced acetamide. The purified amidase from Rhodococcus sp. S13-4 revealed the acetamide formation activity (specific activity of 30.6 U/mg protein). This suggests that the amidase-catalyzed amide formation may cause the remaining of acetamide in the acetonitrile conversion process.

The ability to produce vanillin and/or vanillic acid from isoeugenol was screened using resting cells of various bacteria. The vanillin- and/or vanillic-acid-producing activities were observed in strains belonging to the genera Achromobacter, Aeromonas, Agrobacerium, Alcaligenes, Arthrobacter, Bacillus, Micrococcus, Pseudomonas, Rhodobacter, and Rhodococcus. Strain IE27, a soil isolate showing the highest vanillin-producing activity, was identified as Pseudomonas putida. We optimized the culture and reaction conditions for vanillin production from isoeugenol using P. putida IE27 cells. The vanillin-producing activity was induced by adding isoeugenol to the culture medium but not vanillin or eugenol. Under the optimized reaction conditions, P. putida IE27 cells produced 16.1 g/l vanillin from 150 mM isoeugenol, with a molar conversion yield of 71% at 20 degrees C after a 24-h incubation in the presence of 10% (v/v) dimethyl sulfoxide.

We found a bacterium, Pandoraea sp. 12B-2, of which whole cells catalyzed not only the decarboxylation of 2,6-dihydroxybenzoate but also the regioselective carboxylation of 1,3-dihydroxybenzene to 2,6-dihydroxybenzoate. The whole cells of Pandoraea sp. 12B-2 also catalyzed the regioselective carboxylation of phenol and 1,2-dihydroxybenzene to 4-hydroxybenzoate and 2,3-dihydroxybenzoate, respectively. The molar conversion ratio of the carboxylation reaction depended on the concentration of KHCO(3) in the reaction mixture. Only 5 or 48 % of 1,3-dihydroxybenzene added was converted into 2,6-dihydroxybenzoate in the presence of 0.1 M or 3 M KHCO(3), respectively. The addition of acetone to the reaction mixture increased the initial rate of the carboxylation reaction, but the final molar conversion yield reached almost the same value. When the efficient production of 2,6-dihydroxybenzoate was optimized using the whole cells of Pandoraea sp. 12B-2, the productivity of 2,6-dihydroxybenzoate topped out at 1.43 M, which was the highest value so far reported. No formation of any other products was observed after the carboxylation reaction.

This study aimed to construct an acetonitrile-containing waste treatment process by using nitrile-degrading microorganisms. To degrade high concentrations of acetonitrile, the microorganisms were newly acquired from soil and water samples. Although no nitrilase-producing microorganisms were found to be capable of degrading high concentrations of acetonitrile, the resting cells of Rhodococcus pyridinivorans S85-2 containing nitrile hydratase could degrade acetonitrile at concentrations as high as 6 M. In addition, an amidase-producing bacterium, Brevundimonas diminuta AM10-C-1, of which the resting cells degraded 6 M acetamide, was isolated. The combination of R. pyridinivorans S85-2 and B. diminuta AM10-C-1 was tested for the conversion of acetonitrile into acetic acid. The resting cells of B. diminuta AM10-C-1 were added after the first conversion involving R. pyridinivorans S85-2. Through this tandem process, 6 M acetonitrile was converted to acetic acid at a conversion rate of >90% in 10 h. This concise procedure will be suitable for practical use in the treatment of acetonitrile-containing wastes on-site.

Hydroxylation of adamantane using whole cells of bacteria, actinomyces, and molds was examined. The structure of the product was determined using gas chromatography (GC), nuclear magnetic resonance (NMR), and mass spectroscopy (MS). Among 470 strains tested, Streptomyces griseoplanus was highly regioselective to give 1-adamantanol (0.096 mmol) from adamantane (0.3 mmol) in a 32% molar conversion yield after 72-h cultivation in the presence of 3% (v/v) Tween 60. A P450 inhibitor such as 0.5 mM 1-aminobenzotriazole or menadione significantly inhibited the hydroxylation activity. These results suggested that a P450 oxidation system might be involved in this hydroxylation reaction.

epsilon-Poly-L-lysine (epsilon-PL) is a homo-poly-amino acid characterized by the peptide bond between the carboxyl and epsilon-amino groups of L-lysine. epsilon-PL shows a wide range of antimicrobial activity and is stable at high temperatures and under both acidic and alkaline conditions. The mechanism of the inhibitory effect of epsilon-PL on microbial growth is the electrostatic adsorption to the cell surface of microorganisms on the basis of its poly-cationic property. Due to this antimicrobial activity, epsilon-PL is now industrially produced in Japan as a food additive by a fermentation process using Streptomyces albulus. In spite of the practical application of epsilon-PL, the biosynthetic mechanisms of epsilon-PL have not been clarified at all. epsilon-PL producers commonly possess membrane-bound epsilon-PL-degrading aminopeptidase, which might play a role in self-protection.

A new soil isolate, tentatively identified as Rhodococcus equi TG328, was found to be effective in the production of S-(+)-2-phenylpropionic acid from (R,S)-2-phenylpropionitrile. The conversion is catalysed by two enzymes. First, a nitrile hydratase converts the (R,S)-nitrile to (R,S)-2-phenylpropionamide. Second, a stereoselective amidase converts the S-(+)-amide to S-(+)-2-phenylpropionic acid. Conditions for optimal enzyme production and accumulation of S-(+)-2-phenylpropionic acid by resting cells were studied. The reaction of resting cells for 30 h at 10 degrees C with (R,S)-2-phenylpropionitrile resulted in the production of 100 g of S-(+)-2-phenylpropionic acid per litre of reaction mixture. The enantiometric excess of the purified S-(+)-2-phenylpropionic acid was 99.4%. The amount of S-(+)-2-phenylpropionic acid accumulated was enhanced by lower reaction temperatures. In addition, unreacted R-(-)-2-phenylpropionamide with 99.0% enantiometric excess was isolated.