Search

Washing is an essential process in surimi production, from which a large amount of wastewater is generated. Due to the increasing pressure of environmental protection, it is an urgent technical requirement for surimi manufacturers to reduce water usage while maintaining the quality of surimi. In this study, composition, structure and gelling properties of grass carp surimi prepared with a modified washing process (MWP) were investigated. Intermediate dehydration with various compression ratios were utilized between two washing cycles.Water usage and wastewater discharge were reduced significantly by 33% and 38%, respectively, when MWP was applied. As the compression ratio increased, composition of fat, cathepsins, transglutaminase and heme proteins in surimi decreased gradually. Yield, protein content and the major protein pattern of surimi were not changed, but surface hydrophobicity gradually decreased. As the compression rate increased to 1:2.0, textural values and water holding capacity of the corresponding surimi gel decreased gradually, while whiteness increased and then remained unchanged. At a higher compression ratio (1:1.5), aggregated network and excessive free water were observed in the surimi gel. Composition and gelling properties of the MWP surimi with a compression ratio of 1:1.2-1:1.5 were equal to those of the surimi prepared under conventional three-cycle washing.Results indicated that MWP demonstrated its great potential in surimi production by dramatically reducing the usage of cold water and discharge of wastewater without scarifying surimi quality. © 2022 Society of Chemical Industry.

Histamine-forming bacteria (HFB) were isolated from the 70 salted fish samples bought from town markets of Guangdong Province of south China. In addition, the histamine-forming ability of HFB was analyzed. There were 31 strains of HFB isolated from 36 salted fish pickled overnight. They were identified as six bacteria species: Vibrio alginolyticus, Vibrio rumoiensis, Staphylococcus saprophyticus, Staphylococcus xylosus, Lactococcus lactis, and Morganella morganii. The rate of confirmation of V. alginolyticus was highest (23 of 31), exceeding 200 mg/kg histamine. In particular, M. morganii produced a histamine amount that exceeded 2,000 mg/kg, although it was only one isolate in this study. In addition, five bacteria species of HFB were isolated from 34 dried salted fish. Among them, S. saprophyticus was dominant in the dried salted fish but produced histamines below 200 mg/kg. However, Enterobacter aerogenes from dried salted fish formed a histamine amount exceeding 200 mg/kg. The study showed that the dominant strain of HFB was different in two kinds of salted fish. Both kinds of salted fish contained HFB whose histamine-forming capacity exceeded 200 mg/kg. As a result, the safety of salted fish should be of concern, especially salted fish pickled overnight.

Surimi is produced from the various sequences of filleting, deboning, washing, dehydrating, blending with cryprotectant, and freezing. Deboning, after which fish flesh is minced and separated from bone, skin, etc., is a vital step in the surimi production. In this study, effects of repeated deboning on yield, structure, composition, and gelling properties of silver carp surimi were investigated.Surimi yield increased rapidly from 10% to 23% as the cycle of repeated deboning was increased from one to three, and then slowly increased up to 26%. As the cycle increased, cellular structure and ultrastructure of muscle fibers progressively fractured. Contents of fat, cathepsins, heme proteins, and transglutaminase of surimi obviously increased and then decreased. Three-dimensional network of surimi gel without setting (NS gel) became more porous with the increase of cycles. It became more compact, and then turned to aggregated forms with lower homogeneity, for the surimi gel with setting (WS gel). Correspondently, the NS gel textural values gradually decreased with the cycles, while the WS gel textural values increased up to three cycles and then decreased. Regardless of setting, whiteness of surimi gels decreased and then increased with the cycles.Our results suggested that structure and compositions of surimi changed with the cycle of repeated deboning, which affected gelling properties of surimi. It is recommended to debone three or four cycles in silver carp surimi production. © 2022 Society of Chemical Industry.

In this study, DNA barcoding was applied to identify the distinct species of fish products in Guangzhou supermarkets and sushi restaurants in order to confirm whether products were correctly labeled. Samples were analyzed using mitochondrial cytochrome C oxidase subunit I (CO I) gene as the target. Our results showed that the CO I gene of all 139 samples examined was successfully amplified by PCR. When sequenced, 30 samples (21.58%) were mislabeled as the wrong species, 11 samples had insufficient information provided on the label to determine if the labeling was correct (7.91%), and four samples failed sequencing (2.88%). We also found that the use of proper labels for fish products in sushi restaurants was higher than that in supermarkets. As a simple, rapid, and efficient technology, DNA barcoding can be widely used for species identification of fish products. Our work shows that regulation of the labeling of fish products, as we evaluated in Guangzhou and other markets in China, is needed on a global scale.

This study investigates the mercury (Hg) levels distribution in fish and fish products and their relationships with fish types, weights, protein, and lipid contents in Qatar. Principal component analysis (PCA) was employed to analyze the influence of lipids and protein content on Hg accumulation in the fish tissues. Additionally, the impact of Hg concentration and fish consumption on the estimated weekly intake (EWI). The PCA results showed that Hg contamination levels are primarily affected by protein-lipid content in predatory species. The results showed that high lipid content reflected lower Hg levels and that high Hg levels in fish with high lipid content indicated a polluted environment. The finding of the PCA of EWI, consumption, and Mercury concentration indicate that EWI is highly correlated to Mercury concentration except in the case of low Mercury concentration. 2023 Elsevier Ltd This publication was made possible by Qatar University grant # [QUST-1-CAS-2022-312]. The findings achieved herein are solely the responsibility of the author[s]. Special thanks to the Central Food Laboratories, Public Health Department, Qatar. Scopus

Background Sodium chloride (NaCl) is an essential food additive used for preservation/flavor enhancement. Food processing with NaCl has higher sodium contents, raising the concern between the excess of dietary sodium as a risk factor for several health problems. Thus, there is a growing demand for alternatives to reduce sodium in processed foods. Scope and approach This systematic review comprehensively discusses how NaCl replacement can affect microbiological, sensory, and physicochemical attributes of processed fish products, besides identifying the current trend of a potential substitute. Key findings and conclusions KCl, K-lactate, CaCl2, MgCl2, SODA-LO salt microspheres were the main NaCl replacers found in smoked, restructured, fermented, read-to-eat, sushi, and fried cake fish products evaluating microbiological, physicochemical, and sensory parameters. The effectiveness of NaCl substitution is closely related to the particular characteristics of each fish product. Nevertheless, no study analyzed all quality parameters in each product, making it challenging to identify sodium substitution efficiency. KCl has higher research attention: the substitution of 25–50% of NaCl by KCl in combination with packaging conditions was enough to control microbial growth and reduce the prooxidant effect. However, the sensory quality was compromised, and adverse effects of high potassium intakes on health should be considered. Few studies analyzed the proximate composition, although seafood products have high protein and essential lipid content. Novel salt technologies as SODA-LO were identified as the current trend to lower sodium in fish products without taste impairment. Nevertheless, more studies are needed to elucidate the effects of its use on the overall quality of products.

Topicality: The content of histamine in high concentrations causes a number of diseases that even lead to death, it is one of the indicators that characterizes the safety of fish and fish products. Therefore, the choice or development of a simple and inexpensive method for the determination of histamine content in fish and fish products is relevant. Objective: We confirmed the effectiveness of photometric method for the determination of histamine in fish and fish products by obtaining and analyzing validation characteristics. Results: Based on the results of validation, it has been substantiated and experimentally proved that the photometric method of quantitative determination of histamine can be correctly reproduced and is suitable for the quality control of measurements. The most acceptable results were obtained for histamine concentrations in the range from 50.0 ± 0.1 to 200.0 ± 0.5 mg/kg. The lower histamine concentrations are characterized by a higher percentage of total uncertainty, although it is also within acceptable values. Conclusions: Evaluation of the obtained validation characteristics indicates that this technique can be used to quantify the content of histamine in fish and fish products and is not inferior in accuracy and correctness to the method of high performance liquid chromatography.

