Search

The effect of ozonation of anaerobic digested sludge on methane production was studied as a means of increasing the capacity of municipal anaerobic digesters. Ozone doses ranging from 0 to 192 mg O 3 /g sludge COD were evaluated in batch tests with a bench scale ozonation unit. Ozonation initially, and temporarily, reduced biomass viability and acetoclastic methanogenic activity, resulting in an initial lag phase ranging from 0.8 to 10 days. Following this lag phase, ozonation enhanced methane production with an optimal methane yield attained at 86 mg O 3 /g COD. Under these conditions, the yield of methane and the rate of its formation were 52% and 95% higher, respectively, than those factors measured without ozonation. A required optimal ozone dose could be feasible to improve the anaerobic digestion performance by increasing the methane production potential with a minimum impact on microbial activity; thus, an optimal ozone dose would enable an increase in the capacity of anaerobic digesters., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

The purpose of this research was the investigation of the ozonation of sludge as a method to improve anaerobic digestion performance in a chemically enhanced primary treatment facility. Batch tests were conducted to evaluate the effect of ozonation on the physicochemical characteristics of both primary and digested sludge. Then, the performance of semi-continuous anaerobic digesters in combination with ozone treatment was investigated (pre-ozonation and post-ozonation). Ozonation of primary sludge did not increase the soluble COD nor the biodegradable COD, but resulted in the mineralization of a fraction of the organic matter into CO2. However, the ozonation of anaerobic digested sludge resulted in an increase in soluble COD and biodegradable COD and in a small level of mineralization at the dose of 90 mg O3/g COD. Pre-ozonation of primary sludge was not effective in enhancing the performance of the anaerobic digester. The coupling of ozonation and anaerobic digestion by means of the post-ozonation of digested sludge was found to be effective in improving methane production (+16%), for COD removal efficiency and for the dewaterability of anaerobic digesters compared to the control digester. [ABSTRACT FROM AUTHOR]