Search

Aims: Aromatic amines with diverse physical characteristics are often employed as antioxidants and precursors to pharmaceutical products. As the traditional chemical methods pose serious environmental pollution, there is an arising interest in biomanufacturing aromatic amines from renewable feedstocks., Materials and Results: We report the establishment of a bacterial platform for synthesizing three types of aromatic amines, namely, tyramine, dopamine and phenylethylamine. First, we expressed aromatic amino acid decarboxylase from Enterococcus faecium (pheDC) in an Escherichia coli strain with increasing shikimate (SHK) pathway flux towards L-tyrosine. We found that glycerol served as a better carbon source than glucose, resulting in 940 ± 46 mg/L tyramine from 4% glycerol. Next, the genes of lactate dehydrogenase (ldhA), pyruvate formate lyase (pflB), phosphate acetyltransferase (pta) and alcohol dehydrogenase (adhE) were deleted to mitigate the fermentation by-product formation. The tyramine level was further increased to 1.965 ± 0.205 g/L in the shake flask, which was improved by 2.1 times compared with that of the parental strain. By using a similar strategy, we also managed to produce 703 ± 21 mg/L dopamine and 555 ± 50 mg/L phenethylamine., Conclusions: We demonstrated that the knockout of ldhA-pflB-pta-adhE is an effective strategy for improving aromatic amine productions., Significance and Impact of the Study: This study achieved the highest aromatic amine titres in E. coli under shake flask reported to date., (© 2022 Society for Applied Microbiology.)

Successful adaptation of Escherichia coli to constant environmental challenges demands the operation of a wide range of regulatory control mechanisms, some of which are global, while others are specific. Here, we show that the ability of acetate-negative phenotype strains of E. coli devoid of acetate kinase (AK) and phosphotransacetylase (PTA) to assimilate acetate when challenged at the end of growth on acetogenic substrates is explicable by the co-expression of acetyl CoA-synthetase (AcCoA-S) and acetate permease (AP). Furthermore, mRNA transcript measurements for acs and aceA , together with the enzymatic activities of their corresponding enzymes, acetyl CoA synthetase (AcCoA-S) and isocitrate lyase (ICL), clearly demonstrate that the expression of the two enzymes is inextricably linked and triggered in response to growth rate threshold signal (0.4 h -1 ± 0.03: n4). Interestingly, further restriction of carbon supply to the level of starvation led to the repression of acs (AcCoA-S), ackA (AK) and pta (PTA). Further, we provide evidence that the reaction sequence catalysed by PTA, AK and AcCoA-S is not in operation at low growth rates and that the reaction catalysed by AcCoA-S is not merely an ATP-dissipating reaction but rather advantageous, as it elevates the available free energy (Δ G °) in central metabolism. Moreover, the transcriptomic data reinforce the view that the expression of PEP carboxykinase is essential in gluconeogenic phenotypes.

L-tryptophan (L-trp) is a precursor of various bioactive components and has great pharmaceutical interest. However, due to the requirement of several precursors and complex regulation of the pathways involved, the development of an efficient L-trp production strain is challenging. In this study, Escherichia coli (E. coli) strain KW001 was designed to overexpress the L-trp operator sequences (trpEDCBA) and 3-deoxy-D-arabinoheptulosonate-7-phosphate synthase (aroG fbr ). To further improve the production of L-trp, pyruvate kinase (pykF) and the phosphotransferase system HPr (ptsH) were deleted after inactivation of repression (trpR) and attenuation (attenuator) to produce strain KW006. To overcome the relatively slow growth and to increase the transport rate of glucose, strain KW018 was generated by combinatorial regulation of glucokinase (galP) and galactose permease (glk) expression. To reduce the production of acetic acid, strain KW023 was created by repressive regulation of phosphate acetyltransferase (pta) expression. In conclusion, strain KW023 efficiently produced 39.7 g/L of L-trp with a conversion rate of 16.7% and a productivity of 1.6 g/L/h in a 5 L fed-batch fermentation system.

Escherichia coli excretes acetate upon growth on fermentable sugars, but the regulation of this production remains elusive. Acetate excretion on excess glucose is thought to be an irreversible process. However, dynamic 13 C-metabolic flux analysis revealed a strong bidirectional exchange of acetate between E. coli and its environment. The Pta-AckA pathway was found to be central for both flux directions, while alternative routes (Acs or PoxB) play virtually no role in glucose consumption. Kinetic modelling of the Pta-AckA pathway predicted that its flux is thermodynamically controlled by the extracellular acetate concentration in vivo. Experimental validations confirmed that acetate production can be reduced and even reversed depending solely on its extracellular concentration. Consistently, the Pta-AckA pathway can rapidly switch from acetate production to consumption. Contrary to current knowledge, E. coli is thus able to co-consume glucose and acetate under glucose excess. These metabolic capabilities were confirmed on other glycolytic substrates which support the growth of E. coli in the gut. These findings highlight the dual role of the Pta-AckA pathway in acetate production and consumption during growth on glycolytic substrates, uncover a novel regulatory mechanism that controls its flux in vivo, and significantly expand the metabolic capabilities of E. coli., Competing Interests: The authors declare no competing financial interests.

We demonstrate metabolic enzyme ligation using a transpeptidase (Staphylococcal sortase A) in the microbial cytoplasm for the redirection of metabolic flux through metabolic channeling. Here, sortase A expression was controlled by the lac promoter to trigger metabolic channeling by the addition of isopropyl-β-d-thiogalactopyranoside (IPTG). We tested covalent linking of pyruvate-formate lyase and phosphate acetyltransferase by sortase A-mediated ligation and evaluated the production of acetate. The time point of addition of IPTG was not critical for facilitating metabolic enzyme ligation, and acetate production increased upon expression of sortase A. These results show that sortase A-mediated enzyme ligation enhances an acetate-producing flux in E. coli. We have validated that sortase A-mediated enzyme ligation offers a metabolic channeling approach to redirect a central flux to a desired flux.

