Search

This study examined the effect of water-chilled perches on hen production and physiological responses to induced molt during elevated temperatures. A total of 288White Leghorns at 82 wk of age were housed in 36 cages of 6 banks. Each bank was assigned to 1 of 3 treatments: cooled perches, air perches, and no perches. The hens were subjected to 2 heat episodes during their first laying cycle at week 21 to 35 and week 73 to 80, respectively. The hens were subjected to a 28 D nonfasted molting regimen starting at 85 wk of age. Cyclic heat of 32°C (6:00 am to 6:00 pm) was applied daily during the molting period. After molt, hens were returned to a layer diet and housed under thermoneutral condition. Two birds per cage were monitored for BW change during molt. Egg production was recorded daily. Feed utilization was measured during molt at 86 and 88 wk of age. Egg weight and eggshell traits were examined at 84 wk (pre-molt) and post-molt at 92, 96, and 104 wk of age. Rectal temperature and blood samples were collected from 2 birds per cage at the end of molt. Blood samples were used for determining heterophil/lymphocyte ratio, corticosterone, and thyroid hormones. Plumage condition was examined at 22 wk post-molt. Compared to control and air perch hens, cooled perch hens had higher feed usage and greater BW loss, lower heterophil/lymphocyte ratios (P < 0.05) with no difference in thyroid hormones and corticosterone at the end of molt. Cooled perch hens also had higher egg production beginning at 98 wk of age (Ptreatment*age < 0.0001) than control hens and sometimes the air-perch hens. Cooled perch hens had higher rectal temperature than control but not air perch hens at end of molt. Moreover, cooled perch hens had better breast feather scores than air perch hens but worse vent plumage (P ≤ 0.05) than both control and air perch hens. These results indicate that the provision of cooled perches assists hens with better adaptation to stressors, such as induced molt plus heat exposure, resulting in improved post-molt egg production., (Published by Oxford University Press on behalf of Poultry Science Association 2019.)

We assessed the effects of water-chilled perches as a cooling device on the physiological parameters of caged laying hens exposed to 2 cyclic heating episodes. White Leghorns, 17 wk of age, were randomly assigned to 36 cages of 6 banks placed in the same room. Each bank was randomly assigned to 1 of 3 treatments: cooled perch (CP), air perch (AP), and no perch (CTRL) resulting in 2 replicate banks and 12 cages per treatment. Chilled water (10°C) circulated through the CP during heat periods when hens were 21 wk to 35 wk and 73 wk to 80 wk of age, respectively. During the heating episodes, hens were submitted to a daily cyclic temperature regimen of 35°C (0600 h to 1800 h) and 28°C (1800 h to 0600 h). Rectal temperature, packed cell volume, heterophil to lymphocyte (H/L) ratio, and plasma levels of triiodothyronine (T3), thyroxine (T4), interleukin (IL)-6, IL-10, immunoglobulin (Ig) Y, interferon (IFN)-γ, and heat shock protein (HSP) 70 were measured on the last day of the 2 heating episodes. At the end of the first heating episode, CP hens had lower rectal temperature (P = 0.02) than both AP and CTRL hens. The CP hens also had lower HSP 70 (P = 0.04) than CTRL hens but not AP hens. At the end of the second heating episode, the CP hens had lower rectal temperature (P = 0.02) and circulating H/L ratio (P = 0.01) than both AP and CTRL hens. The CP hens also had higher levels of T3 (P = 0.002) and T3/T4 ratio (P = 0.0006) than CTRL hens but not AP hens, with a greater packed cell volume than AP hens (P = 0.02) but not CTRL hens. Cytokines and IgY levels were similar among treatments. These results indicate that CP hens were better able to cope with cyclic heat stress than CTRL and sometimes AP hens as noted by the beneficial effects on rectal temperature, thyroid activity, HSP, and H/L ratio., (Published by Oxford University Press on behalf of Poultry Science Association 2019.)

Image processing systems have been widely used in monitoring livestock for many applications, including identification, tracking, behavior analysis, occupancy rates, and activity calculations. The primary goal of this work was to quantify image processing performance when monitoring laying hens by comparing length of stay in each compartment as detected by the image processing system with the actual occurrences registered by human observations. In this work, an image processing system was implemented and evaluated for use in an environmental animal preference chamber to detect hen navigation between 4 compartments of the chamber. One camera was installed above each compartment to produce top-view images of the whole compartment. An ellipse-fitting model was applied to captured images to detect whether the hen was present in a compartment. During a choice-test study, mean ± SD success detection rates of 95.9 ± 2.6% were achieved when considering total duration of compartment occupancy. These results suggest that the image processing system is currently suitable for determining the response measures for assessing environmental choices. Moreover, the image processing system offered a comprehensive analysis of occupancy while substantially reducing data processing time compared with the time-intensive alternative of manual video analysis. The above technique was used to monitor ammonia aversion in the chamber. As a preliminary pilot study, different levels of ammonia were applied to different compartments while hens were allowed to navigate between compartments. Using the automated monitor tool to assess occupancy, a negative trend of compartment occupancy with ammonia level was revealed, though further examination is needed., (©2014 Poultry Science Association Inc.)

