Search

The current study evaluated the effects of feeding diets contaminated with aflatoxin B1 (AFB1), fumonisins (FBs), or both on the performance and health of broiler chickens and the safety of their food products as well as the efficacy of bentonite and fumonisin esterase to mitigate the effects of these mycotoxins under conditions representative for sub-Saharan Africa (SSA). Four hundred one-day-old Cobb 500 broiler chickens were randomly assigned to 20 treatments with either a control diet, a diet with moderate AFB1 (60 μg/kg feed) or high AFB1 (220 μg/kg feed), or FBs (17,430 μg FB1+FB2/kg feed), alone or in combination, a diet containing AFB1 (either 60 or 220 μg/kg) and/or FBs (17,430 μg FB1+FB2/kg) and bentonite or fumonisin esterase or both, or a diet with bentonite or fumonisin esterase only. The experimental diets were given to the birds from day 1 to day 35 of age, and the effects of the different treatments on production performance were assessed by feed intake (FI), body weight gain (BWG), and feed conversion ratio (FCR). Possible health effects were evaluated through blood biochemistry, organ weights, mortality, liver gross pathological changes, and vaccine response. Residues of aflatoxins (AFB1, B2, G1, G2, M1 and M2) were determined in plasma, muscle, and liver tissues using validated UHPLC-MS/MS methods. The results obtained indicated that broiler chickens fed high AFB1 alone had poor FCR when compared to a diet with both high AFB1 and FBs ( p = 0.0063). Serum total protein and albumin from birds fed FBs only or in combination with moderate or high AFB1 or detoxifiers increased when compared to the control ( p < 0.05). Liver gross pathological changes were more pronounced in birds fed contaminated diets when compared to birds fed the control or diets supplemented with mycotoxin detoxifiers. The relative weight of the heart was significantly higher in birds fed high AFB1 and FBs when compared to the control or high AFB1 only diets ( p < 0.05), indicating interactions between the mycotoxins. Inclusion of bentonite in AFB1-contaminated diets offered a protective effect on the change in weights of the liver, heart and spleen ( p < 0.05). Residues of AFB1 were detected above the limit of quantification (max: 0.12 ± 0.03 μg/kg) in liver samples only, from birds fed a diet with high AFB1 only or with FBs or the detoxifiers. Supplementing bentonite into these AFB1-contaminated diets reduced the levels of the liver AFB1 residues by up to 50%. Bentonite or fumonisin esterase, alone, did not affect the performance and health of broiler chickens. Thus, at the doses tested, both detoxifiers were safe and efficient for use as valid means of counteracting the negative effects of AFB1 and FBs as well as transfer of AFB1 to food products (liver) of broiler chickens.

The poultry industry in sub-Saharan Africa (SSA) is faced with feed insecurity, associated with high cost of feeds, and feed safety, associated with locally produced feeds often contaminated with mycotoxins. Mycotoxins, including aflatoxins (AFs), fumonisins (FBs), trichothecenes, and zearalenone (ZEN), are common contaminants of poultry feeds and feed ingredients from SSA. These mycotoxins cause deleterious effects on the health and productivity of chickens and can also be present in poultry food products, thereby posing a health hazard to human consumers of these products. This review summarizes studies of major mycotoxins in poultry feeds, feed ingredients, and poultry food products from SSA as well as aflatoxicosis outbreaks. Additionally reviewed are the worldwide regulation of mycotoxins in poultry feeds, the impact of major mycotoxins in the production of chickens, and the postharvest use of mycotoxin detoxifiers. In most studies, AFs are most commonly quantified, and levels above the European Union regulatory limits of 20 μg/kg are reported. Trichothecenes, FBs, ZEN, and OTA are also reported but are less frequently analyzed. Co-occurrences of mycotoxins, especially AFs and FBs, are reported in some studies. The effects of AFs on chickens' health and productivity, carryover to their products, as well as use of mycotoxin binders are reported in few studies conducted in SSA. More research should therefore be conducted in SSA to evaluate occurrences, toxicological effects, and mitigation strategies to prevent the toxic effects of mycotoxins.

Mycotoxins are secondary metabolites of fungi that contaminate food and feed and have a significant negative impact on human and animal health and productivity. The tropical condition in Sub-Saharan Africa (SSA) together with poor storage of feed promotes fungal growth and subsequent mycotoxin production. Aflatoxins (AF) produced by Aspergillus species, fumonisins (FUM), zearalenone (ZEN), T-2 toxin (T-2), and deoxynivalenol (DON) produced by Fusarium species, and ochratoxin A (OTA) produced by Penicillium and Aspergillus species are well-known mycotoxins of agricultural importance. Consumption of feed contaminated with these toxins may cause mycotoxicoses in animals, characterized by a range of clinical signs depending on the toxin, and losses in the animal industry. In SSA, contamination of dairy feed with mycotoxins has been frequently reported, which poses a serious constraint to animal health and productivity, and is also a hazard to human health since some mycotoxins and their metabolites are excreted in milk, especially aflatoxin M1. This review describes the major mycotoxins, their occurrence, and impact in dairy cattle diets in SSA highlighting the problems related to animal health, productivity, and food safety and the up-to-date post-harvest mitigation strategies for the prevention and reduction of contamination of dairy feed.