Acetate accumulation during the fermentation process of Escherichia coli FB-04, an L-tryptophan production strain, is detrimental to L-tryptophan production. In an initial attempt to reduce acetate formation, the phosphate acetyltransferase gene (pta) from E. coli FB-04 was deleted, forming strain FB-04(Δpta). Unfortunately, FB-04(Δpta) exhibited a growth defect. Therefore, pta was replaced with a pta variant (pta1) from E. coli CCTCC M 2016009, forming strain FB-04(pta1). Pta1 exhibits lower catalytic capacity and substrate affinity than Pta because of a single amino acid substitution (Pro69Leu). FB-04(pta1) lacked the growth defect of FB-04(Δpta) and showed improved fermentation performance. Strain FB-04(pta1) showed a 91% increase in L-tryptophan yield in flask fermentation experiments, while acetate production decreased by 35%, compared with its parent FB-04. Throughout the fed-batch fermentation process, acetate accumulation by FB-04(pta1) was slower than that by FB-04. The final L-tryptophan titer of FB-04(pta1) reached 44.0 g/L, representing a 15% increase over that of FB-04. Metabolomics analysis showed that the pta1 genomic substitution slightly decreased carbon flux through glycolysis and significantly increased carbon fluxes through the pentose phosphate and common aromatic pathways. These results indicate that this strategy enhances L-tryptophan production and decreases acetate accumulation during the L-tryptophan fermentation process.

3-Hydroxypropionic acid (3-HP) is an important platform chemical for the biobased chemical industry. Lactobacillus reuteri produces 3-HP from glycerol via 3-hydroxypropionaldehyde (3-HPA) through a CoA-dependent propanediol utilization (Pdu) pathway. This study was performed to verify and evaluate the pathway comprising propionaldehyde dehydrogenase (PduP), phosphotransacylase (PduL), and propionate kinase (PduW) for formation of 3-HP from 3-HPA. The pathway was confirmed using recombinant Escherichia coli co-expressing PduP, PduL and PduW of L. reuteri DSM 20016 and mutants lacking expression of either enzyme. Growing and resting cells of the recombinant strain produced 3-HP with a yield of 0.3mol/mol and 1mol/mol, respectively, from 3-HPA. 3-HP was the sole product with resting cells, while growing cells produced 1,3-propanediol as co-product. 3-HP production from glycerol was achieved with a yield of 0.68mol/mol by feeding recombinant E. coli with 3-HPA produced by L. reuteri and recovered using bisulfite-functionalized resin., (Copyright © 2015 Elsevier Ltd. All rights reserved.)

Reducing the accumulation of acetate in Escherichia coli cultures can decrease carbon efflux as by-products and reduce acetate toxicity, and therefore enable high cell density cultivation. The concentration of intracellular amino acids can be decreased by genetic modifications of the corresponding amino acid transport systems. This can increase the levels of amino acids in the fermentation broth by decreasing the feedback inhibition on the corresponding biosynthetic pathways. Here, the effects of genetic manipulation of phosphate acetyltransferase (pta), high affinity tryptophan transporter (mtr) and aromatic amino acid exporter (yddG) on L-tryptophan production were investigated. The pta mutants accumulated less acetate and showed higher capacity for producing L-tryptophan as compared with the parental strain. The strains lacking mtr, or overexpressed yddG, or with the both mtr knockout and yddG overexpression, accumulated lower concentrations of intracellular tryptophan but higher production of extracellular L-tryptophan. In the L-tryptohan fed-batch fermentation of an E. coli derived from TRTH0709/pMEL03 having deletion of pta-mtr and overexpression of yddG in a 30-L fermentor, the maximum concentration of L-tryptophan (48.68 g/L) was obtained, which represented a 15.96 % increase as compared with the parental strain. Acetate accumulated to a concentration of 0.95 g/L. The intracellular concentration of L-tryptophan was low, and the glucose conversion rate reached a high level of 21.87 %, which was increased by 15.53 % as compared with the parent strain.

Microbial biosynthesis of fatty acid like chemicals from renewable carbon sources has attracted significant attention in recent years. Free fatty acids can be used as precursors for the production of fuels or chemicals. Wild type E. coli strains produce fatty acids mainly for the biosynthesis of lipids and cell membranes and do not accumulate free fatty acids as intermediates in lipid biosynthesis. However, free fatty acids can be produced by breaking the fatty acid elongation through the overexpression of an acyl-ACP thioesterase. Since acetyl-CoA might be an important factor for fatty acid synthesis (acetate formation pathways are the main competitive pathways in consuming acetyl-CoA or pyruvate, a precursor of acetyl-CoA), and the long chain fatty acid CoA-ligase (FadD) plays a pivotal role in the transport and activation of exogenous fatty acids prior to their subsequent degradation, we examined the composition and the secretion of the free fatty acids in four different strains including the wild type MG1655, a mutant strain with inactivation of the fatty acid beta-oxidation pathway (fadD mutant (ML103)), and mutant strains with inactivation of the two major acetate production pathways (an ack-pta (acetate kinase/phosphotransacetylase), poxB (pyruvate oxidase) double mutant (ML112)) and a fadD, ack-pta, poxB triple mutant (ML115). The engineered E. coli cells expressing acyl-ACP thioesterase with glucose yield is higher than 40% of theoretical yield. Compared to MG1655(pXZ18) and ML103(pXZ18), acetate forming pathway deletion strains such as ML112(pXZ18) and ML115(pXZ18) produced similar quantity of total free fatty acids, which indicated that acetyl-CoA availability does not appear to be limiting factor for fatty acid production in these strains. However, these strains did show significant differences in the composition of free fatty acids. Different from MG1655(pXZ18) and ML103(pXZ18), acetate formation pathway deletion strains such as ML112(pXZ18) and ML115(pXZ18) produced similar level of C14, C16:1 and C16 free fatty acids, and the free fatty acid compositions of both strains did not change significantly with time. In addition, the strains bearing the fadD mutation showed significant differences in the quantities of free fatty acids found in the broth. Finally, we examined two potential screening methods for selecting and isolating high free fatty acids producing cells., (Copyright © 2012 Elsevier Inc. All rights reserved.)