An easy-to-use food packaging label with pH and ammonia sensitivity was developed by adding betacyanin (5, 10 and 15 mg per g of starch) from flowers of paperflower (Bougainvillea glabra) to potato starch film made using the solvent casting method. The betacyanin was well dispersed into the starch matrix and formed new interactions with it as revealed by FTIR. The film containing 15 mg/g of betacyanin showed a color change from light pink to yellow as a response to pH adjustment of between 2 to 13. It was also able to detect the presence of ammonia in a range of 0.1 and 0.01 mg of ammonia per ml of water. Surface hydrophobicity and water vapor barrier capacity of the starch film increased by addition of the betacyanin, yet their mechanical strength decreased in the presence of the betacyanin. The ability of the film in the real-time indication of fish quality as a label was also evaluated during the storage of Caspian sprat at 4 °C. A visual change in the color of the packaging label from pink to yellow in parallel with the increase in the total volatile basic nitrogen (TVB-N), microbial count of the fish samples was detected. The starch/betacyanin film could be a novel intelligent label for application in food packaging.

Constant fishing industry innovations in response to consumer demands for novel, balanced healthy products exhibiting high nutritional value, as well as easy to prepare and ready to consume, have led to the emergence of new technologies. Among them, the development of products based on ground beef and fish mixtures are noteworthy. In this context, the purpose of this study was to develop products from different ground rainbow trout and tilapia fillet ratios, in the form of meatballs and nuggets, determining their proximate composition and physico-chemical, microbiological and toxicological characteristics. The average dry matter percentage of the developed products was 29.20±2.30%, while mineral content was 1.45±0.55%, lipid pulp content, 3.70±0.30% and crude pulp protein, 16.60±2.04%. Total psychotropic counts remained below 102 CFU/g, for standard counting on aerobic microorganism plates. Histamine and sulfur-based compounds were not detected in any of the prepared samples. The purpose of the work proposal was to develop foods and technologies that can serve as standards, allowing for simple handling products that apply ground meat mixtures from different fish species to maintain adequate nutritional indices after processing. RESUMO A constante inovação da indústria pesqueira, em resposta às demandas dos consumidores por novos produtos saudáveis, com alto valor nutritivo, balanceados, de fácil preparo e prontos para consumo, levou ao surgimento de novas tecnologias, entre elas o desenvolvimento de produtos à base de mistura de carne moída de pescado. Nesse contexto, a proposta deste trabalho é desenvolver produtos a partir de carne moída de pescado de truta-arco-íris e tilápia, confeccionando almôndegas e nuggets em diferentes proporções, com determinação da composição centesimal e de suas características físico-químicas, microbiológicas e toxicológicas. A matéria seca percentual média foi de 29,20±2,30%. Teores de matéria mineral nos produtos estão em 1,45±0,55%. Os teores de lipídeos aferidos na polpa foram de 3,70±0,30%, e os níveis de proteína bruta apresentados na polpa de 16,60±2,04%. A contagem de psicrotróficos totais manteve-se abaixo de 102 CFU/g, para contagem padrão em placas de micro-organismos aeróbicos. Nas amostras, não foram detectados níveis de histamina e de compostos à base de enxofre. A proposta de trabalho objetivou, por fim, desenvolver alimentos e tecnologias que possam servir como padrões, permitindo que produtos de manipulação simples e que utilizem misturas de carne moída de diferentes espécies de pescado mantenham índices nutricionais adequados após o processamento.

BACKGROUND Recent studies demonstrate that fish byproducts can be used as sources of bioactive peptides for functional foods. Sturgeon skin contains abundant proteins but it has commonly been discarded during sturgeon processing. The objective of the present work was to identify and characterize the bioactive peptides from protein hydrolysates of sturgeon skin. RESULTS Sturgeon skin protein extract (SKPE) hydrolyzed by flavourzyme for 60 min exhibited high antioxidant activity, dipeptidyl peptidase IV (DPP-IV) and angiotensin converting enzyme (ACE) inhibitory activity. The sequences of peptides from flavourzyme hydrolysates were identified using high-performance liquid chromatography-tandem mass spectrometry. Gly-Asp-Arg-Gly-Glu-Ser-Gly-Pro-Ala (P1) showed the highest DPPH radical scavenging activity (DPPH IC50 = 1.93 mmol L-1 ). Gly-Pro-Ala-Gly-Glu-Arg-Gly-Glu-Gly-Gly-Pro-Arg (P11) (DPP-IV IC50 = 2.14 mmol L-1 ) and Ser-Pro-Gly-Pro-Asp-Gly-Lys-Thr-Gly-Pro-Arg (P12) (DPP-IV IC50 = 2.61 mmol L-1 ) exhibited the strongest DPP-IV inhibitory activity. Gly-Pro-Pro-Gly-Ala-Asp-Gly-Gln-Ala-Gly-Ala-Lys (P6) displayed the highest ACE inhibitory activity (ACE IC50 = 3.77 mmol L-1 ). The molecular docking analysis revealed that DPP-IV inhibition of P11 and P12 are mainly attributed to hydrogen bonds and hydrophobic interactions, whereas ACE inhibition of P6 is mainly attributed to strong hydrogen bonds. CONCLUSIONS These results indicate that SKPE hydrolysates generated by flavourzyme are potential sources of bioactive peptides that could be used in the health food industry. © 2021 Society of Chemical Industry.

BACKGROUND The substitution or mislabeling of toothfish is an issue of significant concern for seafood authorities; it also reduces the effectiveness of marine conservation and management programs for its over-exploitation and illegal trafficking, boosting the need for identification methods. RESULTS Two species-specific real-time polymerase chain reaction (PCR) assays for the identification of Patagonian toothfish (Dissostichus eleginoides) and Antarctic toothfish (Dissostichus mawsoni) and a genus-specific real-time PCR assay for Dissostichus spp. identification were developed based on fragments of the 16S rRNA and COI (cytochrome c oxidase subunit I) genes. These methods were confirmed to be rapid, simple, and sensitive (absolute sensitivity of 0.0002 ng μL-1 and relative sensitivity of 0.1 g kg-1 with good specificity). These methods can be applied to processed and commercial fish products. CONCLUSIONS These approaches can be beneficial for protecting both consumers and producers from economic fraud and might also help protect toothfish from over-exploitation as well as combat illegal, unreported, and unregulated (IUU) fisheries. © 2021 Society of Chemical Industry.

Histamine is a biogenic amine and a food safety hazard, and it is the only biogenic amine regulated by statute or HACCP Guidance. This paper reviews the regulations for histamine levels in fish in countries around the world, including maximum limits or levels and sampling procedures in different fish preparations. The maximum histamine levels, sampling plans, and fish products are listed. The country-by-country regulations for maximum histamine acceptance levels in some food products vary by a factor of 8, from 50 ppm in some countries to a maximum of 400 ppm in other countries. For similar food products, the maximum histamine levels vary by a factor of 4 (from 50 ppm to 200 ppm) in, for example, fresh tuna. The country-by-country sampling plans vary widely as well and these, too, are covered in detail. Molecules of histamine are formed from L-histidine molecules, an amino acid, by a decarboxylation reaction caused by a bacterial enzyme, histidine decarboxylase. Histamine can form in many different species of saltwater fish that have elevated levels of free L-histidine. Histamine formation is completely preventable, and these methods are described as well. Although there are multiple maximum histamine acceptance levels, rapidly chilling the fish immediately after harvest by any means available is the only method to stop the formation of histamine. Fishermen should rapidly chill the fish using ice, chilled seawater, dense cold brine, or air blast freezers as quickly as possible.