Quantifying non-methane hydrocarbons (NMHC) from animal feeding operations (AFOs) is challenging due to the broad spectrum of compounds and the polar nature of the most abundant compounds. The purpose of this study was to determine the performance of commercial NMHC analyzers for measuring volatile organic compounds (VOCs) commonly emitted from AFOs. Three different NMHC analyzers were tested for response to laboratory generated VOCs, and two were tested in the field at a commercial poultry facility. The NMHC analyzers tested included gas chromatography/flame ionization detector (GC/FID), photoacoustic infrared (PA-IR) and photoionization detector (PID). The GC/FID NHHC analyzer was linear in response to nonpolar compounds, but detector response to polar oxygenated compounds were lower than expected due to poor peak shape on the column. The PA-IR NMHC instrument responded well to the calibration standard (propane), methanol, and acetone, but it performed poorly with larger alcohols and ketones and acetonitrile. The PA-IR response varied between compounds in similar compound classes. The PID responded poorly to many of the most abundant VOCs at AFOs, and it underreported alcohols by > 70%. In the field monitoring study, total NMHC concentrations were calculated from sum total of VOC determined using EPA Methods TO-15 and TO-17 with GC-MS compared to results from NMHC analyzers. NMHC GC/FID values were greater than the values calculated from the individual compound measurements. This indicated the presence of small hydrocarbons not measured with TO-15 or TO-17 such as propane. The PA-IR response was variable, but it was always lower than the GC/FID response. Results suggest that improved approaches are needed to accurately determine the VOC profile and NMHC emission rates from AFOs.

Mitigation of bioaerosol emissions from concentrated animal feeding operations (CAFOs) demands knowledge of bioaerosol concentrations feeding into an end-of-pipe air treatment process. The aim of this preliminary study was to measure total endotoxin and (1 --> 3)-beta-glucan concentrations at the air exhaust of 18 commercial CAFOs and to examine their variability with animal operation type (swine farrowing, swine gestation, swine weaning, swine finishing, manure belt laying hen, and tom turkey) and season (cold, mild, and hot). The measured airborne concentrations of total endotoxin ranged from 98 to 23,157 endotoxin units (EU)/m3, and the airborne concentrations of total (1 --> 3)-beta-D-glucan ranged from 2.4 to 537.9 ng/m3. Animal operation type in this study had a significant effect on airborne concentrations of total endotoxin and (1 --> 3)-beta-D-glucan but no significant effect on their concentrations in total suspended particulate (TSP). Both endotoxin and (1 --> 3)-beta-D-glucan attained their highest airborne concentrations in visited tom turkey buildings. Comparatively, season had no significant effect on airborne concentrations of total endotoxin or (1 --> 3)-beta-D-glucan. Endotoxin and (1 --> 3)-beta-glucan concentrations in TSP dust appeared to increase as the weather became warmer, and this seasonal effect was significant in swine buildings. Elevated indoor temperatures in the hot season were considered to facilitate the growth and propagation of bacteria and fungi, thus leading to higher biocomponent concentrations in TSP.

As part of a systemic assessment toward social sustainability of egg production, we have reviewed current knowledge about the environmental impacts of egg production systems and identified topics requiring further research. Currently, we know that 1) high-rise cage houses generally have poorer air quality and emit more ammonia than manure belt (MB) cage houses; 2) manure removal frequency in MB houses greatly affects ammonia emissions; 3) emissions from manure storage are largely affected by storage conditions, including ventilation rate, manure moisture content, air temperature, and stacking profile; 4) more baseline data on air emissions from high-rise and MB houses are being collected in the United States to complement earlier measurements; 5) noncage houses generally have poorer air quality (ammonia and dust levels) than cage houses; 6) noncage houses tend to be colder during cold weather due to a lower stocking density than caged houses, leading to greater feed and fuel energy use; 7) hens in noncage houses are less efficient in resource (feed, energy, and land) utilization, leading to a greater carbon footprint; 8) excessive application of hen manure to cropland can lead to nutrient runoff to water bodies; 9) hen manure on open (free) range may be subject to runoff during rainfall, although quantitative data are lacking; 10) mitigation technologies exist to reduce generation and emission of noxious gases and dust; however, work is needed to evaluate their economic feasibility and optimize design; and 11) dietary modification shows promise for mitigating emissions. Further research is needed on 1) indoor air quality, barn emissions, thermal conditions, and energy use in alternative hen housing systems (1-story floor, aviary, and enriched cage systems), along with conventional housing systems under different production conditions; 2) environmental footprint for different US egg production systems through life cycle assessment; 3) practical means to mitigate air emissions from different production systems; 4) process-based models for predicting air emissions and their fate; and 5) the interactions between air quality, housing system, worker health, and animal health and welfare.