Glycerol has become an ideal feedstock for producing fuels and chemicals. Here, five technological schemes for optically pure D: -lactic acid production from raw glycerol were designed, simulated, and economically assessed based on five fermentative scenarios using engineered Escherichia coli strains. Fermentative scenarios considered different qualities of glycerol (pure, 98 wt.%, and crude, 85 wt.%) with concentrations ranging from 20 to 60 g/l in the fermentation media, and two fermentation stages were also analyzed. Raw glycerol (60 wt.%) was considered as the feedstock feeding the production process in all cases; then a purification process of raw glycerol up to the required quality was required. Simulation processes were carried out using Aspen Plus, while economic assessments were performed using Aspen Icarus Process Evaluator. D: -Lactic acid recovery and purification processes were based on reactive extraction with tri-n-octylamine using dichloromethane as active extractant agent. The use of raw glycerol represents only between 2.4% and 7.8% of the total production costs. Also, the total production costs obtained of D: -lactic acid in all cases were lower than its sale price indicating that these processes are potentially profitable. Thus, the best configuration process requires the use of crude glycerol diluted at 40 g/l with total glycerol consumption and with D: -lactic acid recovering by reactive extraction. The lowest obtained total production cost was 1.015 US$/kg with a sale price/production cost ratio of 1.53.

Objective: To study the effects of gene pta disruption on biosynthesis of L-tryptophan., Methods: The pta gene of the L-tryptophan producing strain E. coli TRTH was disrupted by Red recombination technology and a pta mutant E. coli TRTHdeltapta was constructed. Fed-batch fermentation of E. coli TRTHdeltapta was carried out in 30-Liter fermentor to investigate the biomass, L-tryptophan production, organic acid content and the concentration of NH4+, lactate, pyruvate and succinate. The metabolic flux balance model of L-tryptophan synthesis by E. coli was established. Based on this model, the practical metabolic flux distribution of E. coli and its pta mutant were determined with the linear program planted in MATLAB software., Results: Compared with E. coli TRTH, the pta mutant was able to maintain higher growth rate at exponential phase, the final biomass and the L-tryptophan production were increased by 52.7% and 46.8% respectively. Meanwhile, the data analysis of organic acids accumulated during fed-batch culture showed that the concentration of acetate was decreased to 2.5 g/L, which was only 19.5% of that of the parental strain; as the decreased concentration of succinate, the accumulation of pyruvate and lactate was increased. The concentration of Na+, K+, PO4(3-) were consistent with E. coli TRTH during the fed-batch culture, the concentration of NH4+ was decreased by 33.2%. The metabolic flux analysis indicated that EMP pathway and TCA cycle were reduced by 7.4% and 32.2% respectively, but PP pathway was increased by 8.4% compared with E. coli TRTH during the middle and late period of the fed-batch culture., Conclusion: In the process of L-tryptophan fermentation, pta gene deletion in E. coli TRTH led to change in metabolic flux and acetate content, which derepressed its inhibition on cell growth and production of L-tryptophan and finally made a substantial increase of bacterial biomass and L-tryptophan production.

Individual deletions of acs and aceA genes in E. coli B (BL21) showed little difference in the metabolite accumulation patterns but deletion of the ackA gene alone or together with pta showed acetic acid gradually accumulated to 3.1 and 1.7 g/l, respectively, with a minimal extended lag in bacterial growth and a higher pyruvate formation. Single poxB deletion in E. coli B (BL21) or additional poxB deletion in the ackA-pta mutants did not change the acetate accumulation pattern. When the acetate production genes (ackA-pta-poxB) were deleted in E. coli B (BL21) acetate still accumulated. This may be an indication that perhaps acetate is not only a by-product of carbon metabolism; it is possible that acetate plays also a role in other cellular metabolite pathways. It is likely that there are alternative acetate production pathways.

Background: The biotechnology industry has extensively exploited Escherichia coli for producing recombinant proteins, biofuels etc. However, high growth rate aerobic E. coli cultivations are accompanied by acetate excretion i.e. overflow metabolism which is harmful as it inhibits growth, diverts valuable carbon from biomass formation and is detrimental for target product synthesis. Although overflow metabolism has been studied for decades, its regulation mechanisms still remain unclear., Results: In the current work, growth rate dependent acetate overflow metabolism of E. coli was continuously monitored using advanced continuous cultivation methods (A-stat and D-stat). The first step in acetate overflow switch (at μ = 0.27 ± 0.02 h(-1)) is the repression of acetyl-CoA synthetase (Acs) activity triggered by carbon catabolite repression resulting in decreased assimilation of acetate produced by phosphotransacetylase (Pta), and disruption of the PTA-ACS node. This was indicated by acetate synthesis pathways PTA-ACKA and POXB component expression down-regulation before the overflow switch at μ = 0.27 ± 0.02 h(-1) with concurrent 5-fold stronger repression of acetate-consuming Acs. This in turn suggests insufficient Acs activity for consuming all the acetate produced by Pta, leading to disruption of the acetate cycling process in PTA-ACS node where constant acetyl phosphate or acetate regeneration is essential for E. coli chemotaxis, proteolysis, pathogenesis etc. regulation. In addition, two-substrate A-stat and D-stat experiments showed that acetate consumption capability of E. coli decreased drastically, just as Acs expression, before the start of overflow metabolism. The second step in overflow switch is the sharp decline in cAMP production at μ = 0.45 h(-1) leading to total Acs inhibition and fast accumulation of acetate., Conclusion: This study is an example of how a systems biology approach allowed to propose a new regulation mechanism for overflow metabolism in E. coli shown by proteomic, transcriptomic and metabolomic levels coupled to two-phase acetate accumulation: acetate overflow metabolism in E. coli is triggered by Acs down-regulation resulting in decreased assimilation of acetic acid produced by Pta, and disruption of the PTA-ACS node.

