Search

Bitumen (referred to as asphalt in the United States) is a widely used construction material, and emissions from hot bitumen applications have been a long-standing health concern. One objective of the Human Bitumen Study was to identify potential determinants of the exposure to bitumen. The study population analysed comprised 259 male mastic asphalt workers recruited between 2003 and 2008. Personal air sampling in the workers' breathing zone was carried out during the shift to measure exposure to vapours and aerosols of bitumen. The majority of workers were engaged in building construction, where exposure levels were lower than in tunnels but higher than at road construction sites. At building construction sites, exposure levels were influenced by the room size, the processing temperature of the mastic asphalt and the job task. The results show that protective measures should include a reduction in the processing temperature.

Emission levels of vapours and aerosols of bitumen are different when processing rolled asphalt compared to mastic asphalt, with working temperatures up to 180 and 250°C, respectively. During the Human Bitumen Study, we examined six workers handling rolled asphalt and mastic asphalt in two consecutive weeks at the same construction site in a tunnel. In addition to the determination of exposure to bitumen and polycyclic aromatic hydrocarbons (PAH) during shift, we examined urinary PAH metabolites, irritative and genotoxic effects before and after shift. Median personal shift concentration of vapours and aerosols of bitumen was 1.8 (range 0.9-2.4) mg/m(3) during the application of rolled asphalt and 7.9 (range 4.9-11.9) mg/m(3) when mastic asphalt was applied. Area measurement of vapours and aerosols of bitumen revealed higher concentrations than the personal measurements for mastic asphalt (mastic asphalt: 34.9 mg/m(3); rolled asphalt: 1.8 mg/m(3)). Processing mastic asphalt was associated also with higher PAH concentrations. Urinary 1-hydroxypyrene and the sum of 1-, 2+ 9-, 3- and 4-hydroxyphenanthrene increased slightly during shift without clear difference between mastic and rolled asphalt application. However, the post-shift urinary PAH-metabolite concentrations did not reflect the different PAH exposure during mastic and rolled asphalt application. Individual workers could be identified by their spirometry results indicating that these data reflect more chronic than acute effects. In most cases, an increase of 8-oxodGuo adducts was observed during shift that was independent of the asphalt application. 8-oxodGuo and (+)-anti-BPDE-DNA adducts were higher than in exposed workers of the Human Bitumen Study independent of the asphalt application. The DNA-strand breaks were considerably higher pre-shift and decreased during shift. In this study, mastic asphalt application led to significantly higher exposure to vapours and aerosols of bitumen, as well as to airborne PAH, compared to rolled asphalt application. Nevertheless, no differences in the excretion of urinary PAH metabolites, lung function impairment and genotoxic markers were detected. However, higher levels of genotoxicity markers on both examination days compared with the results of the Human Bitumen Study may indicate a possible influence of the specific tunnel setting.

Bitumen has attracted attention from the scientific community and regulating agencies. The debate on health effects of exposure to vapours and aerosols of bitumen during the hot application of bitumen ranges from respiratory and neurological effects to carcinogenicity. In 2000, the German Hazardous Substances Committee (AGS), in collaboration with the German Bitumen Forum, initiated the examination of a group of mastic asphalt workers and a same number of construction workers without exposure bitumen using a cross-shift design. The study was then extended to the Human Bitumen Study, and the recruitment was finished in 2008 after examination of 500 workers on 80 construction sites. Three hundred and twenty workers exposed to vapours and aerosols of bitumen at high processing temperatures and 118 workers at outdoor construction sites were included. In the Human Bitumen Study external exposure to vapours and aerosols of bitumen, internal exposure to PAH by analysing urinary 1-hydroxypyrene, the sum of hydroxyphenanthrenes and the sum of 1- and 2-hydroxynaphthalenes, irritative effects in the upper and lower airways and genotoxic effects in blood cells were investigated. The study turned out to be one of the largest investigations of workers exposed to vapours and aerosols of bitumen under current exposure conditions. The present paper summarizes its background and main topics.

The chemical complexity of emissions from bitumen applications is a challenge in the assessment of exposure. Personal sampling of vapours and aerosols of bitumen was organized in 320 bitumen-exposed workers and 69 non-exposed construction workers during 2001-2008. Area sampling was conducted at 44 construction sites. Area and personal sampling of vapours and aerosols of bitumen showed similar concentrations between 5 and 10 mg/m(3), while area sampling yielded higher concentrations above the former occupational exposure limit (OEL) of 10 mg/m(3). The median concentration of personal bitumen exposure was 3.46 mg/m(3) (inter-quartile range 1.80-5.90 mg/m(3)). Only few workers were exposed above the former OEL. The specificity of the method measuring C-H stretch vibration is limited. This accounts for a median background level of 0.20 mg/m³ in non-exposed workers which is likely due to ubiquitous aliphatic hydrocarbons. Further, area measurements of polycyclic aromatic hydrocarbons (PAHs) were taken at 25 construction sites. U.S. EPA PAHs were determined with GC/MS, with the result of a median concentration of 2.47 μg/m(3) at 15 mastic asphalt worksites associated with vapours and aerosols of bitumen, with a Spearman correlation coefficient of 0.45 (95% CI -0.13 to 0.78). PAH exposure at mastic-asphalt works was higher than at reference worksites (median 0.21 μg/m(3)), but about one order of magnitude lower compared to coke-oven works. For a comparison of concentrations of vapours and aerosols of bitumen and PAHs in asphalt works, differences in sampling and analytical methods must to be taken into account.