Warm and humid climatic conditions coupled with poor agricultural practices in sub-Saharan Africa favor the contamination of food and feed by Aspergillus flavus and Fusarium verticillioides fungi, which subsequently may produce aflatoxins (AFs) and fumonisins (FBs), respectively. The growth of fungi and the production of mycotoxins are influenced by physical (temperature, pH, water activity, light and aeration), nutritional, and biological factors. This study aimed at optimizing the conditions for the laboratory production of large quantities of AFs and FBs for use in the animal experiments. A. flavus and F. verticillioides strains, previously isolated from maize in Kenya, were used. Levels of AFB1 and total FBs (FB1, FB2, and FB3) in different growth substrates were screened using ELISA methods. Maize kernels inoculated with three different strains of A. flavus simultaneously and incubated at 29 °C for 21 days had the highest AFB1 level of 12,550 ± 3397 μg/kg of substrate. The highest level of total FBs (386,533 ± 153,302 μg/kg of substrate) was detected in cracked maize inoculated with three different strains of F. verticillioides and incubated for 21 days at temperatures of 22–25 °C in a growth chamber fitted with yellow light. These two methods are recommended for the mass production of AFB1 and FBs for animal feeding trials. [ABSTRACT FROM AUTHOR]

The occurrence of aflatoxin M1 (AFM1) in milk has been widely reported in Kenya, with levels freqently exceeding national and international thresholds. Exposure to aflatoxin increases the risk of hepatic cancers and can also have other negative health impacts in children such as growth impairment and immunosuppression. Anti-mycotoxin agents (AMAs) included in contaminated feeds can greatly reduce the amount of AFM1 released in milk. A 45-day trial was designed to assess secretion of AFM1 in milk from individual cows fed commercial Kenyan dairy feed, as well as the efficacy of Novasil™ Plus in reducing the levels. A four-by-four Latin square cross-over design was used for the experiment. Four cows were fed on naturally contaminated with AFB1 feed, with levels ranging from 19 to 47 µg/kg, and either no binder or inclusion of binder at the rate of 0.6 or 1.2%. Milk samples were collected each day and analyzed for AFM1. The results showed that AFM1 levels in the milk varied between the cows, even when fed similar levels of contaminated feed. On average, inclusion of 0.6% binder into the diet resulted in 34% decline in milk AFM1 levels, while 1.2% binder dose resulted in a decline of 45%. Significant reduction in AFM1 secretion was observed in all experimental units (p < 0.005), though only minimal reduction was recorded in one of the units (Cow 4) compared to the other three. This trial shows novel data on aflatoxin exposure and excretion in Kenyan dairy cows in a field setting where AFB1 level is uncontrolled. We demonstrate significant reduction in AFM1 secretion in milk using AMA, though AFM1 levels were still above the recommended EC standard of 50 ŋg/kg. This study suggests that AMAs alone cannot be relied on to reduce AFM1 in milk to safe levels. Training and good feeding practices are recommended in addition to use of AMAs. [ABSTRACT FROM AUTHOR]

Milk is an important source of energy and nutrients, especially for children, and in Kenya, milk consumption is higher than other countries in the region. One major concern with milk is the risks of chemical contaminants, and reports of high levels of aflatoxin M1 (AFM1) in milk in Kenya has been causing public health concerns. This study collected marketed milk products every month during 1 year, just as a consumer would purchase them from retailers and traders in a low-income area, and a major supermarket in a middle/high-income area. In total, 291 sampled milk products (raw, pasteurised, UHT milk, yoghurt and lala) were collected and analysed for AFM1 using a commercial ELISA kit. More than 50% of the samples exceeded 50 ng/kg (the level allowed in the EU), but only three samples exceeded 500 ng/kg (the level allowed in the USA). Geometric mean AFM1 level was 61.9 ng/kg in the 135 samples from the low-income area while it was 36.1 ng/kg in the 156 from the higher income area (p < 0.001). The levels varied significantly depending on the time of year, with lowest levels of milk in January. There were also differences between manufacturers and products, with UHT milk having lower levels. There was no difference depending on the price for all dairy products, but when only including milk, higher price was associated with lower levels of AFM1. In conclusion, this study shows that milk purchased by a consumer is likely to contain AFM1 above 50 ng/kg, and that further research is needed to find ways to mitigate AFM1 contamination through working with farmers and milk processors both in the formal and informal sectors. [ABSTRACT FROM AUTHOR]