The Escherichia coli genes pta and eutD encode proteins containing the phosphate-acetyltransferase domain. EutD is composed only by this domain and belongs to the ethanolamine operon. This enzyme has not been characterized yet, and its relationship to the multimodular E. coli phosphotransacetylase (Pta) remains unclear. In the present work, a detailed characterization of EutD from E. coli (EcEutD) was performed. The enzyme is a more efficient phosphotransacetylase than E. coli Pta (EcPta) in catalyzing its reaction in either direction and assembles as a dimer, being differentially modulated by EcPta effectors. When comparing EutD and Pta, both from E. coli, certain divergent regions of the primary structure responsible for their unique properties can be found. The growth on acetate of the E. coli pta acs double-mutant strain, was complemented by either introducing EcEutD or by inducing the eut operon with ethanolamine. In this case, the expression of a phosphotransacetylase different from Pta was confirmed by activity assays. Overall, the results indicate that EcEutD and Pta, although able to catalyse the same reaction, display differential efficiency and regulation, and also differ in the induction of their expression. However, under certain growth conditions, they can fulfil equal roles in E. coli metabolism.

Escherichia coli phosphotransacetylase (Pta) catalyzes the reversible interconversion of acetyl-CoA and acetyl phosphate. Both compounds are critical in E. coli metabolism, and acetyl phosphate is also involved in the regulation of certain signal transduction pathways. Along with acetate kinase, Pta plays an important role in acetate production when E. coli grows on rich medium; alternatively, it is involved in acetate utilization at high acetate concentrations. E. coli Pta is composed of three different domains, but only the C-terminal one, called PTA_PTB, is specific for all Ptas. In the present work, the characterization of E. coli Pta and deletions from the N-terminal region were performed. E. coli Pta acetyl phosphate-forming and acetyl phosphate-consuming reactions display different maximum activities, and are differentially regulated by pyruvate and phosphoenolpyruvate. These compounds activate acetyl phosphate production, but inhibit acetyl-CoA production, thus playing a critical role in defining the rates of the two Pta reactions. The characterization of three truncated Ptas, which all display Pta activity, indicates that the substrate-binding site is located at the C-terminal PTA_PTB domain. However, the N-terminal P-loop NTPase domain is involved in expression of the maximal catalytic activity, stabilization of the hexameric native state, and Pta activity regulation by NADH, ATP, phosphoenolpyruvate, and pyruvate. The truncated protein Pta-F3 was able to complement the growth on acetate of an E. coli mutant defective in acetyl-CoA synthetase and Pta, indicating that, although not regulated by metabolites, the Pta C-terminal domain is active in vivo.

Background: Acetate metabolism in Escherichia coli plays an important role in the control of the central metabolism and in bioprocess performance. The main problems related to the use of E. coli as cellular factory are i) the deficient utilization of carbon source due to the excretion of acetate during aerobic growth, ii) the inhibition of cellular growth and protein production by acetate and iii) the need for cofactor recycling (namely redox coenzymes and free CoASH) to sustain balanced growth and cellular homeostasis., Results: This work analyzes the effect of mutations in the acetate excretion/assimilation pathways, acetyl-CoA synthethase (acs) and phosphotransacetylase (pta), in E. coli BW25113 grown on glucose or acetate minimal media. Biomass and metabolite production, redox (NADH/NAD+) and energy (ATP) state, enzyme activities and gene expression profiles related to the central metabolism were analyzed. The knock-out of pta led to a more altered phenotype than that of acs. Deletion of pta reduced the ability to grow on acetate as carbon source and strongly affected the expression of several genes related to central metabolic pathways., Conclusion: Results showed that pta limits biomass yield in aerobic glucose cultures, due to acetate production (overflow metabolism) and its inefficient use during glucose starvation. Deletion of pta severely impaired growth on acetate minimal medium and under anaerobiosis due to decreased acetyl-coenzyme A synthethase, glyoxylate shunt and gluconeogenic activities, leading to lower growth rate. When acetate is used as carbon source, the joint expression of pta and acs is crucial for growth and substrate assimilation, while pta deletion severely impaired anaerobic growth. Finally, at an adaptive level, pta deficiency makes the strain more sensitive to environmental changes and de-regulates the central metabolism.

In vivo accumulation of D-serine by Escherichia coli CFT073 leads to elevated expression of PAP fimbriae and hemolysin by an unknown mechanism. Loss of D-serine catabolism by CFT073 leads to a competitive advantage during murine urinary tract infection (UTI), but loss of both D- and L-serine catabolism results in attenuation. Serine is the first amino acid to be consumed in closed tryptone broth cultures and precedes the production of acetyl phosphate, a high-energy molecule involved in intracellular signaling, and the eventual secretion of acetate. We propose that the colonization defect associated with the loss of serine catabolism is due to perturbations of acetate metabolism. CFT073 grows more rapidly on acetogenic substrates than does E. coli K-12 isolate MG1655. As shown by transcription microarray results, D-serine is catabolized into acetate via the phosphotransacetylase (pta) and acetate kinase (ackA) genes while downregulating expression of acetyl coenzyme A synthase (acs). CFT073 acs, which is unable to reclaim secreted acetate, colonized mouse bladders and kidneys in the murine model of UTI indistinguishably from the wild type. Both pta and ackA are involved in the maintenance of intracellular acetyl phosphate. CFT073 pta and ackA mutants were screened to investigate the role of acetyl phosphate in UTI pathogenesis. Both single mutants are at a competitive disadvantage relative to the wild type in the kidneys but normally colonize the bladder. CFT073 ackA pta was attenuated in both the bladder and the kidneys. Thus, we demonstrate that CFT073 is adapted to acetate metabolism as a result of requiring a proper cycling of the acetyl phosphate pathway for colonization of the upper urinary tract.