The objective of this work was to evaluate the use of galactomannan from Caesalpinia pulcherrima as a binding agent for the restructuring of fishes. The effect of a frozen (-18 °C) storage of 120 days on the physical-chemical and mechanical properties of fishes was evaluated, restructured fish products with transglutaminase were used as a control. Two fish restructuring formulations were developed: Galactomannan, with 0.2% galactomannan and 1.8% refined salt; and Control, with 0.5% transglutaminase. The analyses were carried out after 24 hours of refrigerated storage (4 °C), corresponding to time zero, and after 30, 60, 90, and 120 days of frozen (-18 °C) storage. The use of galactomannan resulted in a higher pH, and lower total volatile basic nitrogen (TVB-N) and thiobarbituric acid reactive substances (TBARS), with no differences from zero to 120-day storage times for the L*, a*, and b* coordinates. Galactomannan easily bounds to hydrogen, enabling the obtaining restructured fish products with lower expressible water content and less weight losses by cooking, important characteristics for the acceptance of products that denote softness and succulence. Contrastingly, this easy bound to water molecules resulted in a lower hardness, cohesiveness, and elasticity, and higher adhesivity when compared to the control. The results showed the viability of using galactomannan to restructure fishes during frozen storage. RESUMO Este trabalho tem como objetivo avaliar a utilização da galactomanana de Caesalpinia pulcherrima como agente ligante na reestruturação de pescado, examinando as propriedades físico-químicas e mecânicas para determinar o efeito do armazenamento congelamento−18 °C durante 120 dias, utilizando como controle o reestruturado de pescado feito com transglutaminase. Foram desenvolvidas duas formulações de reestruturados sendo a Gal com 0.2% de galactomanana e 1.8% de sal refinado e o Controle com 0.5% de transglutaminase. As análises foram realizadas após 24 horas de armazenamento refrigerado (4 °C) correspondente ao tempo zero e depois aos 30, 60, 90 e 120 dias de armazenamento congelado a−18 °C. Foi observado ao longo do período estudado que a incorporação de galactomanana registrou um aumento no pH, menores valores para as bases voláteis totais (N-BVT) e substâncias reativas ao ácido tiobarbitúrico (TBARS), além de não manifestarem mudanças significativas, entre os tempos zero e 120 dias, nas coordenadas L*, a* e b*. A facilidade da galactomanana em realizar ligações hidrogênio permitiram obter reestruturados com menor teor de água expressível e reduzida perda de peso por cocção, sendo estas características importantes para aceitação dos produtos por proporcionarem maciez e suculência. Por outro lado, está maior facilidade de ligação com a água contribuiu para os menores valores de dureza e coesividade, além de baixa elasticidade e maior adesividade em relação ao controle. Os resultados foram importantes e demonstraram a viabilidade da galactomanana na reestruturação de pescado durante o armazenamento congelado.

This study was conducted with the aims of utilizing the resources and analyzing the quality of value‐added fish products, fish ball made from a fish mince blend of pangasius (Pangasius hypophthalmus) and skipjack tuna (Sarda orientalis) (ratios P100:T0, P75:T25, P50:T50, P25:T75, P0:T100), under two cooking processes (two‐step heating and autoclaving). The textural quality (softness/firmness [S/F]; chewiness/rubberiness [C/R]; and folding test [FT]) and the nutritional quality of the fish products were determined by the sensory method and AOAC method, respectively. The results showed that tuna had higher utilization than pangasius. The products from the washed fish mince blend showed better textural properties with two‐step heating (50℃ for 60 min and 100℃ for 30 min) than with autoclaving (120℃, 15Ib/Inc2 for 15 min) and unwashed process. Of the five fish mince blend ratios, P50:T50 showed significant higher textural properties (FT, S/F, and C/R values) than the other ratios (p, Tuna meat mince had a higher yield than pangasius meat mince. Pangasius and tuna at P50:T50 ratio showed better textural quality than other ratios. The heating process, salt solutions washing and muscle compositions significantly affects the color and textural quality of the fish ball.

6 pages, 4 tables, 1 figure.-- Under a Creative Commons license, Listeria monocytogenes is a major foodborne pathogen which mainly infects susceptible individuals through the consumption of contaminated foods. To this end, ready-to-eat (RTE) food products are of particular concern as this microorganism is widely distributed, can survive, and even grow, under adverse conditions, and thus must be carefully controlled. In the present study, an interlaboratory ring trial was organized to evaluate an open formula qPCR-based method for the detection of L. monocytogenes. The molecular method was evaluated on a novel RTE seafood product, developed in the framework of a European project, the SEAFOODAGE (EAPA_758/2018). Six laboratories located in Spain and Portugal participated in the study, and the results obtained indicated that this new method presented high diagnostic sensitivity (100%) reaching a low limit of detection (, This work was financially supported by the Seafood Age project, which was co-financed by the Interreg Atlantic Area Program (EAPA_758/2018) though the European Development Fund (ERDF). Mrs. Sarah Azinheiro was financed by a Ph.D. grant from the Fundação para a Ciência e a Tecnologia (SFRH/BD/140396/2018). Dr. Alejandro Garrido-Maestu and Luís D. R. Melo acknowledge funding from the Fundação para a Ciência e Tecnologia through the Scientific Employment Stimulus Program (2021.02810. CEECIND and 2021.00221. CEECIND, respectively). This study was supported by the Fundação para a Ciência e a Tecnologia (FCT) under the scope of the strategic funding of UIDB/04469/2020 unit

Protein oxidation of fish products during storage and processing is of interest recently. In this study, the effect of peroxyl radicals generated from 2,2′-azobis (2-amidinopropane) dihydrochloride (AAPH) on the physicochemical and gel properties of myofibrillar protein (MP) from grass carp was investigated. After incubation with AAPH (0.04, 0.2, 1, 5, 25 mM), the carbonyl and dityrosine content, and surface hydrophobicity index of MP were higher than that of the non-oxidation control. Conversely, this treatment decreased the free ammonia, total and free sulfhydryl content of MP progressively. The transformation from α-helix to β-sheet and β-turn in MP treated with AAPH was found. The fluorescence quenching of tryptophan occurred in the 5 and 25 mM AAPH groups. When the AAPH concentration reached to 25 mM, the protein solubility decreased to 58%, compared to the control group. Meanwhile, this AAPH treatment damaged the elastic feature of MP and also decreased the water holding capacity, gel strength and texture of gel, which were closely depended on the oxidation degree. The poor and rough microstructure provided solid and visible evidence for the loss of gel properties in oxidation treatment groups. In short, these results gave a deeper understanding for the changes of physicochemical and gel properties of fish MP subjected to oxidation environment.

BACKGROUND The content of essential and toxic elements in grilled fish (Atlantic salmon, trout) and in 20 assortments of fish products was examined. The aim of this study was to assess the fulfilment of the demand for Zn, Fe, Mn and Cu based on recommended dietary allowances (RDAs) or adequate intakes (AIs) and to assess the health risk associated with the consumption of Al, Pb and Cd. The risk assessment was based on estimated weekly intake (EWI), hazard index (HI), target risk ratio (THQ) and percentage: provisional tolerable weekly intake (PTWI) for Al, tolerable weekly intake (TWI) for Cd and reference dose lower bound (BMDL) for Pb. RESULTS Taking into account the health benefits, the best source of Fe, Cu and Mn was found to be fish products in cans and jars, 150 g of which covered the daily requirement: Fe 9.39%, Cu 2.91% and Mn 1.21%. Smoked fish covered the RDA for Zn to 5.69%. Moreover, the uptake of toxic elements was as follows: Al 0.45% PTWI: Pb 0.74% BMDL10 and Cd 2.20% TWI. The THQ values for Pb and Cd were significantly lower than 1, whereas for Al it reached as high as 4.0. CONCLUSION The obtained results indicate that there is no risk related to the intake of Pb and Cd with the consumption of the tested fish products. Low consumption of fish by Poles, however, contributes to their small share in covering the demand for microelements, i.e. Zn, Fe, Mn and Cu. © 2021 Society of Chemical Industry.

