Search

Ultrasound (US) and basic electrolyzed water (BEW) are considered emerging technologies; however, few studies have addressed the combination of both technologies in emulsified meat products. This study aimed to evaluate the individual and combined effect of US (25 kHz; 175 W; 20 min) and BEW (pH 10.99; -92.33 mV) on the microbiological and oxidative profile of low-sodium mortadellas (30% of NaCl reduction) stored for 90 days at 5 °C. The use of BEW alone increased the pH and reduced the redox potential of mortadellas, while the US did not affect these parameters. The combined application of US and BEW reduced the lactic acid bacteria counts by up to 0.36 log CFU/g. In addition, BEW stimulated the growth of lipolytic bacteria. The treatments subjected to US application alone showed a lower growth rate of lipolytic bacteria, lower lipid and protein oxidation, and higher ΔE* values. Therefore, the application of US and BEW may be a promising strategy to improve the microbiological and oxidative quality of mortadella during storage., (Copyright © 2021 Elsevier B.V. All rights reserved.)

Dry-cured rabbit legs were produced with a 50% reduction or replacement of NaCl by KCl and with the addition of monosodium glutamate (MG). The effect of this reformulation on technological, nutritional, and sensory characteristics was evaluated. The sodium reformulation did not show a great impact on Aw, pH, weight loss, and volatile profile of the samples. The samples presented high protein (31.5 to 36.1%) and low fat contents (3.2 to 5.7%). In addition, all essential amino acids presented an amino acid score greater than 1.0. The reformulated samples showed a sodium reduction of 46.2% while the addition of KCl to the formulations provided a healthy Na/K ratio. Oleic acid was the major fatty acid (FA) (31.3% of total FA) and healthy lipid indexes were observed for all samples. Finally, the addition of MG was effective to compensate for the sensory defects caused by sodium reformulation., (Copyright © 2020 Elsevier Ltd. All rights reserved.)

Meat emulsions were made with 50% of phosphate level commonly used in the meat industry, and 0, 25, and 50% NaCl reduction. In addition, salt replacers (KCl, CaCl 2 , or MgCl 2 ) were used in the formulations with 25 and 50% salt reduction, corresponding to 10 and 20% of the total amount of salts added, respectively. After embedding in casings, the samples were sonicated (25 kHz and 230 W) in an ultrasonic bath (US) at 20 °C for 0, 18, and 27 min. The addition of CaCl 2 or MgCl 2 impaired (P < .05) the technological properties of the low-sodium samples. Defects caused by NaCl reduction were not eliminated by 18-min US. However, the combination of KCl and 27-min US eliminated the technological defects caused by the 50% NaCl reduction, with no major impact on lipid oxidation during storage (21 days/4 °C), as observed in the TBARS and sensory profile results. Therefore, it is possible to produce low-phosphate and low-sodium meat emulsions., Competing Interests: Declaration of Competing Interest None., (Copyright © 2020 Elsevier Ltd. All rights reserved.)

Meat emulsions with a reduction of 0, 25, 50, 75, and 100% of phosphate levels were produced. Soon after filling, the pieces were sonicated in an ultrasonic bath (normal mode, 60% amplitude, 25 KHz frequency, 230 W acoustic power, and 33 W L -1 volumetric power) for 0, 9, and 18 min. The technological, oxidative, and sensory quality was evaluated. The reduction of the phosphate content in the non-sonicated samples led to a decrease in the cooking yield and emulsion stability and impaired the texture profile, and the oxidative and sensory quality of the samples. Although the 9-min ultrasound treatment was not effective to compensate for defects caused by the phosphate reduction, the application for 18 min improved the technological quality and did not increase the lipid oxidation. In addition, it allowed reducing most of the sensory defects caused by the reduction of 50% of the phosphate level. Therefore, the US can be useful to produce low-phosphate meat emulsions., (Copyright © 2019 Elsevier Ltd. All rights reserved.)

The use of ultrasound (US) has proven to be an effective tool in the preparation of emulsions. However, the cavitation phenomenon leads to an increase in temperature, which can affect the emulsion stability and the texture. Thus, different US operating modes (degas, normal, and sweep) were applied in meat emulsions for 5.5 min, at 25 kHz frequency and 60% amplitude, and the temperature behavior, yield, emulsion stability, texture, and lipid and protein oxidation were evaluated. The results showed that the wave propagation mode in the US bath exerts a great influence on the increase of temperature of meat emulsions. The distribution of cavitation in normal operating mode significantly favored (P < .001) a higher yield (88.7%) and emulsion stability, with good values of cohesiveness (0.76), hardness (26.9 N), and chewiness (26.1 N), not increasing lipid and protein oxidation. Therefore, this study has proven that that the use of normal US operating mode improved the technological quality of meat emulsions., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

The effect of pork skin (PS) and green banana flour (GBF) on the physicochemical, technological, microbiological, and sensory properties of Bologna-type sausages was assessed. For this propose, six batches were manufactured: control (formulated with 20% fat) and five treatments replacing 20%, 40%, 60%, 80%, and 100% of pork-fat by a mixture of PS, water, and GBF (1:2:2). Fat contents significantly (P<0.05) decreased, while moisture, resistant starch and ash levels significantly (P<0.05) increased with the addition of PS and GBF gel. Lower cooking loss and higher emulsion stability (P<0.05) were observed in the modified treatments. No difference was observed between the treatments for the microbiological quality. The substitution of up to 60% fat did not influence (P>0.05) on color (L*, a*, b*, and whiteness), texture parameters, and sensory acceptability. Therefore, healthier Bologna type sausages could be produced by replacing up to 60% of the fat with a mixture of PS, water, and GBF without depreciating product's quality., (Copyright © 2016 Elsevier Ltd. All rights reserved.)