Search

The enhanced permeability and retention (EPR) effect controls passive nanodrug uptake in tumors and may provide a high tumor payload with prolonged retention for cancer treatment. However, EPR-mediated tumor uptake and distribution vary by cancer phenotype. Thus, we hypothesized that a companion PET imaging surrogate may benefit EPR-mediated therapeutic drug delivery. We developed two 89Zr-radiolabeled nanocarriers based on 4-armed starPEG40kDa with or without talazoparib (TLZ), a potent PARP inhibitor, as surrogates for the PEG-TLZ4 therapeutic scaffold. For PET imaging, PEG-DFB4 and PEG-DFB1-TLZ3 were radiolabeled with 89Zr by replacing one or all four copis of TLZ on PEG-TLZ4 with deferoxamine B (DFB). The radiolabeled nanodrugs [89Zr]PEG-DFB4 and [89Zr]PEG-DFB1-TLZ3 were tested in vivo in prostate cancer subcutaneous (s.c.) xenografts (22Rv1, LTL-545, and LTL-610) and 22Rv1 metastatic models. Their EPR-mediated tumoral uptake and penetration was compared with CT26, a known EPR-high cell line. MicroPET/CT images, organ biodistribution, and calculated kinetic parameters showed high uptake in CT26 and LTL-545 and moderate to low uptake in LTL-610 and 22Rv1. MicroPET/CT and high-resolution autoradiographic images showed nanocarrier penetration into highly permeable CT26, but heterogeneous peripheral accumulation was observed in LTL-545, LTL-610, and 22Rv1 s.c. xenografts and metastatic tumors. CD31 staining of tumor sections showed homogenous vascular development in CT26 tumors and heterogeneity in other xenografts. Both [89Zr]PEG-DFB4 and [89Zr]PEG-DFB1-TLZ3 showed similar accumulation and distribution in s.c. and metastatic tumor models. Both nanocarriers can measure tumor model passive uptake heterogeneity. Although heterogeneous, prostate cancer xenografts had low EPR. These starPEG nanocarriers could be used as PET imaging surrogates to predict drug delivery and efficacy., (©2024 The Authors; Published by the American Association for Cancer Research.)

The objective of this work was to develop a long-acting form of the lipidated peptide semaglutide that can be administered to humans once-monthly. Semaglutide was attached to hydrogel microspheres by a cleavable linker with an expected in vivo release half-life of about 1 mo. After a single subcutaneous dose, the pharmacokinetic parameters of released semaglutide and bodyweight loss were determined in mice, and results were used to estimate the dosing and pharmacokinetics of the released semaglutide in humans. The in vivo half-life of released semaglutide was ~36 d, and a single dose in diet-induced obese mice resulted in a lean-sparing body weight loss of 20% over 1 mo, statistically the same as semaglutide dosed twice daily. Simulations indicated the microsphere-semaglutide would permit once-monthly administration in humans; moreover, it could maintain the therapeutic minimum concentration (C min ) of once-weekly semaglutide with only 75% of the once-weekly maximum concentration (C max ), a feature that could reduce adverse side effects or allow higher dosing. The same approach should enable the conversion of other lipidated peptides from once-weekly to once-monthly administration., Competing Interests: Competing interests statement:All authors are employees and hold options or stock in ProLynx.