Among the foodstuff, most often adulterated are white meat and meat products as well as fish and fish products. For this reason, we evaluated in practice the possibilities of identifying selected species of white meat, i.e., guinea fowl and rabbit as well as four fish species, namely, pollock, hake, sole, and panga, in thermally treated samples. The aim was to check whether the previously published in the scientific literature species-specific primers allows for the identification of processed meat using the end-point PCR technique. To identify the six species, the short sequence fragments (from 130 to 255 bp) of 12S rRNA, COX3, mitochondrial ATP synthase Fo subunit 6 (ATP6) gene, pantophysin (Pan I) gene, 5S rRNA gene, and microsatellite markers (locus: Phy01-KUL) were selected. Stability and specificity of the six pair primers were evaluated on cooked and autoclaved meat, and commercially processed food samples such as rabbit and guinea pâtés, ready-made baby food, and breaded, fried, and deep-frozen fish products. The method proved to be useful for the authentication of severely processed food products against fraudulent species substitution and mislabelling and this approach may be an alternative to more advanced and more expensive PCR techniques.

Application conditions of the ACTIVA® TG-TI transglutaminase combined with setting agents (gelatine and chitosans of various modifications) are substantiated for moulded food processing from waterlogged fish raw materials targeted by deep-water fishery, i.e. giant grenadier (Albatrossia pectoralis). It was shown that combining different setting agents ensures time reduction of gel formation with a minor change in their development and melting temperatures. Adding an enzyme preparation leads to the formation of thermostable gels with a 1.5-fold increased strength. When forming gels from the grenadier muscle tissue in the presence of setting agents of different concentrations, the quality of soluble muscle proteins reduces, most prominently with gelatine and chitosan ascorbate. Physicochemical parameters of the structured gels prepared from the muscle tissue of giant grenadier (moisture retention capacity, tensile strength, water activity) and their organoleptic profiles were measured. Based on the results, we have shown that adding 3% of gela-tine, 0.06% of high-molecular chitosan and 1% of transglutaminase may be employed for processing moulded fish products. The digestibility of the protein components in obtained samples did not depend on fermentation. The overall protein deposition was between 0.38 and 0.56% of the sample mass. The total biological value of samples ranged from 78 to 134% when studying their effect on the growth of T. pyriformis testing culture.

BACKGROUD/OBJECTIVES Understanding the factors associated with fish consumption is necessary to determine strategies to improve the fish consumption particularly those high in omega-3 long chain polyunsaturated fatty acids (n-3 LCPUFA). The aim of this study was to analyse the correlation between a mother's perspective on fish and actual fish consumption in their children. SUBJECTS/METHODS Two hundred thirty-one elementary school children grade 3-6 and their mothers in Surakarta were recruited using multi stage random sampling for this study. Data was collected in July and August 2017. A validated questionnaire consisted of 3 topics including knowledge related to the health benefits and organoleptic properties of fish and cooking technique-related attitudes on fish were used to measure the mother's response to the fish properties. A validated food frequency questionnaire and a food picture book of fish specifically designed for the survey were developed and used to assess fish consumption of the children. A χ2 test was used to analyse the correlation between the mothers' perspective on fish and their children's fish consumption. RESULTS The median fish consumption in children was 65 g/d with fried non-oily or lean fish, e.g., milkfish (locally called Bandeng) and catfish (locally called Lele) were consumed more than oily fish as well as processed fish products. Of all children, 31% met the fish consumption recommended by the Environmental Protection Agency-Food and Drug Administration 2017. There was no relationship between a mother's knowledge related to health benefits, organoleptic properties and cooking technique-related attitude toward fish and her child's fish consumption. CONCLUSIONS The fish consumption of children is not influenced by their mother's perspective on fish. Nutrition education strategies are warranted to improve fish consumption and maintain the optimal benefits by consuming fish, including fish high in n-3 LCPUFA.

The antioxidant peptides extracted from plants or animals have shown great potential in preventing food quality deterioration caused by oxidization. Here, peptide fractions obtained from hairtail surimi hydrolysates (HSH) were investigated for structure and color-protective effect. The results showed the

The unique nutritional and chemical composition of fish makes it highly susceptible to autolytic and microbial decomposition arising concerns about the safety of fish and fish products. Conventiona...

Multiple pathways of severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) transmission have been examined, and the role of contaminated foods as a source of SARS-CoV-2 exposure has been suggested. As many cases of SARS-CoV-2 have been linked to meat processing plants, it may be that conditions in live animal markets and slaughterhouses or meat processing plant procedures transfer viral particles to meat, poultry, and seafood during animal slaughter, processing, storage, or transport. Because of the potential for contamination of foods such as beef, chicken, pork, or fish, the goal of this study was to evaluate the survival of a lipid enveloped RNA bacteriophage, phi 6, as well as two animal coronaviruses, murine hepatitis virus (MHV) and transmissible gastroenteritis virus (TGEV), as SARS-CoV-2 surrogates for their survival under various meat and fish cold-storage conditions over 30 days. Viral surrogates differed in survival, depending on food product and temperature, but overall, viruses survived for extended periods of time at high concentrations at both refrigerated and frozen temperatures. The ability of SARS-CoV-2 viral surrogates like Phi 6 and animal coronaviruses to survive for varying extents on some meat and fish products when stored refrigerated or frozen is a significant and concerning finding. Continued efforts are needed to prevent contamination of foods and food processing surfaces, worker hands, and food processing utensils such as knives, and there is a need to better address the lack of or inadequate disinfection of these foods prior to meat packaging.

Financiado para publicación en acceso aberto: Universidade de Vigo/CISUG The detection and inhibition of Clostridium botulinum by probiotics' cell-free supernatants, as a bio-preservation strategy, were investigated in some Egyptian fish-stuffs i.e., canned sardines, fesikh, moloha, renga, and anchovy. The conventional and multiplex polymerase chain reaction were used to detect C. botulinum, while the inhibitory and antioxidant capacity of four probiotics' cell-free supernatants were assessed using disc diffusion assay (DDA) and radical scavenging activity approaches, respectively. The results revealed that the C. botulinum was isolated from 41.6% of the examined products, where the type E. was the most predominant genotyping. The DDA showed that Lactobacillus bulgaricus EMCC 1102 and L. paracasei EMCC 1103 expressed the highest inhibitory action against C. botulinum type E. Meanwhile, L. bulgaricus EMCC 1102 has higher in vitro antioxidant activity (IC50) than L. paracasei EMCC 1103, mostly due to its high bioactive constituent. Consequently, L. bulgaricus EMCC 1102 was used to control the growth of C. botulinum type E in stored anchovy fillets. L. bulgaricus EMCC 1102 supernatant showed a dose-dependent inhibitory effect on C. botulinum type E. These data provided an innovative perspective on the inhibitory potential of probiotics, as a bio-preservation strategy, to guarantee fish products safety for further applications in the food industry. Axencia Galega de Innovación | Ref. IN607A2019/01