A tightly regulated gene expression system composed of a single-copy target gene under the control of a lac promoter derivative and lacI gene in a multicopy plasmid is proposed, and its ability to control the flux of a metabolic pathway is demonstrated. A model system to control the flux of acetyl-CoA to acetyl phosphate was constructed by integrating pta, a gene encoding phosphotransacetylase, under a tac promoter into the chromosome of E. coli with a pta-negative background and transforming a multicopy plasmid containing the lac iota(Q) gene into the strain. The production rate of acetate was shown to be tightly controlled when varying the concentration of the inducer (IPTG) in the model system.

Highly reduced E. coli strains, MDS40, MDS41, and MDS42, lacking approximately 15% of the genome, were grown to high cell densities to test their ability to produce a recombinant protein with high yields. These strains lack all transposons and insertion sequences, cryptic prophage and many genes of unknown function. In addition to improving genetic stability, these deletions may reduce the biosynthetic requirements of the cell potentially allowing more efficient production of recombinant protein. Basic growth parameters and the ability of the strains to produce chloramphenicol acetyltransferase (CAT) under high cell density, batch cultivation were assessed. Although growth rate and recombinant protein production of the reduced genome strains are comparable to the parental MG1655 strain, the reduced genome strains were found to accumulate significant amounts of acetate in the medium at the expense of additional biomass. A number of hypotheses were examined to explain the accumulation of acetate, including oxygen limitation, carbon flux imbalance, and metabolic activity of the recombinant protein. Use of a non-catalytic CAT variant identified the recombinant protein activity as the source of this phenomenon; implications for the metabolic efficiency of the reduced genome strains are discussed.

Protein degradation is a central component of the protein quality control system. Here we show that efficient proteolysis in Escherichia coli requires the active acetyl phosphate pathway. Deletion of this pathway, leading to depletion of acetyl phosphate, results in temperature sensitivity and reduced rate of ATP-dependent proteolysis. The effect on proteolysis is general, as can be seen from the slowing down of the degradation of unstable proteins, including puromycin-derived peptides. In addition, reduced intracellular concentrations of acetyl phosphate brings about an increase in the levels of protein aggregates, which contain a wide range of proteins, as expected if a broad spectrum of substrates are involved. Additional outcomes of acetyl phosphate deficiency are elevation in the transcript levels of heat shock genes and increased thermotolerance. In E. coli the acetyl phosphate pathway is the only source of acetyl phosphate, which is a key metabolic compound involved in major cellular processes. In this communication we present evidence for the general role of the acetyl phosphate pathway in protein degradation.

During aerobic growth of Escherichia coli on acetate, the component parts of the 'acetate switch' are turned-on as a consequence of direct competition, on the one hand, between phosphotransacetylase (PTA) and alpha-ketoglutarate dehydrogenase (alpha-KGDH) for their common co-factor free-CoA (HS-CoA) and, on the other hand, between isocitrate lyase (ICL) and isocitrate dehydrogenase (ICDH) for their common substrate isocitrate. Flux analysis revealed that competitions at both junctions in central metabolism are resolved in a precise way, so that the fraction of HS-CoA flux processed through PTA for biosynthesis relative to that processed through alpha-KGDH for energy generation, matches that observed for isocitrate flux through ICL relative to ICDH at the junction of isocitrate. Whereas the mechanism involved in the partition of carbon flux at the level of HS-CoA in central metabolism remains to be unravelled, the competition at the junction of isocitrate is resolved by the reversible phosphorylation/inactivation of ICDH and the operation of the glyoxylate bypass, the expression of which is subject to regulation at the transcriptional and translational levels as well as being dependent on growth rate.

Although the bacterium E. coli is chosen as the host in many bioprocesses, the accumulation of a common byproduct, acetate, is often problematic. Acetate, when present at high levels, will inhibit both cell growth and recombinant protein productivity. In addition, products derived from the central aerobic metabolic pathway often compete with the acetate-producing pathways poxB and ackA-pta for glucose as the substrate. As such, a significant portion of the glucose may be excreted as acetate, wasting substrate that otherwise could have been used for the desired product. We have created mutant E. coli strains with a deletion of either the poxB or the ackA-pta pathway. These two strains, along with the wild-type strain, have been studied in batch reactors over a 12 h time period, at pH 7.0 and 6.0. The wild-type strain has also been studied using glucose as the carbon source. Data were collected to correlate cellular growth, extracellular metabolite production, enzyme activity, and gene expression. Results show that the ackA-pta pathway dominates in exponential phase, and the poxB pathway dominates in stationary phase. The ackA-pta pathway is repressed in acidic environments, whereas the poxB pathway is activated.

The gene coding for alcohol acetyltransferase ( ATF2), which catalyzes the esterification of isoamyl alcohol and acetyl coenzyme A (acetyl-CoA), was cloned from Saccharomyces cerevisiae and expressed in Escherichia coli. This genetically engineered strain of E. coli produced the ester isoamyl acetate when isoamyl alcohol was added externally to the cell culture medium. Various competing pathways at the acetyl-CoA node were inactivated to increase the intracellular acetyl-CoA pool and divert more carbon flux to the ester synthesis pathway. Several strains with deletions in the ackA-pta and/or ldh pathways and bearing the ATF2 on a high-copy-number plasmid were constructed and studied. Compared to the wild-type, ackA-pta and nuo mutants produced higher amounts of ester and an ackA-pta-ldh-nuo mutant lower amounts. Isoamyl acetate production correlated well with intracellular coenzyme A (CoA) and acetyl-CoA levels. The ackA-pta-nuo mutant had the highest intracellular CoA/acetyl-CoA level and hence produced the highest amount of ester (1.75 mM) during the growth phase under oxic conditions and during the production phase under anoxic conditions.