Introduction: IL-15 agonists hold promise as immunotherapeutics due to their ability to induce the proliferation and expansion of cytotoxic immune cells including natural killer (NK) and CD8 + T cells. However, they generally have short half-lives that necessitate frequent administration to achieve efficacy. To address this limitation, we have developed a half-life extension technology using hydrogel microspheres (MS). Here, the therapeutic is tethered to MSs by a releasable linker with pre-programed cleavage rates. We previously showed the MS conjugate of single-chain IL-15, MS~IL-15, effectively increased the half-life of IL-15 to approximately 1 week and enhanced the pharmacodynamics. We sought to determine whether the same would be true with a MS conjugate of the IL-15 agonist, receptor-linker IL-15 (RLI)., Methods: We prepared a long acting MS conjugate of RLI, MS~RLI. The pharmacokinetics and pharmacodynamics of MS~RLI were measured in C57BL/6J mice and compared to MS~IL-15. The antitumor efficacy of MS~RLI was measured when delivered subcutaneously or intratumorally in the CT26 tumor model and intratumorally in the orthotopic EO771 tumor model., Results: MS~RLI exhibited a half-life of 30 h, longer than most IL-15 agonists but shorter than MS~IL-15. The shorter than expected half-life of MS~RLI was shown to be due to target-mediated-disposition caused by an IL-15 induced cytokine sink. MS~RLI resulted in very potent stimulation of NK and CD44 hi CD8 + T cells, but also caused significant injection-site toxicity that may preclude subcutaneous administration. We thus pivoted our efforts toward studying the MS~RLI for long-acting intra-tumoral therapy, where some degree of necrosis might be beneficial. When delivered intra- tumorally, both MS~IL-15 and MS~RLI had modest anti-tumor efficacy, but high anti- metastatic activity., Conclusion: Intra-tumoral MS~RLI and MS~RLI combined with systemic treatment with other agents could provide beneficial antitumor and anti-metastatic effects without the toxic effects of systemic IL-15 agonists. Our findings demonstrate that intra-tumorally administered long-acting IL-15 agonists counter two criticisms of loco-regional therapy: the necessity for frequent injections and the challenge of managing metastases., Competing Interests: JH, RF, GH, GA and DVS are employees and hold options or stock in ProLynx Inc. BF and GP are inventors on US Government-owned patents related to hetIL-15. The remaining authors declare that the research was conducted in the absence of any commercial or financial relationships that could be construed as a potential conflict of interest., (Copyright © 2024 Hangasky, Fernández, Stellas, Hails, Karaliota, Ashley, Felber, Pavlakis and Santi.)

The tumor uptake of large non-targeted nanocarriers primarily occurs through passive extravasation, known as the enhanced permeability and retention (EPR) effect. Prior studies demonstrated improved tumor uptake and retention of 4-arm 40 kDa star polyethylene glycol (StarPEG) polymers for cancer imaging by adding prostate-specific membrane antigen (PSMA) targeting small molecule ligands. To test PSMA-targeted delivery and therapeutic efficacy, StarPEG nanodrugs with/without three copies of PSMA-targeting ligands, ACUPA, are designed and synthesized. For single-photon emission computed tomography (SPECT) imaging and therapy, each nanocarrier is labeled with 177Lu using DOTA radiometal chelator. The radiolabeled nanodrugs, [177Lu]PEG-(DOTA)1 and [177Lu]PEG-(DOTA)1(ACUPA)3, are evaluated in vitro and in vivo using PSMA+ PC3-Pip and/or PSMA- PC3-Flu cell lines, subcutaneous xenografts and disseminated metastatic models. The nanocarriers are efficiently radiolabeled with 177Lu with molar activities 10.8-15.8 MBq/nmol. Besides excellent in vitro PSMA binding affinity (kD = 51.7 nM), the targeted nanocarrier, [177Lu]PEG-(DOTA)1(ACUPA)3, demonstrated excellent in vivo SPECT imaging contrast with 21.3% ID/g PC3-Pip tumors uptake at 192 h. Single doses of 18.5 MBq [177Lu]PEG-(DOTA)1(ACUPA)3 showed complete resolution of the PC3-Pip xenografts observed up to 138 days. Along with PSMA-targeted excellent imaging contrast, these results demonstrated high treatment efficacy of [177Lu]PEG-(DOTA)1(ACUPA)3 for prostate cancer, with potential for clinical translation., (© 2024 The Authors. Advanced Healthcare Materials published by Wiley‐VCH GmbH.)

Intratumoral (IT) therapy is a powerful method of controlling tumor growth, but a major unsolved problem is the rapidity that injected drugs exit tumors, limiting on-target exposure and efficacy. We have developed a generic long acting IT delivery system in which a drug is covalently tethered to hydrogel microspheres (MS) by a cleavable linker; upon injection the conjugate forms a depot that slowly releases the drug and "bathes" the tumor for long periods. We established technology to measure tissue pharmacokinetics and studied MSs attached to SN-38, a topoisomerase 1 inhibitor. When MS ~ SN-38 was injected locally, tissues showed high levels of SN-38 with a long half-life of ~ 1 week. IT MS ~ SN-38 was ~ tenfold more efficacious as an anti-tumor agent than systemic SN-38. We also propose and provide an example that long-acting IT therapy might enable safe use of two drugs with overlapping toxicities. Here, long-acting IT MS ~ SN-38 is delivered with concurrent systemic PARP inhibitor. The tumor is exposed to both drugs whereas other tissues are exposed only to the systemic drug; synergistic anti-tumor activity supported the validity of this approach. We propose use of this approach to increase efficacy and reduce toxicities of combinations of immune checkpoint inhibitors such as αCTLA-4 and αPD-1., (© 2024. The Author(s).)

