Search

In total, around 631 million broilers were slaughtered in Germany in 2022. This evaluation included data of approx. 198 million broilers of different ages and breeds that were transported in Germany in 2022 (31% of all cases of broiler chicken transport in 2022). The aim of this study was to analyze German broiler chicken transport (n = 14,054) to the slaughterhouse between January 2022 and May 2023 with regard to the dead-on-arrival (DOA) rate and the possible influencing factors. Therefore, the relation between the total amount of animals per transport, the duration and distance of the transport, the planned stocking density in the transport cages, the average daily temperature and time of day and season of the transport as well as the DOA rate were statistically evaluated. The results showed a mean DOA rate of 0.09% (SD 0.09). Transport conducted at midday (11:00 to 17:00) showed higher DOA rates (p < 0.05) than transport at other times (day split into 6 h intervals). The highest mean DOA rate (0.10%) was found in the fall, followed by the winter, while transport in the spring and summer resulted in the lowest DOA rate (p < 0.05). All in all, the relatively low DOA rate (%) in Germany indicates the good standard of their broiler transport compared to available data from research in other European countries.

ABSTRACT: Broiler meat is the predominant source of Salmonella as a foodborne pathogen. Several control strategies have focused on the reduction of Salmonella spp. levels at different production stages. However, the persistence of Salmonella between consecutive flocks is still of great concern. This study was designed to understand the cause of reinfection in broiler flocks due to survival of Salmonella in feeding lines of related matrices. Salmonella (S.) Enteritidis, S. Infantis, and S. Typhimurium isolated from broiler farms in North-West Germany were used. Four types of matrices (phosphate buffer saline (PBS), dietary plant fat, fat with feed mixture, and feed) were applied to evaluate Salmonella survival (with the initial dose about 8.0 log10 CFU/mL) during a simulation of 4 production cycles. To evaluate the growth and survival status of Salmonella ISO 6579-1:2017 were performed (quantitatively by plate count method (PCM) and most probable number method (MPN)) and qualitatively) at 5 defined time points (−7, 0, 4, 7, and 35 d). In all matrices and for the 3 serovars, the Salmonella count decreased at the end of the fourth cycle in comparison to the beginning of the experimental infection, and was still cultivated except for fat matrix. The PBS matrices showed the highest survival level of Salmonella and did not decline drastically by the end of the fourth cycle (5.93 ± 0.00, 5.87 ± 0.02, 5.73 ± 0.05 log10 CFU/mL, respectively). However, the fat matrices showed the lowest survival level for the 3 isolates at d 35 since the first cycle (0 log10 CFU/mL using PCM). Regarding the fat-feed mixture, and feed matrices, there was a fluctuation in the survival rate of Salmonella (all serovars) within each cycle. For the qualitative method, the 3 serovars persisted in all matrices until the end of the fourth cycle except for fat matrices. The present study highlights the ability of Salmonella to survive for a long time in different temperatures and matrices despite efficient cleaning and disinfection processes in the feeding lines, which may influence reinfection with Salmonella in poultry houses.

Campylobacteriosis is the most commonly reported bacterial foodborne disease in the European Union. Its transmission is often associated with the consumption of poultry meat. In 2018, Regulation (EC) No. 2017/1495 introduced a process hygiene criterion and with this, the testing requirements for Campylobacter. The results of microbiological testing for Campylobacter of chicken carcass neck skin samples from several slaughter lines in Northwest Germany collected by the food business operators and contamination levels (cfu/g Campylobacter) of these samples were analysed from 2018 to 2021. Classification into three different categories was made based on contamination levels. The proportion of highly contaminated (category three) neck samples (>1000 cfu/g) decreased from 2018 to 2021. Our analysis showed a relationship between the number of neck samples with high Campylobacter contamination levels (>1000 cfu/g) and human cases in Northwest Germany. Spearman’s rank test (p < 0.01) showed a higher correlation in 2018 (0.66) and 2019 (0.58) compared to 2020 and 2021. Campylobacter enteritis cases in Northwest Germany stayed at a low level in 2020 and 2021. It remains unclear whether the decrease in reported Campylobacter enteritis cases is related to a decrease in Campylobacter levels on chicken carcasses or due to other reasons like underreporting during the COVID-19 pandemic, and therefore must be investigated in further analyses.