High-throughput sequencing and high-pressure liquid chromatography (HPLC) methods were used to investigate the influences of microbial dynamics on the quality and biogenic amine (BA) content during fish sauce fermentation. The homogeneity of total viable bacteria and lactic acid bacteria in fish sauce becomes higher as fermentation progresses. Tetragenococcus was the key genus of fish sauce fermentation. Carnobacterium (38.43%) and Lentibacillus (41.01%) were the dominant genera in the samples fermented for 3 months and 18 months, respectively. These three bacterial genera were significantly related to the physicochemical characteristics and characteristic flavors of the sauces. Tetragenococcus was significantly positively correlated with nitrogen oxides, the main characteristic flavor components in fish sauce. The BA content in fish sauce fermentation increased from 106.88 to 376.03 mg/kg, and the content of histamine reached 115.30 mg/kg at the end of fermentation, indicating that fish sauce has health risks. About 66.67% of Lentibacillus isolates were able to produce a large amount of BA, suggesting that Lentibacillus was the key genus for BA accumulation in fish sauce fermentation. Research on reducing the content of BA in fish sauce by intervening with regard to the fermentation temperature showed that a safe fish sauce product could be obtained at the fermentation temperature of about 25°C. These results help us to understand the contribution of microbial community composition to fish sauce fermentation and provide a basis for improving the quality and safety of fermented fish sauce. IMPORTANCE Traditional fermentation of fish sauce is mainly carried out by complex microbial communities from raw anchovies and processing environments. However, it is still unclear how the environmental microbiota influences the quality and the safety of fish sauce products. Therefore, this study comprehensively explained the influence of microorganisms on the quality and safety of fish sauce during the fermentation process in terms of physicochemical characters, flavors, and BA. Additionally, the accumulation of BA in fish sauce fermentation was controlled by intervening in the fermentation temperature. This finding contributes to a deeper understanding of the role of environmental microbiota during fermentation and provides data support for improving the safety of fish sauce.

Salt is a necessary condition to produce a surimi product that is based on the gelation of salt-soluble myofibrillar proteins. Recently, there has been a growing concern among consumers to consume healthy foods due to the threat of several chronic diseases caused by an unhealthy diet. Methods of reducing salt content out of concern for health issues caused by excessive sodium intake may affect the gel properties of surimi, as can many health-oriented food additives. Several studies have investigated different strategies to improve the health characteristics of surimi products without decreasing gel properties. This review reports recent developments in this area and how the gel properties were successfully maintained under reduced-salt conditions and the use of additives. This review of recent studies presents a great deal of progress made in the health benefits of surimi and can be used as a reference for further development in the surimi product processing industry.

PurposeDemand for fishery products rich in protein, vitamins, minerals and omega fatty acids has been increasing daily to meet the world population's increasing nutritional request, estimated to be 7.6 billion. Despite aquatic products' positive effects on human health, their consumption in Turkey has decreased over time and is currently lower than most countries with 6.3 kg per capita. The reason why fish consumption in Turkey is less than in other countries is the more preference for terrestrial production. Therefore, it was aimed to determine the consumption habits of consumers in Turkey's coastal region.Design/methodology/approachThis study was carried out between Feb–March 2018 to determine the consumption habits of aquatic products; 28 areas in the coastal regions of Turkey random were selected, 650 volunteer consumers were randomly selected to answer a set of 25 questions. The survey results were evaluated by Chi-square analysis.FindingsFrom the survey results, 81.4% of the respondents prefer to consume fish from the natural environment. Additionally, from the consumers, there was no statistical difference between natural (81.4%) and aquaculture (85.4%) fish taste (p = 0.05). It was found that 63% of the participants consumed fish meat once a week, with an average per capita consumption of 17.50 ± 2.34 and 10.50 ± 1.66 kg for fish and other seafood consumption, respectively. As a result, it was estimated that fish products were consumed at the desired level in the provinces examined. Accordingly, individuals need to be more conscious and encouraged to increase the consumption of seafood.Research limitations/implicationsBecause Turkey's seafood consumption is still held in coastal regions in this article are the limitations of this article results. In the future, the difference between inland and coastal regions for fish consumption needs to be explored further.Practical implicationsThe article says exports of fish / fisheries products have gradually decreased due to the global COVID-19 crisis, but producers / markets will have to target the domestic market more and sales with TL will come to the fore. As a result, it was estimated that fish products were consumed at the desired level in the studied provinces. Accordingly, it has been revealed that individuals should be more conscious and encouraged to increase their consumption of seafood.Social implicationsThrough this research, the consumption of fisheries consumption preferences of individuals in Turkey's coastal regions uncovered.Originality/valueOn the other hand, since Turkey's aquaculture and fisheries sector attaches great importance to foreign sales (exports), domestic consumption amounts are low, and the issue of increasing this is an issue that has remained in the background for the producer. However, during the COVID-19 pandemic period, it was well understood that the closing of the customs gates partially and/or completely and the export figures becoming scanty will cause the end of 2020 and 2021 to be more troublesome in this sense. Therefore, producers/markets will have to target the domestic market more, and sales with TL (Turkish Lira) will come to the fore, various campaigns and price reductions will be made during some special hours during the day in order to increase sales in domestic market.

The salted fermented fish (Mugil cephlus) Feseekh is not only popular as an appetizer; but also it's popular in some festivities in Egypt as a main dish. Biogenic amines (BA) are known as toxic in food. This study was conducted to investigate biogenic amines (BAs), physicochemical properties, and some microorganisms in salted fermented fish (Feseekh). Fifteen samples of Feseekh samples were obtained from different Egyptian local markets in four governorates (Sharkia, Ismailia, Beheira, and Dakahlia). The total biogenic amine content in Feseekh varied between 104.6 and 166.8 mg/kg. Six BAs Histamine (HIS), Tyramine (TYR), Putrescine (PUT), Cadaverine (CAD), Spermine (SPE), and Spermidine (SPD) were found in all fish samples under investigation. Histamine was quantitatively the most common biogenic amine in all samples, the histamine content ranged from 51.80 to 93.3 mg/kg, which was above the 50 mg/kg limits set by the Food and Drug Administration (FDA). Fermented fish (Feseekh) contains 14 amino acids. The essential amino acids accounted for 30.7-36.9% of the total concentration of amino acids. Fish flesh of mullet had the highest fatty acids that are saturated fatty was less than monounsaturated and polyunsaturated fatty acids. The total volatile basic-nitrogen (TVBN) content was ranged from 23.00 to 48.00 mgN/100g, Thiobarbituric acid (TBA) content was from 1.36 to 2.94 mg malonaldehyde/kg sample and Trimethylamine (TMA) was from 3.20 to 23.10 mgN/100g. Meanwhile, The total bacteria count(TBC) was from (6.48 to 7.27 log CFU/g) was significantly higher than that of total mesophilic bacteria count (TMC) ranged from 6.04 to 7 log CFU/g. It could be inferred that the safety of Feseekh should be improved by hygienic manufacturing process.