Poly(ADP-ribose) polymerase inhibitors (PARPi) have been approved for once or twice daily oral use in the treatment of cancers with BRCA defects. However, for some patients, oral administration of PARPi may be impractical or intolerable, and a long-acting injectable formulation is desirable. We recently developed a long-acting PEGylated PARPi prodrug, PEG∼talazoparib (TLZ), which suppressed the growth of PARPi-sensitive tumors in mice for very long periods. However, the release rate of TLZ from the conjugate was too fast to be optimal in humans. We prepared several new PEG∼TLZ prodrugs having longer half-lives of drug release and accurately measured their pharmacokinetics in the rat. Using the rates of release of TLZ from these prodrugs and the known pharmacokinetics of free TLZ in humans, we simulated the pharmacokinetics of the macromolecular prodrugs and released TLZ in humans. From several possibilities, we chose two conjugates that could be administered intravenously every 2 weeks and maintain TLZ within its known therapeutic window. We describe situations where the PEG∼TLZ conjugates would find utility in humans and suggest how the intravenously administered long-acting prodrugs could in fact be more effective than daily oral administration of free TLZ.

We previously proposed that sacituzumab govitecan (SG, Trodelvy®) likely acts as a simple prodrug of systemic SN-38 as well as an antibody drug conjugate (ADC). In the present commentary, we assess whether a long-acting SN-38 prodrug, such as PLX038, might be efficacious in SG-resistant patients. We first describe possible mechanisms of action of SG, with new insights on pharmacokinetics and TROP2 receptor occupancy. We argue that SG is not an optimal conventional ADC and that the amount of systemic SN-38 spontaneously hydrolyzed from the ADC is so high it must have activity. Then, we describe the concept of time-over-target as related to the pharmacology of SG and PLX038 as SN-38 prodrugs. To be clear, we are not in any way suggesting that PLX038 or any SN-38 prodrug is superior to SG as an anticancer agent. Clearly, SG has the benefit over antigen-independent SN-38 prodrugs in that it targets cells with the TROP2 receptor. However, we surmise that PLX038 should be a more efficacious and less toxic prodrug of systemic SN-38 than SG. Finally, we suggest possible mechanisms of SG resistance and how PLX038 might perform in the context of each. Taken together, we argue that-contrary to many opinions-SG does not exclusively act as a conventional ADC, and propose that PLX038 may be efficacious in some settings of SG-resistance., (© 2024. This is a U.S. Government work and not under copyright protection in the US; foreign copyright protection may apply.)

Exatecan (Exa) is a very potent inhibitor of topoisomerase I and anticancer agent. It has been intensively studied as a single agent, a large macromolecular conjugate and as the payload component of antigen-dependent antibody-drug conjugates. The current work describes an antigen-independent conjugate of Exa with polyethylene glycol (PEG) that slowly releases free Exa. Exa was conjugated to a 4-arm 40 kDa PEG through a β-eliminative cleavable linker. Pharmacokinetic studies in mice showed that the conjugate has an apparent circulating half-life of 12 hours, which reflects a composite of both the rate of renal elimination (half-life ∼18 hours) and release of Exa (half-life ∼40 hours). Remarkably, a single low dose of 10 μmol/kg PEG-Exa-only approximately 0.2 μmol/mouse-caused complete suppression of tumor growth of BRCA1-deficient MX-1 xenografts lasting over 40 days. A single low dose of 2.5 μmol/kg PEG-Exa administered with low but efficacious doses of the PARP inhibitor talazoparib showed strong synergy and caused significant tumor regression. Furthermore, the same low, single dose of PEG-Exa administered with the ATR inhibitor VX970 at doses of the DNA damage response inhibitor that do not affect tumor growth show high tumor regression, strong synergy, and synthetic lethality., Significance: A circulating conjugate that slowly releases Exa is described. It is efficacious after a single dose and synergistic with ATR and PARP inhibitors., (© 2023 The Authors; Published by the American Association for Cancer Research.)