The aim of this study was to evaluate the effect of slatted flooring beneath waterlines in broiler barns on litter quality and, subsequently, footpad health. The hypothesis tested was that installing slatted flooring underneath waterlines helps to improve litter quality and thus reduces footpad diseases, enhancing animal welfare as a result. Five experimental runs with two groups were conducted. Each run was defined as one fattening period of 32 days and consisted of 15,000 broiler Ross 308 of both sexes. Every barn was divided into three areas (drinkers, feeders, and comfort area) for weekly sampling. No influence on growth performance was noted. The slatted flooring influenced the litter quality by preventing the litter in the experimental group (EG = 690 ± 167 g/kg DM) from becoming moisture until day 14 of the fattening period compared to the control group (CON = 636 ± 198 g/kg DM). The footpad health was also influenced by using slatted flooring, with lower camera-based footpad scores in the EG (8.80) compared to CON (22.0) at the slaughterhouse (p = 0.0258). Installing slatted flooring beneath the waterline reduced the moisture of the litter compared to the control barn in the first two weeks of age and showed a positive effect on the footpad health of the broilers at the end of fattening, which indicates an improvement in animal welfare.

This study aimed to evaluate the influences of different flooring designs and feed particle sizes on the spread of Salmonella (S.) in broiler chickens. Birds (n = 480) were allocated to four different housing systems (fully littered with and without floor heating, partially and fully slatted flooring with sand bath) and two dietary treatments (finely and coarsely ground diets) in 24 boxes. Two broilers per box were experimentally infected with S. Enteritidis (8.00 log10 CFU/bird) at d 17. Salmonella prevalence in caecal contents and the liver was highest in broilers housed on fully slatted floor until d 36/37 (88.1% and 91.5%, respectively), and lowest in litter flooring (caecal content 64.4%) and litter flooring with floor heating (liver 61.7%). In turn, broilers on littered flooring expressed the lowest Salmonella counts in caecal content at d 36/37 (2.21 ± 1.75 log10 CFU/g), partial slatted flooring the highest (3.76 ± 1.46 log10 CFU/g). The mean Salmonella count in the caecal content was significantly lower for birds fed a coarsely ground diet (0.96 and 1.94 log10 CFU/g) than a finely ground diet (5.07 and 3.34 log10 CFU/g) at d 23 and d 36/37, respectively (p < 0.0001). Slatted flooring with a sand bath did not show advantages in terms of Salmonella reduction, whereas the coarsely ground diet markedly reduced the spread of Salmonella.

The aim of the present study was to evaluate the effects of feed particle size and flooring designs on organ traits, performance and pododermatitis in broilers. A total of 480 broilers (Ross 308) of both sexes were randomly assigned to two feeding groups (finely or coarsely ground pelleted diets; with addition of 5% to 10% intact wheat in coarsely diets) and four different housing systems (litter; litter with floor heating; partially or fully slatted floor) with three subgroups each. A coarse diet increased the final gizzard and pancreas weights (p < 0.001) while decreasing the risk of Isthmus gastrici dilatation compared to a fine diet (p < 0.001). Broilers fed a coarse diet displayed an increased final body weight (p = 0.023) and led to a favourable feed conversion ratio. Final body weight was the highest (p < 0.001) for birds housed on partially or fully slatted floor. Housing birds on litter with floor heating showed the lowest pododermatitis scoring (p < 0.001). It seems to be favourable to use coarse diets for organ development, whereas slatted floors seem to foster enlargement of the Isthmus gastrici. Increasing growth performance was possible both when using coarse diets or slatted floors.