Polythioesters newly emerged as a type of novel polymer and they have showed great potential for application in industries. In this study, genes of butyrate kinase (buk) and phosphotransbutyrylase (ptb) from Clostridium acetobutylicum, and poly (3-hydroxybutyrate) (PHB) synthase gene from Thiocapsa pfennigii were used for construction of a metabolic pathway to synthesize the polythioesters. When 3-mercaptopropionate and 3-hydroxybutyrate were fed, poly (3-mercaptopropoinate) [poly (3MP)] and poly(3-mercaptopropionate-co-3-hydroxybutyrate) [poly(3MP-co-3HB)] were synthesized by recombinant Escherichia coli JM109 (pBPP1) harboring the constructed metabolic pathway. Results indicated clearly that all these genes are necessary for the synthesis of poly(3MP) and poly(3MP-co-3HB).

Expression of the major outer-membrane porins in Escherichia coli is transcriptionally controlled during nutrient limitation. Expression of ompF was more than 40-fold higher under glucose limitation than under nitrogen (ammonia) limitation in chemostat cultures at the same growth rate. In contrast, ompC expression was higher under N limitation. The basis of regulation by nutrient limitation was investigated using mutations affecting expression of porin genes. The influence of cyaA, rpoS, ackA and pta, as well as the two-component envZ-ompR system, was studied under glucose and N limitation in chemostat cultures. A major contributor to low ompF expression under N limitation was negative control by the RpoS sigma factor. RpoS levels were high under N limitation and loss of RpoS resulted in a 19-fold increase in ompF transcription, but little change was observed with ompC. Lack of RpoS under glucose limitation had a lesser stimulatory effect on ompF expression. Porin production was minimally dependent on EnvZ under N limitation due to OmpR phosphorylation by acetyl phosphate. Evidence obtained with pta and ackA mutants suggested that the acetyl phosphate level also regulates porins independently and indirectly via RpoS and other pathways. pta-envZ double mutants had a residual level of porin transcription, implicating alternative means of OmpR phosphorylation under nutrient limitation. Another critical factor in regulation was the level of cAMP, as a cyaA mutant hardly expressed ompF under glucose limitation but boosted ompC. In addition, the role of DNA-binding proteins encoded by hns and himA was tested under glucose limitation: the hns mutation reduced the glucose-limitation peak, but the himA mutation suppressed the hns effect, suggesting a complex web of interrelationships between the DNA-binding proteins. Indeed, multiple inputs and no single regulator were responsible for the high peak of ompF expression under glucose limitation.

A new pathway to synthesize poly(hydroxyalkanoic acids) (PHA) was constructed by simultaneously expressing butyrate kinase (Buk) and phosphotransbutyrylase (Ptb) genes of Clostridium acetobutylicum and the two PHA synthase genes (phaE and phaC) of Thiocapsa pfennigii in Escherichia coli. The four genes were cloned into the BamHI and EcoRI sites of pBR322, and the resulting hybrid plasmid, pBPP1, conferred activities of all three enzymes to E. coli JM109. Cells of this recombinant strain accumulated PHAs when hydroxyfatty acids were provided as carbon sources. Homopolyesters of 3-hydroxybutyrate (3HB), 4-hydroxybutyrate (4HB), or 4-hydroxyvalerate (4HV) were obtained from each of the corresponding hydroxyfatty acids. Various copolyesters of those hydroxyfatty acids were also obtained when two of these hydroxyfatty acids were fed at equal amounts: cells fed with 3HB and 4HB accumulated a copolyester consisting of 88 mol% 3HB and 12 mol% 4HB and contributing to 68.7% of the cell dry weight. Cells fed with 3HB and 4HV accumulated a copolyester consisting of 94 mol% 3HB and 6 mol% 4HV and contributing to 64.0% of the cell dry weight. Cells fed with 3HB, 4HB, and 4HV accumulated a terpolyester consisting of 85 mol% 3HB, 13 mol% 4HB, and 2 mol% 4HV and contributing to 68.4% of the cell dry weight.

In the cultivation of gene engineered strain of Escherichia coli on glucose medium, excretion and accumulation of acetic acid inhibit not only cell growth but also the the expression of heterologous protein. It is obvious that the desirable host strain maintaining acetate at a low level is one of the approaches to increase the production of recombinant protein. The present article deals with the selection of mutants of E. coli DP19, DP8, which grow on the medium containing pyruvate as the sole carbon source in the presence of 50 mmol/L fluoroacetic acid. It is shown that mutant DP19 is defective in its phosphotransacetylase(PTA) activity and accumulates less acetate in the medium, while DP8 is defective in acetate kinase (ACK) and accumulates similar level of acetate comparing with its parent. Using pta- mutant E. coli DP19 as host, the expression of GL-7ACA acylase gene on the recombinant plasmid pMR24 is improved, and the yield of enzyme activity in flask fermentation is about twice as much as its parent.