Tumoral uptake of large-size nanoparticles is mediated by the enhanced permeability and retention (EPR) effect, with variable accumulation and heterogenous tumor tissue penetration depending on the tumor phenotype. The performance of nanocarriers via specific targeting has the potential to improve imaging contrast and therapeutic efficacy in vivo with increased deep tissue penetration. To address this hypothesis, we designed and synthesized prostate cancer-targeting starPEG nanocarriers (40 kDa, 15 nm), [ 89 Zr]PEG-(DFB) 3 (ACUPA) 1 and [ 89 Zr]PEG-(DFB) 1 (ACUPA) 3 , with one or three prostate-specific membrane antigen (PSMA)-targeting ACUPA ligands. The in vitro PSMA binding affinity and in vivo pharmacokinetics of the targeted nanocarriers were compared with a nontargeted starPEG, [ 89 Zr]PEG-(DFB) 4 , in PSMA+ PC3-Pip and PSMA- PC3-Flu cells, and xenografts. Increasing the number of ACUPA ligands improved the in vitro binding affinity of PEG-derived polymers to PC3-Pip cells. While both PSMA-targeted nanocarriers significantly improved tissue penetration in PC3-Pip tumors, the multivalent [ 89 Zr]PEG-(DFB) 1 (ACUPA) 3 showed a remarkably higher PC3-Pip/blood ratio and background clearance. In contrast, the nontargeted [ 89 Zr]PEG-(DFB) 4 showed low EPR-mediated accumulation with poor tumor tissue penetration. Overall, ACUPA conjugated targeted starPEGs significantly improve tumor retention with deep tumor tissue penetration in low EPR PC3-Pip xenografts. These data suggest that PSMA targeting with multivalent ACUPA ligands may be a generally applicable strategy to increase nanocarrier delivery to prostate cancer. These targeted multivalent nanocarriers with high tumor binding and low healthy tissue retention could be employed in imaging and therapeutic applications.

Alterations in the ATM gene are among the most common somatic and hereditary cancer mutations, and ATM-deficient tumors are hypersensitive to DNA-damaging agents. A synthetic lethal combination of DNA-damaging agents and DNA repair inhibitors could have widespread utility in ATM-deficient cancers. However, overlapping normal tissue toxicities from these drug classes have precluded their clinical translation. We investigated PLX038, a releasable polyethylene glycol-conjugate of the topoisomerase I inhibitor SN-38, in ATM wild-type and null isogenic xenografts and in a BRCA1-deficient xenograft. PLX038 monotherapy and combination with PARP inhibition potently inhibited the growth of both BRCA1- and ATM-deficient tumors. A patient with an ATM-mutated breast cancer treated with PLX038 and the PARP inhibitor rucaparib achieved rapid, symptomatic, and radiographic complete response lasting 12 months. Single-agent PLX038 or PLX038 in combination with DNA damage response inhibitors are novel therapeutic paradigms for patients with ATM-loss cancers., (©2022 American Association for Cancer Research.)

The C-natriuretic peptide (CNP) analog vosoritide has recently been approved for treatment of achondroplasia in children. However, the regimen requires daily subcutaneous injections in pediatric patients over multiple years. The present work sought to develop a long-acting CNP that would provide efficacy equal to or greater than that of vosoritide but require less frequent injections. We used a technology for half-life extension, whereby a drug is attached to tetra-polyethylene glycol hydrogels (tetra-PEG) by β-eliminative linkers that cleave at predetermined rates. These hydrogels-fabricated as uniform ∼60-μm microspheres-are injected subcutaneously, where they serve as a stationary depot to slowly release the drug into the systemic circulation. We prepared a highly active, stable CNP analog-[Gln 6,14 ]CNP-38-composed of the 38 C-terminal amino acids of human CNP-53 containing Asn to Gln substitutions to preclude degradative deamidation. Two microsphere [Gln 6,14 ]CNP-38 conjugates were prepared, with release rates designed to allow once-weekly and once-monthly administration. After subcutaneous injection of the conjugates in mice, [Gln 6,14 ]CNP-38 was slowly released into the systemic circulation and showed biphasic elimination pharmacokinetics with terminal half-lives of ∼200 and ∼600 h. Both preparations increased growth of mice comparable to or exceeding that produced by daily vosoritide. Simulations of the pharmacokinetics in humans indicated that plasma [Gln 6,14 ]CNP-38 levels should be maintained within a therapeutic window over weekly, biweekly, and likely, monthly dosing intervals. Compared with vosoritide, which requires ∼30 injections per month, microsphere [Gln 6,14 ]CNP-38 conjugates-especially the biweekly and monthly dosing-could provide an alternative that would be well accepted by physicians, patients, and patient caregivers.