In 2016, Campylobacter was the most commonly reported gastrointestinal bacterial pathogen in humans in the European Union with 246,307 reported cases. Of these cases, 83.6% were Campylobacter jejuni. The objective of the present study was to investigate to what extent an infection with C. jejuni alters the feed intake behavior of broiler chicks in terms of protein intake. This was done to see if, conversely, measures of control could be derived. In total, 300 commercial broilers of the Ross 308 line were allocated to four different groups, including five replications of 15 chickens each. In two groups, a conventional diet [216 g CP/kg dry matter (DM)] and in the two choice diet groups, diets with different levels of crude protein (286 and 109 g CP/kg DM, respectively) were fed between day 14 and day 42. An intake of both choice diets at a ratio of 3:2 resulted in a composition of consumed feed identical to that of the control concerning composition, energy and nutrient content. One group of each feeding concept was infected artificially with C. jejuni at day 21 by applying an oral C. jejuni-suspension containing 5.26 ± 0.08 log10 colony forming units of C. jejuni to three out of 15 chickens. No significant differences concerning C. jejuni prevalence and excretion could be seen. Broilers infected with C. jejuni chose a higher amount of the high protein choice diet in comparison to C. jejuni negative broilers. This resulted in a significantly (p < 0.0001) higher content of crude protein in the consumed diet (198 ± 3.09 g CP/kg DM and 208 ± 8.57 g CP/kg DM, respectively). Due to C. jejuni infection, a significant increase in crude mucin in excreta at day 42 was seen in experimentally infected groups (62.6 ± 4.62 g/kg DM vs. 59.6 ± 6.21 g/kg DM, respectively; p = 0.0396). There were significantly deeper crypts in infected birds (256 ± 71.6 vs. 234 ± 61.3 μm). In summary, C. jejuni infections significantly alter the feed intake behavior of broiler chickens regarding higher protein intake. Therefore, targeted manipulation of protein supply could be tested for limiting the spread of infection.

Sustainably produced poultry meat with consideration of animal health poses a challenge for broiler production. Low protein diets with high amounts of synthetic amino acids (AAs) like methionine (Met) are the consequence. In a five-week feeding trial, 360 broilers (Ross 308) assigned to four feeding groups were offered protein-reduced complete diets (starter: 20% crude protein (CP); grower: 18.5% CP; finisher: 17.5% CP), supplemented with essential AAs. The “MHA” group received DL-2-hydroxy-4-(methylthio) butanoic acid (DL-HMTBA; trade name: MHA®), groups “L” and “DL” the respective Met source in equivalent concentrations each exceeding the nutritional recommendations. “R-MHA” (“R” for “reduced”) received the minimum required level (using MHA as Met source). Performance exceeded performance goals without differences between the groups. The average feed conversion ratio (FCR) amounted to 1.35. The carcass/body weight ratio of R-MHA was significantly lower (0.782) compared to DL (0.808) and L (0.809). Breast meat of R-MHA contained significantly more fat (144 g/kg dry matter (DM)) compared to L (104 g/kg DM) and significantly lower CP content (R-MHA: 838 g/kg DM; L: 875 g/kg DM). The results indicated possible improvement in slaughter yield by protein-reduced diets supplemented with L-Met, thus recommending further research focusing on the Met influence.

Litter quality has a significant influence on the performance and foot pad health in poultry. The objective of this study was to evaluate the effects of different types of flooring designs on the performance and foot pad health in fattening broilers and turkeys. Three trials were conducted for each species using a total of 720 Ross 308 broilers and 720 Big 6 turkeys. After day seven, animals were randomly assigned to four groups with three subgroups each: G1—floor pens with litter, G2—floor pens with litter and floor heating, G3—partially-slatted flooring, including a littered area, and G4—fully-slatted flooring with a sand bath (900 cm2). Animals of both species had a significantly higher final body weight at dissection (day 36) after being reared on fully-slatted floors compared to common littered floors. In turkeys, the feed conversion ratio was worse in G4 (1.53 ± 0.04) than in G1 (1.47 ± 0.02) and G2 (1.48 ± 0.03). Water to feed ratio was significantly higher in G2 than other groups. Turkeys’ foot pad health was significantly better in G4 than in other groups beginning at day 21. In turkeys, platforms with slatted floors that allow for temporary separation of the feet from the litter could lead to improvements in foot pad health which could better enable the realization of species-specific behaviours and activities in littered areas.