To provide a comprehensive overview of the amounts of unesterified and bound 2- and 3-monochloropropanediol (MCPD) and glycidyl esters (G–E) in processed fishery products sold in Germany, an analysis of various frequently consumed products was conducted. In total, 258 commercial samples of breaded and pre-fried fishery products (e.g., frozen fish fingers), fried fish products (e.g., products in marinade), canned fish, smoked fish and some smoked spice preparations were examined. In addition, the effect of different kitchen preparation methods (e.g., baking, frying and roasting) on the MCPD and G–E amounts of fish fingers was studied. The mentioned process contaminants, MCPD and G-E, were quantifiable in the majority of the samples. Although pre-fried and fried fishery products predominantly contained MCPD esters (MCPD-E), mainly free MCPD was found in smoked fish. Compared with other types of smoke generation, hot smoked fish prepared in traditional Altona smoking kilns contained, on average, the highest 3-MCPD contents (range: 12–246 µg/kg). The amounts of bound MCPD in the fried fish products (range for 3-MCPD-E

In recent years, the global demand for finished fish products is increased. Aquaculture raw materials are a rich source of nutrients for health. At the same time a large amount of fished fish raw materials are rejected and representing a losses. High-quality raw materials with technological defects are not in demand by the food production of fish products. Perishable substandard fish raw materials can be used in the production of combined fish products. The analysis of the fish catches global scale in the seas, oceans, farmed marine and freshwater aquaculture is carried out. An assessment of the market trends for the production and fish products consumption is made. This article provides an overview of targeted ingredient selection for balanced fish formulations. The characteristics of the most popular plant origin ingredients and their derivatives in the fish pates production are given. A comprehensive assessment of the biological, energy and nutritional value of plant products is given. Described technological approaches and production methods, the safety of vegetable ingredients. The results of research, technological solutions, substantiation of the choice of ingredients adopted by the developers for the formulations of multicomponent pate are summarized. The use of unclaimed raw materials, leftover fish meat with plant ingredients represents additional profit. Fish pate formulations are the basis for the production of complete, ready-to-eat products. Tests of multicomponent fish and vegetable products confirm their high performance. Pates, balanced in nutritional value, minerals, are a finished product that does not require additional preparation. The review article will generate awareness among the researchers, food technologists for the production of fish products and the general public.

Background The health benefits associated with consuming fish products are mainly attributed to their desirable nutrition profiles, including vitamins, minerals, essential amino acids, and polyunsaturated fatty acids. However, large quantities of fish proteins are presently underutilized or discarded as waste. Effective strategies to utilize fish proteins are therefore needed. Recently, researchers have focused on generating and characterizing bioactive fish protein hydrolysates and peptides and then studying their potential health benefits. Scope and Approach The major methods of producing, separating, and purifying protein hydrolysates are initially given. Then, the biological activities and potential mechanisms of action of protein hydrolysates and peptides are discussed. Finally, current limitations and future possibilities of fish peptide identification, production, and bioactivity are identified and discussed. Key findings and conclusions Fermentation, chemical synthesis, and enzymatic hydrolysis are effective methods of obtaining hydrolysates from underutilized fish protein by-products. These hydrolysates can then be purified by membrane separation and chromatographic methods to obtain bioactive peptides. The molecular characteristics of the peptides can then be identified using mass spectrometry. Fish hydrolysates/peptides have multiple biological activities, including antioxidative, lipid homeostasis modulation, anti-inflammatory, anticancer, neuroprotective, and antihypertensive activities, which make them promising nutraceutical ingredients for application in foods. Moreover, they often have emulsifying, foaming, and gelling properties, which means they may be suitable as multipurpose functional ingredients. Thus, waste-derived fish by-products may be turned into value-added functional ingredients designed to address chronic diseases. However, further research is required to develop large-scale commercially viable extraction and purification methods, develop robust structure-function relationships for peptides, and perform in vivo human studies of peptide bioactivity.

The global market of special foods has grown by 75 % in 2003–2008, that indicating a trend towards individualized diets and healthy lifestyles. Gluten-free foods are popular today due to the increase in the number of people with celiac disease and the general idea of healthy lifestyle. Thus, the production of such products increases due to the intensification of marketing activities. Because the only treatment for celiac disease is a lifelong gluten-free diet, people with this problem need to carefully read food labels for wheat, barley and rye, as well as so-called “hidden” gluten – barley-made malt and hydrolyzed vegetable protein (often contains wheat), as well as to exclude from the diet foods containing these cereals and select alternative foods for full life. However, given the number of people with individual gluten intolerance in Ukraine, the difficult economic situation and the high cost of gluten-free products, not every consumer with this problem can afford to buy certified specialized products labeled “gluten-free”. The aim of the research was to evaluate meat and fish products for gluten content. The article presents information of the results of monitoring gluten in meat and fish products (sausages, canned fish) from different regions of Ukraine by molecular genetic method for 2018–2020 using R-Biopharm diagnostic kits. According to the results of research, fish products that were not labeled “gluten-free” and were not certified as “gluten-free” met the requirements of current legislation of Ukraine and EU Regulation № 41/2009 on gluten-free products. Gluten was not detected in 29.4 % of meat products of various producers; 58.8 % of meat products contained gluten in trace amounts – less than 2 mg/kg; and 11.8 % of meat products contained gluten – more than 20 mg/kg. Prospects for further research are to monitor gluten in sweets and dietary products of domestic production and analyze the results of research on compliance with current legislation and safety for people with individual intolerance to gluten.

The application of texturing agents is of great relevance to fish processing technology. Thus, the aim of this study was to evaluate the effects of the use of different levels of carrageenan hydroc...

Padaek is a salt-fermented freshwater fish product popularly used in Laos as a shelf-stable all-purpose seasoning. For padaek production, the fish is fermented with salt and rice bran at ambient temperature. Although it is considered edible after 2 to 3 months of fermentation, 6 to 12 months is required to enhance its palatability. Its long shelf life and abundance of free amino acids, such as glutamate and lysine, are distinctive features of the product. Although commercial products are currently available, the tradition of making and consuming padaek at home continues, particularly in rural areas, to make use of indigenous freshwater fish, which provides a continuous supply of food and nutrition. Histamine can cause foodborne intoxication. Occasionally, its excessive accumulation occurs in amino acid-containing food, such as fermented fish products, because of the growth of microorganisms with histidine decarboxylase activity. We found a negative correlation between salinity and histamine content in homemade padaek products collected from rural households. Experimental padaek fermentation with initial salinity conditions of 10 and 6.5% exhibited significant histamine accumulation after 2 weeks of incubation at 30°C and exceeded 1,000 ppm within 6 months, but no histamine was detected in fermentation with an initial salinity of 18% over the same period. This indicated that salinity was a critical factor for controlling the risk of histamine accumulation during padaek fermentation. We, therefore, created and used a simplified calculation chart to help local households adjust the initial salinity to a sufficient level to reduce histamine accumulation during padaek fermentation. This producer-friendly approach for reducing the risk of histamine accumulation in this popular fermented food in Laos should be widely implemented to enhance food safety management in the country. HIGHLIGHTS

In interest of improving the traditional processing of meat and fish products, this study aimed to evaluate the sensory profile of traditionally processed grilled pork (GP), smoked fish (SF), and s...

The combined effect of ascorbic acid (AsA) and hydrogen peroxide (H2 O2 ) on gel-forming ability and structural changes of lizardfish (LZ) and threadfin bream (TB) surimi were investigated. Addition of 0.15% AsA and 0.1% H2 O2 greatly increased breaking force and distance of LZ surimi by 300% and 55%, respectively. Combination of 0.2% AsA and 0.15% H2 O2 resulted in the maximum TB surimi gel improvement with 150% and 90% increase in breaking force and distance, respectively. Browning reaction obviously occurred when combined AsA and H2 O2 was added, due to ascorbic acid oxidation. Polymerization of myosin heavy chain via disulfide bonds was promoted, and the formation of disulfide bonds was involved through oxidation of sulfhydryl groups with increasing AsA and H2 O2 . Fourier-transform infrared (FT-IR) spectroscopy revealed a decrease in α-helix and an increase in β-sheet content as AsA and H2 O2 increased in both species. A decrease of band area of aliphatic (2,800 to 3,000 and 1,450 cm-1 ), aromatic (1,208, 757, and ratio 850/830 cm-1 ), and change of disulfide bonds (525 and 540 cm-1 ) suggested an increase in hydrophobic interactions and disulfide bonds with addition of these additives. Based on principal component analysis (PCA), textural characteristics were positively correlated with β-sheet content. Our study suggested that combination of AsA and H2 O2 greatly enhanced gelation of LZ and TB by increasing not only disulfide bonds but also hydrophobic interactions. PRACTICAL APPLICATION: The combined ascorbic acid and hydrogen peroxide can be used to improve gelation of two important tropical surimi species, namely threadfin bream and lizardfish surimi, without requirement of setting. The optimum concentration of each additive varied with fish species.