β-Elimination of drugs tethered to macromolecular carbamates provides a platform for drug half-life extension. However, the macromolecular Michael acceptor products formed upon drug release can potentially react with biological amines and thiols and may raise concerns about safety. We desired to mitigate this possibility by developing linkers that have predictable rates of β-elimination but suppressed rates of nucleophilic addition to their Michael acceptor products. We prepared Michael acceptor products of β-eliminative linkers that contained a methyl group at the Cβ carbon or a gem -dimethyl group at the Cγ carbon and studied the kinetics of their reactions with the most prevalent biological nucleophiles-amine and thiol groups. Aza-Michael reactions with glycine are slowed about 20-fold by methylation of the β-carbon and 175-fold with a gem -dimethyl group at the γ-carbon. Likewise, addition of the glutathione thiol to γ- gem -dimethyl Michael acceptors was retarded 7-24-fold compared to parent unsubstituted linkers. It was estimated that in an in vivo environment of ∼0.5 mM macromolecular thiols or ∼20 mM macromolecular amines-as in plasma-the reaction half-life of a typical Michael acceptor with a γ- gem -dimethyl linker could exceed 3 years for thiols or 25 years for amines. We also prepared a large series of γ- gem -dimethyl β-eliminative linkers and showed excellent structure-activity relationships of elimination rates with corresponding unsubstituted parent linkers. Finally, we compared the first-generation unsubstituted and new gem -dimethyl β-eliminative linkers in a once-monthly drug delivery system of a 39 amino acid peptide. Both linkers provided the desired half-life extension of the peptide, but the Michael acceptor formed from the gem -dimethyl linker was much less reactive. We conclude that the γ- gem -dimethyl β-eliminative linkers provide high flexibility and greatly reduce potential reactions of Michael acceptor products with biologically important nucleophiles.

PARP inhibitors are approved for treatment of cancers with BRCA1 or BRCA2 defects. In this study, we prepared and characterized a very long-acting PARP inhibitor. Synthesis of a macromolecular prodrug of talazoparib (TLZ) was achieved by covalent conjugation to a PEG 40kDa carrier via a β-eliminative releasable linker. A single injection of the PEG∼TLZ conjugate was as effective as ∼30 daily oral doses of TLZ in growth suppression of homologous recombination-defective tumors in mouse xenografts. These included the KT-10 Wilms' tumor with a PALB2 mutation, the BRCA1 -deficient MX-1 triple-negative breast cancer, and the BRCA2 -deficient DLD-1 colon cancer; the prodrug did not inhibit an isogenic DLD-1 tumor with wild-type BRCA2 . Although the half-life of PEG∼TLZ and released TLZ in the mouse was only ∼1 day, the exposure of released TLZ from a single safe, effective dose of the prodrug exceeded that of oral TLZ given daily over one month. μPET/CT imaging showed high uptake and prolonged retention of an 89Zr-labeled surrogate of PEG∼TLZ in the MX-1 BRCA1 -deficient tumor. These data suggest that the long-lasting antitumor effect of the prodrug is due to a combination of its long t 1/2 , the high exposure of TLZ released from the prodrug, increased tumor sensitivity upon continued exposure, and tumor accumulation. Using pharmacokinetic parameters of TLZ in humans, we designed a long-acting PEG∼TLZ for humans that may be superior in efficacy to daily oral TLZ and would be useful for treatment of PARP inhibitor-sensitive cancers in which oral medications are not tolerated. SIGNIFICANCE: These findings demonstrate that a single injection of a long-acting prodrug of the PARP inhibitor talazoparib in murine xenografts provides tumor suppression equivalent to a month of daily dosing of talazoparib., (©2020 American Association for Cancer Research.)