In vitro systems are widely used to evaluate the embryotoxic potential of retinoids. The effective concentrations of these retinoids, however, are not consistent in the various in vitro systems used in evaluating embryotoxicity. This may be explained by the different level of complexity for each individual system, which may lead to different concentrations of the substances in the target tissues. To verify this hypothesis we have compared two in vitro systems of distinct biological complexity: the rat whole embryo culture system, and the mouse limb bud organ culture system. The lipid soluble, teratogenic retinoid all-trans-retinoic acid (ATRA), and all-trans-retinoyl-beta-D-glucuronide (ATRAG), an endogenous, water-soluble and biologically active retinoid with limited placental transfer, were compared with regard to their embryotoxic potential in vitro. In both in vitro systems, ATRAG showed a lower degree of embryotoxicity than ATRA. In the limb bud organ culture, ATRAG revealed only slightly less toxicity than ATRA, whereas the effective concentrations of the two compounds in the whole embryo culture system differed by almost two orders of magnitude. During incubation with ATRAG, ATRA is generated by hydrolysis and is found in culture media and exposed tissues. The presence of membrane barriers around the developing embryo in the whole embryo culture system possibly prevents the transfer of ATRAG to the embryo and, therefore, its exposure to the active hydrolysis product ATRA. From these results we conclude that analysis of retinoid concentrations in the culture media and in the exposed tissues is essential for the interpretation of results obtained from in vitro toxicity testing.

Retinoids are involved in several physiological processes and are used in the treatment of various skin disorders. Therapy with retinoids during pregnancy may induce severe embryotoxic effects like craniofacial and cardiovascular malformations in the developing embryo. We investigated the effects of all-trans-retinoic acid (ATRA) and all-trans-retinoyl-beta-D-glucuronide (ATRAG) in an amphibian embryotoxicity assay with Ambystoma mexicanum (axolotl) as an alternative in vitro method. Embryos were exposed to various concentrations of ATRA or ATRAG for 48 h beginning with the blastula stage. Kinetic investigations in the embryonic tissue were performed during the exposure period. Both retinoids interfered with the development of the axolotl embryos. Dose-dependent effects observed included growth retardation, craniofacial and cardiovascular malformations, as well as neural tube defects. In the axolotl, ATRA induced slightly more pronounced embryotoxic effects than ATRAG. All-trans-retinal was shown to be a major endogenous retinoid in this species. Endogenous levels of all-trans-retinaldehyde were increased during exposure to both ATRA and ATRAG. The glucuronide, however, was only detected in small amounts after ATRAG exposure. The embryotoxic potential of ATRAG could be explained by deglucuronidation to ATRA.

Retinoids, derivatives of vitamin A, are essential for many vertebrate functions. Furthermore, several drugs of this class of compounds are valuable in the treatment of certain forms of skin disorders and cancer. However, the therapeutic application of retinoids is limited by their teratogenic potency. The limbs are important sites of retinoid-induced malformations in rodents. Therefore, organoid cultures of limb bud mesenchymal cells have been established for screening of the teratogenic potency of retinoids. We have now applied this system to compare the effects of all-trans-retinoyl-beta-D-glucuronide (all-trans-RAG) with those of all-trans-retinoic acid (all-trans-RA) on chondrogenesis, as assessed by the Alcian blue binding assay and by electron microscopic evaluation including quantitative morphometric analysis. First data of retinoid toxicokinetics in the culture media as well as retinoid concentrations in the cultured mesenchymal limb bud cells were established. While all-trans-RA inhibited chondrogenesis at 10(-7) M by ca. 50%, tenfold higher concentrations of all-trans-RAG were necessary to obtain the same effect. This difference reflects the ratio of RA isomers which were found in the medium after incubation with either all-trans-RAG or all-trans-RA. A pulse experiment (10(-5) M all-trans-RAG or all-trans-RA for the first 2 h of a 6-day incubation period) demonstrated inhibition of chondrogenesis with all-trans-RA, but not with all-trans-RAG. The data indicate that RAG inhibits chondrogenesis upon hydrolysis to RA. Surprisingly, the rather polar RAG isoforms were extensively accumulated in the limb bud mesenchymal cells when compared to the medium. Both all-trans-RAG and all-trans-RA also induced a large increase of retinyl ester concentrations in the chondrocytes compared to vehicle-treated cells. This finding further supports a recent suggestion that RA regulates retinol metabolism via feedback inhibition of retinol oxidation and stimulation of the esterification of retinol.