In order to study the physiological role of acetate metabolism in Escherichia coli, the growth characteristics of an E. coli W3100 pta mutant defective in phosphotransacetylase, the first enzyme of the acetate pathway, were investigated. The pta mutant grown on glucose minimal medium excreted unusual by-products such as pyruvate, D-lactate, and L-glutamate instead of acetate. In an analysis of the sequential consumption of amino acids by the pta mutant growing in tryptone broth (TB), a brief lag between the consumption of amino acids normally consumed was observed, but no such lag occurred for the wild-type strain. The pta mutant was found to grow slowly on glucose, TB, or pyruvate, but it grew normally on glycerol or succinate. The defective growth and starvation survival of the pta mutant were restored by the introduction of poly-beta-hydroxybutyrate (PHB) synthesis genes (phbCAB) from Alcaligenes eutrophus, indicating that the growth defect of the pta mutant was due to a perturbation of acetyl coenzyme A (CoA) flux. By the stoichiometric analysis of the metabolic fluxes of the central metabolism, it was found that the amount of pyruvate generated from glucose transport by the phosphoenolpyruvate-dependent phosphotransferase system (PTS) exceeded the required amount of precursor metabolites downstream of pyruvate for biomass synthesis. These results suggest that E. coli excretes acetate due to the pyruvate flux from PTS and that any method which alleviates the oversupply of acetyl CoA would restore normal growth to the pta mutant.

We investigated metabolic engineering of fermentation pathways in Escherichia coli for production of optically pure D- or L-lactate. Several pta mutant strains were examined, and a pta mutant of E. coli RR1 which was deficient in the phosphotransacetylase of the Pta-AckA pathway was found to metabolize glucose to D-lactate and to produce a small amount of succinate by-product under anaerobic conditions. An additional mutation in ppc made the mutant produce D-lactate like a homofermentative lactic acid bacterium. When the pta ppc double mutant was grown to higher biomass concentrations under aerobic conditions before it shifted to the anaerobic phase of D-lactate production, more than 62.2 g of D-lactate per liter was produced in 60 h, and the volumetric productivity was 1.04 g/liter/h. To examine whether the blocked acetate flux could be reoriented to a nonindigenous L-lactate pathway, an L-lactate dehydrogenase gene from Lactobacillus casei was introduced into a pta ldhA strain which lacked phosphotransacetylase and D-lactate dehydrogenase. This recombinant strain was able to metabolize glucose to L-lactate as the major fermentation product, and up to 45 g of L-lactate per liter was produced in 67 h. These results demonstrate that the central fermentation metabolism of E. coli can be reoriented to the production of D-lactate, an indigenous fermentation product, or to the production of L-lactate, a nonindigenous fermentation product.

Carbon sources that can be converted to acetate were added to the growth medium of Escherichia coli wild-type cells. Cells responded with an increased cell division rate. The addition of acetate also caused a decreased synthesis of flagella. Mutants in phosphotransacetylase, which are incapable of synthesizing acetyl phosphate, and mutants in the osmoregulator OmpR divided at a lower rate than did wild-type cells. The mutants did not increase their cell division rate upon the addition of serine, as observed for wild-type cells. These data are consistent with the idea that the previously described effect of serine upon the cell division rate is mediated by acetyl phosphate and phosphorylation of OmpR.

Acetyl coenzyme A synthetase (Acs) activates acetate to acetyl coenzyme A through an acetyladenylate intermediate; two other enzymes, acetate kinase (Ack) and phosphotransacetylase (Pta), activate acetate through an acetyl phosphate intermediate. We subcloned acs, the Escherichia coli open reading frame purported to encode Acs (F. R. Blattner, V. Burland, G. Plunkett III, H. J. Sofia, and D. L. Daniels, Nucleic Acids Res. 21:5408-5417, 1993). We constructed a mutant allele, delta acs::Km, with the central 0.72-kb BclI-BclI portion of acs deleted, and recombined it into the chromosome. Whereas wild-type cells grew well on acetate across a wide range of concentrations (2.5 to 50 mM), those deleted for acs grew poorly on low concentrations (< or = 10 mM), those deleted for ackA and pta (which encode Ack and Pta, respectively) grew poorly on high concentrations (> or = 25 mM), and those deleted for acs, ackA, and pta did not grow on acetate at any concentration tested. Expression of acs from a multicopy plasmid restored growth to cells deleted for all three genes. Relative to wild-type cells, those deleted for acs did not activate acetate as well, those deleted for ackA and pta displayed even less activity, and those deleted for all three genes did not activate acetate at any concentration tested. Induction of acs resulted in expression of a 72-kDa protein, as predicted by the reported sequence. This protein immunoreacted with antiserum raised against purified Acs isolated from an unrelated species, Methanothrix soehngenii. The purified E. coli Acs then was used to raise anti-E. coli Acs antiserum, which immunoreacted with a 72-kDa protein expressed by wild-type cells but not by those deleted for acs. When purified in the presence, but not in the absence, of coenzyme A, the E. coli enzyme activated acetate across a wide range of concentrations in a coenzyme A-dependent manner. On the basis of these and other observations, we conclude that this open reading frame encodes the acetate-activating enzyme, Acs.

In Escherichia coli carrying the poly(3-hydroxyalkanoate) (PHA) biosynthesis pathway on a plasmid (pha+), the function of the ackA (acetate kinase) and pta (phosphotransacetylase) genes is necessary for efficient incorporation of 3-hydroxyvalerate (3-HV) into the copolymer, poly(3-hydroxybutyrate-co-3-hydroxyvalerate) (P(3HB-co-3HV)). Recombinant pha+ E. coli fadR atoC(Con) strains possessing mutations in ackA, pta, or both ackA and pta exhibited substantially reduced levels of 3-HV formation. Conversely, the same strains carrying the ackA gene on a multicopy plasmid exhibited an increase in 3-HV formation concomitant with a large increase in acetate kinase activity. However, if the strain possessing the multicopy ackA+ plasmid was mutant at the pta locus, it lost the ability to incorporate significant amounts of 3-HV into P(3HB-co-3HV). In addition to the ackA pta pathway, there is an inducible activity that can also mediate the incorporation of 3-HV into P(3HB-co-3HV). This pathway is repressed by glucose and is not normally operative in P(3HB-co-3HV) production in recombinant pha+ E. coli strains that are grown using glucose as the major carbon source. It appears likely that this activity is due to an inducible acetyl-CoA synthetase that converts propionate to propionyl-CoA.