It is important to preserve the fish products in proper storage condition until further use. Keeping this point in view, fish stick prepared from silver carp (Hypophthalmichthys molitrix) mince by using different kinds of food additives were stored at refrigeration (5 to 8°C) and frozen temperatures (-18 to -20°C) temperature. The results showed that, on “0” day the sensory quality criteria score was 9.00±0.00a for general appearance which decreased to 8.70±0.39a after 3 days of storage at refrigeration temperature and to 8.49±0.41aat frozen temperature after 56 days of storage. The TVBN values were found 22.54±0.17aand 16.04±0.39a, respectively at refrigeration and frozen temperatures which was 7.84±0.95c on “0” day. The peroxide value of the product on “0” day was 6.19 ± 0.71eand the microbial load was 1.49 x104 CFU/g which reached to 19.94 ± 0.17a, 21.58 ± 0.78a meq/kg and 2.13 x107 CFU/g, 1.12 ×102 CFU/g after storage at refrigeration and frozen temperatures. By observing these results present study could be concluded as-frozen temperature storage is comparatively better than refrigeration temperature for storing minced based ‘ready to cook’ products like fish stick and at this temperature the product can be stored for about 8 weeks. Environ. Sci. & Natural Resources, 12(1&2): 175-180, 2019

The objective of this study was to evaluate the antioxidant effects of Moringa leaf and Lavandula extracts in refrigerated tilapia fish burgers. GC-MS analysis identified 12 compounds in the Lavand...

Background Recently, fatty fish have been utilized as a potential approach for the fabrication of surimi products, with the yield of fatty fish surimi being > 10 000 tons in 2019. However, the gelling properties of catfish surimi can be influenced by intermuscular lipid. Lipase could effectively enhance the gel quality of catfish surimi gels, although the chemical forces involved in gel formation and alteration in lipid and protein oxidation status are not well understood. The present study investigated the gelation-enhancing effects of lipase on catfish surimi based on changes in chemical oxidation interactions. Results The addition of 7.5 g kg-1 lipase significantly increased the hydrophobic interactions and disulfide bond contents, both of which facilitated gel formation, in surimi gels. The 2-thiobarbituric acid reactive substance and carbonyl concentrations demonstrated that lipase promoted lipid and protein oxidations. Furthermore, an appropriate dose of malondialdehyde accelerated protein oxidation, thereby resulting in the covalent cross-linking of proteins. Consequently, the gel strength increased from 55.72 to 127.71 g × cm with lipase contents of up to 7.5 g kg-1 , and strong chemical cross-linking and a compact network were observed via sodium dodecyl sulfate polyacrylamide gel electrophoresis and scanning electron microscopy. However, excessive oxidation led to the degeneration of the gel matrix. A schematic mechanism, mainly based on the chemical changes, is proposed. Conclusion The present study revealed the gelation mechanism of catfish surimi gels with lipase, and suggested that lipase treatments may be an effective approach for improving the textural properties of fatty fish surimi gels. © 2021 Society of Chemical Industry.

Background Among various cooking methods, steaming is favored by many because it can cause less damage to nutrient components in muscle, retain the inherent food flavor, and reduce the generation of harmful substances. Steaming conditions are closely related to fish flavor, fat and protein oxidation, and digestibility. Results The black carp steamed for 4 to 14 min was studied in this article based on sensory assessment, electronic tongue, free amino acids, adenosine triphosphate (ATP)-related compounds, total nitrogen and non-protein nitrogen to explore the effect of steaming time on the taste substances and protein degradation of pickled black carp. The experimental result showed that the meat steamed within 8 min tasted better, showing high tastiness. The sensory assessment score increased significantly to the maximum value of 82.33 at 6 min. The content of umami and sweet amino acids increased significantly to the maximum value of 1.6801 g kg-1 at 6 min. In the meantime, the IMP (inosine monophosphate) content was 1.9128 g kg-1 , with its taste activity value (TAV) reaching 7.65, which proved that IMP affected the taste most. Furthermore, the total nitrogen content was 30.77 g kg-1 , which meant protein degraded a great deal. Based on equivalent umami concentration (EUC) and its TAV, the meat tasted best at 6-8 min. The longer the steaming time, the faster the protein degradation and the more the flavor precursors. Conclusion The black carp pickled products (with a weight of 20 g, with the size of 3 cm × 3 cm × 2 cm) is suggested to be steamed for 6 to 8 min. This conclusion provides a theoretical basis for its better taste quality. © 2020 Society of Chemical Industry.

Traditional fermented fish products are favored due to their unique flavors. The fermentation process of fish is accompanied by the formation of flavor substances through a complex metabolic reaction of microorganisms, especially lipolysis and lipid oxidation. However, it is difficult to precisely control the reaction of microorganisms during the fermentation process in modern industrial production, and fermented fish products have lost their traditional characteristic flavors. The purpose of this review is to summarize the different kinds of fermented fish, core microorganisms in it, and flavor formation mechanisms, providing guidance for industrial cultural starters. Future research on the flavor formation mechanism is necessary to confirm the relationship between flavor formation, lipid metabolism, and microorganisms to ensure stable flavor and safety, and to elucidate the mechanism directly toward industrial application.

A total of one hundred random samples of ready to eat (RTE) fish products represented by fried Oreochromis niloticus, grilled Oreochromis niloticus, smoked Herring and salted Sardine (25 of each) were collected from different fish markets and restaurants in Menofia governorate, Egypt. The aim of this study was to estimate the concentration levels of chemical residues such as heavy metals residues (mercury, lead and cadmium) and pesticides residues (aldrin and malathion) through subjection the examined samples to atomic absorption spectrophotometer for detecting the residues of mercury, lead and cadmium and gas chromatography for the residues of aldrin and malathion. The mean values of mercury (mg/Kg) in fried O. niloticus, grilled O. niloticus, smoked herring and salted sardine were 0.43±0.01, 0.59±0.01, 0.70±0.01 and 0.94±0.02, respectively. The mean values of lead (mg/Kg) in fried O. niloticus, grilled O. niloticus, smoked herring and salted sardine were 0.27±0.01, 0.33±0.01, 0.45±0.01 and 0.61±0.01, respectively. The mean values of cadmium (mg/Kg) in fried O. niloticus, grilled O. niloticus, smoked herring and salted sardine were 0.11±0.01, 0.14±0.01, 0.20±0.01 and 0.29±0.01, respectively. The mean values of aldrin (ppb) only detected in fried O. niloticus, grilled O. niloticus and salted sardine were 82.95±4.19, 151.26±7.40 and 193.02±8.81, respectively. The mean values of malathion (ppb) only detected in grilled O. niloticus and salted sardine were 96.57 and 248.19±10.32, respectively. As conclusion, chemical examination of RTE fish products is a sensitive indicator verifying the quality and good hygienic status of RTE fish products. Keywords: Mercury; Lead; Cadmium; Aldrin; Malathion

Pure surimi of silver carp (Hypophthalmichthys molitrix) cannot meet the texture requirements in novel 3D printing of food. In this work, the effect mechanism of adding soluble pectin fiber on the quality of surimi was studied at molecular scale, and the interaction has been discussed by a novel prediction model. In comparison with pure surimi, pH and water-holding capacity decreased with increasing pectin, and texture properties improved. The storage modulus firstly rose and then decreased, reaching a maximum value of 15012 Pa at 0.5 % pectin addition. The thermal transition temperature of myosin was moved from 52.13 to 49.80 °C. Pectin extended the T