Aflatoxin B1 (AFB1), a toxic fungal metabolite associated with human and animal diseases, is a natural contaminant encountered in agricultural commodities, food and feed. Heterogeneity of AFB1 makes risk estimation a challenge. To overcome this, novel sample selection, preparation and extraction steps were designed for representative sampling of chicken feed. Accuracy, precision, limits of detection and quantification, linearity, robustness and ruggedness were used as performance criteria to validate this modification and Horwitz function for evaluating precision. A modified sampling protocol that ensured representativeness is documented, including sample selection, sampling tools, random procedures, minimum size of field-collected aggregate samples (primary sampling), procedures for mass reduction to 2 kg laboratory (secondary sampling), 25 g test portion (tertiary sampling) and 1.3 g analytical samples (quaternary sampling). The improved coning and quartering procedure described herein (for secondary and tertiary sampling) has acceptable precision, with a Horwitz ratio (HorRat = 0.3) suitable for splitting of 25 g feed aliquots from laboratory samples (tertiary sampling). The water slurring innovation (quaternary sampling) increased aflatoxin extraction efficiency to 95.1% through reduction of both bias (−4.95) and variability of recovery (1.2–1.4) and improved both intra-laboratory precision (HorRat = 1.2–1.5) and within-laboratory reproducibility (HorRat = 0.9–1.3). Optimal extraction conditions are documented. The improved procedure showed satisfactory performance, good field applicability and reduced sample analysis turnaround time. [ABSTRACT FROM AUTHOR]

Mycotoxins are common in grains in sub-Saharan Africa and negatively impact human and animal health and production. This study assessed occurrences of mycotoxins, some plant, and bacterial metabolites in 16 dairy and 27 poultry feeds, and 24 feed ingredients from Machakos town, Kenya, in February and August 2019. We analyzed the samples using a validated multi-toxin liquid chromatography-tandem mass spectrometry method. A total of 153 mycotoxins, plant, and bacterial toxins, were detected in the samples. All the samples were co-contaminated with 21 to 116 different mycotoxins and/or metabolites. The commonly occurring and EU regulated mycotoxins reported were; aflatoxins (AFs) (70%; range 0.2–318.5 μg/kg), deoxynivalenol (82%; range 22.2–1037 μg/kg), ergot alkaloids (70%; range 0.4–285.7 μg/kg), fumonisins (90%; range 32.4–14,346 μg/kg), HT-2 toxin (3%; range 11.9–13.8 μg/kg), ochratoxin A (24%; range 1.1–24.3 μg/kg), T-2 toxin (4%; range 2.7–5.2 μg/kg) and zearalenone (94%; range 0.3–910.4 μg/kg). Other unregulated emerging mycotoxins and metabolites including Alternaria toxins, Aspergillus toxins, bacterial metabolites, cytochalasins, depsipeptides, Fusarium metabolites, metabolites from other fungi, Penicillium toxins, phytoestrogens, plant metabolites, and unspecific metabolites were also detected at varying levels. Except for total AFs, where the average contamination level was above the EU regulatory limit, all the other mycotoxins detected had average contamination levels below the limits. Ninety-six percent of all the samples were contaminated with more than one of the EU regulated mycotoxins. These co-occurrences may cause synergistic and additive health effects thereby hindering the growth of the Kenyan livestock sector. [ABSTRACT FROM AUTHOR]

Milk is an important commodity in Kenya; the country has the largest dairy herd and highest per capita milk consumption in East Africa. As such, hazards in milk are of concern. Aflatoxin M1 (AFM1) is a toxic metabolite of aflatoxin B1 (AFB1) excreted in milk by lactating animals after ingesting AFB1-contaminated feeds. This metabolite is injurious to human health, but there is little information on the risk to human health posed by AFM1 in milk in rural Kenya. To fill this gap, a quantitative risk assessment (QRA) applying probabilistic statistical tools to quantify risks was conducted. This assessed the risk of liver cancer posed by AFM1 in milk, assuming 10-fold lower carcinogenicity than AFB1. Data from four agro–ecological zones in Kenya (semi-arid, temperate, sub-humid and humid) were used. We estimated that people were exposed to between 0.3 and 1 ng AFM1 per kg body weight per day through the consumption of milk. The annual incidence rates of cancer attributed to the consumption of AFM1 in milk were 3.5 × 10−3 (95% CI: 3 × 10−3–3.9 × 10−3), 2.9 × 10−3 (95% CI: 2.5 × 10−3–3.3 × 10−3), 1.4 × 10−3 (95% CI: 1.2 × 10−3–1.5 × 10−3) and 2.7 × 10−3 (95% CI: 2.3 × 10−3–3 × 10−3) cancers per 100,000 in adult females, adult males, children 6–18 years old, and in children less than five years old, respectively. Our results show that aflatoxin exposure from milk contributes relatively little to the incidence of liver cancer. Nonetheless, risk managers should take action based on cumulative exposure from all sources of aflatoxins. [ABSTRACT FROM AUTHOR]