Escherichia coli grown in a rich medium excreted acetate and reused the acetate. Using cloned genes and a plasmid with a temperature-sensitive replication origin, three kinds of Pta-Ack pathway deletion mutants were constructed. Acetate production and reuse by wild-type cells grown in the rich medium was confirmed to largely occur through the Pta-Ack pathway. The deletion mutants of the gene encoding phosphotransacetylase secreted pyruvate before the secretion of acetate into the medium. A deletion mutant of the gene encoding acetate kinase grew at a slow rate, but its secretion and use of acetate were rapid. These results indicated that a pathway(s), other than the Pta-Ack pathway, functions in the control of excess carbon flow in the mutants.

We investigated the relationship between Escherichia coli flagellar expression and the regulation of acetyl phosphate synthesis and degradation. Using cells either wild type for acetyl phosphate metabolism or defective for phosphotransacetylase or acetate kinase, or both, we measured flagellar expression and the intracellular concentration of acetyl phosphate relative to growth phase and temperature. Under the conditions tested, we found that elevated levels of acetyl phosphate corresponded to inhibition of flagellar synthesis. To extend these observations, we measured the intracellular concentration of acetyl-CoA, the level of expression from the pta and ackA promoters, and the activities of phosphotransacetylase and acetate kinase derived from cell lysates. Relative to increasing culture density, acetyl-CoA levels and expression from both the pta and ackA promoters decreased. Relative to increasing temperature, expression from the ackA promoter decreased and phosphotransacetylase activity increased. In contrast, temperature had little or no effect on either acetate kinase activity or expression from the pta promoter. We propose that cells regulate intracellular acetyl phosphate concentrations relative to growth phase and temperature by modulating the availability of acetyl-CoA, the expression of ackA, and the activity of phosphotransacetylase.

Strains of Escherichia coli lacking all cytoplasmic chemotaxis proteins except CheY swim smoothly under most conditions. However, they tumble when exposed to acetate. Acetate coenzyme A synthetase (EC 6.2.1.1) was thought to be essential for this response. New evidence suggests that the tumbling is mediated instead by acetate kinase (EC 2.7.2.1), which might phosphorylate CheY via acetyl phosphate. In strains that were wild type for chemotaxis, neither acetate coenzyme A synthetase, acetate kinase, nor phosphotransacetylase (EC 2.3.1.8) (and thus acetyl phosphate) was required for responses to aspartate, serine, or sugars sensed by the phosphotransferase system. Thus, acetate-induced tumbling does not appear to play an essential role in chemotaxis in wild-type cells.

Two controls of the phosphate (PHO) regulon require sensor proteins that are protein kinases that phosphorylate the regulator, PhoB, which in turn activates transcription only when phosphorylated. Pi control requires the Pi sensor PhoR; the other control is Pi independent and requires the sensor CreC (formerly called PhoM). Here we describe an additional control of the PHO regulon which is Pi independent and requires neither PhoR nor CreC. This control is regulated by a two-step pathway in carbon metabolism in which acetyl coenzyme A, Pi, and ADP are converted into acetate, coenzyme A, and ATP via the enzymes phosphotransacetylase (Pta) and acetate kinase (AckA). It responds to the synthesis of acetyl phosphate, an intermediate in the Pta-AckA pathway. Since the synthesis of acetyl phosphate via this pathway leads to the incorporation of Pi into ATP, the primary phosphoryl donor in metabolism, we propose that a regulatory coupling(s) may exist between the PHO regulon, which encodes genes for Pi uptake, and genes for enzymes in central metabolism for incorporation of Pi into ATP. Regulatory interactions of this sort may be important in global control. Further, it provides a functional basis for the concept of cross-regulation in the PHO regulon. This is also the first evidence that acetyl phosphate may have a role as an effector of gene regulation.

In Escherichia coli, acetyl phosphate can be formed from acetyl-CoA via the phosphotransacetylase (phosphate acetyltransferase; acetyl-CoA:orthophosphate acetyltransferase, EC 2.3.1.8) reaction and from acetate (plus ATP) via the acetate kinase (ATP:acetate phosphotransferase, EC 2.7.2.1) reaction. By restricting acetyl phosphate formation to the phosphotransacetylase reaction alone, through the use of metabolic inhibitors, we were able to show that, with pyruvate as a source of energy, mutants defective in phosphotransacetylase are unable to transport glutamine, histidine, and methionine. However, with the same energy source, mutants defective in acetate kinase are normal in the transport of these amino acids. The inability of the phosphotransacetylase mutants to transport is due to their presumed inability to form acetyl phosphate, because pyruvate is found to be metabolized to acetyl-CoA in these mutants. Thus acetyl phosphate has been implicated in active transport. Evidence is also presented that neither the protonmotive force nor the ecf gene product is required for the shock-sensitive transport systems.

Mutants of Escherichia coli K12 have been isolated that grow on media containing pyruvate of proline as sole carbon sources despite the presence of 10 or 50 mM-sodium fluoroacetate. Such mutants lack either acetate kinase [ATP: acetate phosphotransferase; EC 2.7.2.1] or phosphotransacetylase [acetyl-CoA: orthophosphate acetyltransferase; EC 2.3.1.8] activity. Unlike wild-type E. coli, phosphotransacetylase mutants do not excrete acetate when growing aerobically or anaerobically on glucose; their anaerobic growth on this sugar is slow. The genes that specify acetate kinase (ack) and phosphotransacetylase (pta) activities are cotransducible with each other and with purF and are thus located at about min 50 on the E. coli linkage map. Although Pta- and Ack- mutants are greatly impaired in their growth on acetate, they incorporate [2-14C]acetate added to cultures growing on glycerol, but not on glucose. An inducible acetyl-CoA synthetase [acetate: CoA ligase (AMP-forming); EC 6.2.1.1] effects this uptake of acetate.