Silver carp is a type of Asian carp that poses a threat to the United States. Unfortunately, producing Asian carp surimi in the US has been unsuccessful due to the high cost. Thus, exporting Asian carp to China and other Asian countries in the form of frozen deboned fish mince (without washing) would be a new way to create commercial value. This study was to explore the effects of compound cryoprotectants CC (sucrose, sorbitol, and sodium tripolyphosphate) and CC + SD (salted egg white) on unwashed silver carp mince during frozen storage. In the presence of CC, unwashed mince exerted benefits on gel property and water holding property. CC was able to retard protein oxidation as indicated by the retarded carbonyl content and lower loss in sulfhydryl content. Based on indicators of content of salt-soluble protein, α-helix, myosin heavy chain and intrinsic fluorescence intensity, CC addition inhibited protein aggregation by protecting the protein structure. The inclusion of SD did not show a cryoprotective effect or synergistic antioxidant effect with sucrose-sorbitol, but SD improved the gel strength within 4 weeks of freezing. Thus, CC can provide cryoprotective protection during frozen storage of silver carp mince. CC + SD provides a reference for long-distance transport and off-site production of frozen silver carp mince.

Gel properties of threadfin bream surimi gels with squid fin protein hydrolysate (SFPH) at various concentrations (0, 1, 2, 3, and 4%; w/w) were determined. The gel without SFPH (CON) had the highest breaking force (BrF) and deformation (DeF) as compared to those with SFPH (p 0.05). Among the gel with SFPH, gel containing 1 and 2% SFPH (SFPH-1 and SFPH-2, respectively) had the highest BrF, whereas the lowest value was obtained when 4% SFPH was used (SFPH-4) (p 0.05). The whiteness of all samples was slightly decreased with an upsurging amount of SFPH. However, water holding capacity was increased with augmenting levels of SFPH (p 0.05). Sensory analysis revealed that SFPH-2 had a higher squid odor and flavor likeness score than CON (p 0.05). Textural properties, especially hardness, were decreased with increasing SFPH, except for SFPH-1 and SFPH-2 (p 0.05). In addition, the rheological properties, microstructure, and volatile profile of the selected surimi gel were also studied. The storage modulus (G') of SFPH added samples was decreased as compared to the CON sample. The CON gel had a finer and more compact network as compared to SFPH-2 and SFPH-4 samples. Volatile profiles indicated that alcohols, carboxylic acids, ketones, and ether were the major volatile compounds present in both gel samples. Furthermore, thiophene, 3-methyl-, contributing to squid flavor, was found in the SFPH-2 sample. Overall, SFPH at 2% could act as a flavorant in the threadfin bream surimi gel without markedly negative impact on gelling and textural properties, while providing squid odor and flavor to the resulting gel. PRACTICAL APPLICATION: The various low-valued byproducts generated from the squid processing industry could result in various environmental problems. Those byproducts are rich in various biomolecules such as proteins, fats, enzymes, and so forth, which could be utilized to produce value-added products. Among them, protein hydrolysate (PH) rich in amino acids with excellent antioxidant properties could serve as an alternative flavorant. Therefore, PH from squid byproducts, especially fins, could be applied in foods such as fish balls, surimi gels, and so forth to enhance the nutritional and flavoring profile of a finished product. Moreover, bioactive peptides in PH with antioxidant potential could retard the oxidation of proteins and lipids.

Suanyu is one of the traditional Chinese fermented fish products with a pleasant flavor. The present study sought to evaluate the effects of starter cultures and spices on the physicochemical properties and microbial flora of Suanyu after fermentation and storage. The results indicated that fermentation with mixed starter cultures could lower the pH and inhibit TVB-N formation in Suanyu after fermentation and during storage. Moreover, inoculation of starter cultures could promote free amino acids production during storage. Additionally, inoculation of mixed starter cultures and spices mixture could effectively inhibit the formation of most biogenic amines in Suanyu, revealing the significant role of mixed starter cultures. Staphylococcus, Macrococcus, and Lactobacillus were the core microbial genus in Suanyu. The inoculation of starter cultures could inhibit Enteroccoccus and other microorganisms, while spices introduced Bacillus into Suanyu. The study results provide a theoretical basis for the industrial production and storage of Suanyu.

The tilapia (Orechromis niloticus) surimi gels were prepared with high hydrostatic pressure (0, 100, 200, 300, and 400 MPa for 15 min) treatments to investigate the changes in water-holding capacity, color, gel strength, microstructure, texture, and proteins of the gels. Compared it with cooked gel (40°C/30 min + 90°C/30 min). The whiteness of heat-induced and HHP-induced gels were significant (p

Aquafeed manufacturers have reduced, but not fully eliminated, fishmeal and fish oil and are seeking cost competitive replacements. We combined two commercially available microalgae, to produce a high-performing fish-free feed for Nile tilapia (Oreochromis niloticus)—the world’s second largest group of farmed fish. We substituted protein-rich defatted biomass of Nannochloropsis oculata (leftover after oil extraction for nutraceuticals) for fishmeal and whole cells of docosahexaenoic acid (DHA)-rich Schizochytrium sp. as substitute for fish oil. We found significantly better (p p

Probiotics play vital roles in controlling diseases, enhancing specific and non-specific immunity and stimulating growth in the aquaculture industry. However, the effect of fermentation of feed by probiotics on the immune ability of sea cucumber has not been reported to date. Here, three candidate probiotic strains (Bacillus species) were isolated from the culture seawater and sediment of sea cucumber, and fishmeal and scallop mantle fermented by the candidate probiotic strains were used to feed sea cucumber. The results showed that the free amino acid and small peptide contents of the fishmeal and scallop mantle were significantly increased after fermentation for 72 h. However, the weight gain (WG) and specific growth rate (SGR) of sea cucumber showed no significant differences among the fermented fishmeal, fermented scallop mantle and control groups. Scallop mantle fermented by the three candidate probiotics could increase the coelomocyte number and respiratory burst activity. The immune-related enzymatic activity was increased after consuming the fermented fishmeal and scallop mantle, while the activity of antioxidant enzymes was reduced. The expression levels of immune- and antioxidant-related genes were changed after consuming the fermented fishmeal and scallop mantle. Taken together, our results suggest that probiotics could increase the immunocompetence of sea cucumber, and fermented scallop mantle might be a potential substitute for fishmeal during feed preparation. Our results lay a foundation for further understanding the relationship between probiotics and the non-specific immunity of sea cucumber.

The addition or exchange of cheaper fish species instead of more expensive fish species is a known form of fraud in the food industry. This can take place accidentally due to the lack of expertise or act as a fraud. The interest in detecting animal species in meat products is based on religious demands (halal and kosher) as well as on product adulterations. Authentication of fish and meat products is critical in the food industry. Meat and fish adulteration, mainly for economic pursuit, is widespread and leads to serious public health risks, religious violations, and moral loss. Economically motivated adulteration of food is estimated to create damage of around € 8 to 12 billion per year. Rapid, effective, accurate, and reliable detection technologies are keys to effectively supervising meat and fish adulteration. Various analytical methods often based on protein or DNA measurements are utilized to identify fish and meat species. Although many strategies have been adopted to assure the authenticity of fish and meat and meat a fish products, such as the protected designation of origin, protected geographical indication, certificate of specific characteristics, and so on, the coverage is too small, and it is unrealistic to certify all meat products for protection from adulteration. Therefore, effective supervision is very important for ensuring the suitable development of the meat industry, and rapid, effective, accurate, and reliable detection technologies are fundamental technical support for this goal. Recently, several methods, including DNA analysis, protein analysis, and fat-based analysis, have been effectively employed for the identification of meat and fish species.