The goal was to develop and characterize a companion diagnostic for the releasable PEG 40kDa ∼SN-38 oncology drug, PLX038, that would identify tumors susceptible to high accumulation of PLX038. PEG conjugates of the zirconium ligand desferroxamine B (DFB) of similar size and charge to PLX038 were prepared that contained one or four DFB, as well as one that contained three SN-38 moieties and one DFB. Uptake and associated kinetic parameters of the 89 Zr-labeled nanocarriers were determined in tumor and normal tissues in mice using μPET/CT imaging. The data were fit to physiologically based pharmacokinetic models to simulate the mass-time profiles of distribution of conjugates in the tissues of interest. The time-activity curves for normal tissues showed high levels at the earliest time of measurement due to vascularization, followed by a monophasic loss. In tumors, levels were initially lower than in normal tissues but increased to 9% to 14% of injected dose over several days. The efflux half-life in tumors was very long, approximately 400 hours, and tumor levels remained at about 10% injected dose 9 days after injection. Compared with diagnostic liposomes, the PEG nanocarriers have a longer serum half-life, are retained in tumors at higher levels, remain there longer, and afford higher tumor exposure. The small PEG 40kDa nanocarriers studied here show properties for passive targeting of tumors that are superior than most nanoparticles and might be effective probes to identify tumors susceptible to similar size therapeutic nanocarriers such as PLX038., (©2019 American Association for Cancer Research.)

Purpose: The purpose of this study was to determine the importance of UGT1A1 activity on the metabolism and pharmacokinetics of a releasable PEG ~ SN-38 conjugate, PLX038A. Irinotecan (CPT-11) is converted to the topoisomerase 1 inhibitor SN-38 by first-pass hepatic metabolism and is converted to its glucuronide SN-38G by UGT1A1. With diminished UGT1A1 activity, the high liver exposure to SN-38 can cause increased toxicity of CPT-11. In contrast, releasable PEG ~ SN-38 conjugates-such as PLX038-release SN-38 in the vascular compartment, and only low levels of SN-38 are expected to enter the liver by transport through the OATP1B1 transporter., Methods: We measured CPT-11 and PLX038A metabolites in plasma and bile, and determined pharmacokinetics of PLX038A in UGT1A-deficient and replete rats., Results: Compared to CPT-11, treatment of rats with PLX038A results in very low levels of biliary SN-38 and SN-38G, a low flux through UGT1A, and a low SN-38G/SN-38 ratio in plasma. Further, the pharmacokinetics of plasma PLX038A and SN-38 in rats deficient in UGT1A is unchanged compared to normal rats., Conclusions: The disposition of PEGylated SN-38 is independent of UGT1A activity in rats, and PLX038 may find utility in full-dose treatment of patients who are UGT1A1*28 homozygotes or have metastatic disease with coincidental or incidental liver dysfunction.

There is growing evidence that peptidic glucagon-like peptide-1 receptor agonists (GLP-1RA), such as exenatide, may provide useful therapeutic options for treatment of feline diabetes. However, because such drugs are administered subcutaneously, it is desirable that they be long-acting and not require frequent injections. We have developed a chemically controlled delivery system to support half-life extension of peptidic therapeutics. Here, the peptide is covalently attached to hydrogel microspheres by a self-cleaving β-eliminative linker; after subcutaneous injection of the microspheres, the peptide is slowly released from the depot to the systemic circulation. Using this technology, we developed a delivery system that supports once-monthly administration of a stable exenatide analog, [Gln 28 ]exenatide, in rodents (Schneider, et al, ACS Chem Biol 12, 2107 to 2116, 2017). The purposes of the present study were a) to demonstrate pharmacokinetic and pharmacodynamic similarities of the deamidation-sensitive GLP-1RA exenatide and the closely related, more stable [Gln 28 ]exenatide and b) to develop a long-acting GLP-1RA in cats. The results show that exenatide and [Gln 28 ]exenatide injected intravenously or subcutaneously at 10 μg/kg have nearly identical pharmacokinetics in the cat-both having elimination half-lives of ∼40 min-but subcutaneously administered [Gln 28 ]exenatide has superior bioavailability-93% for [Gln 28 ]exenatide vs 52% for exenatide. The results also show that exenatide and [Gln 28 ]exenatide have similar insulinotropic activities in the cat during a high-dose intravenous glucose tolerance test; they increased the area under the curve (AUC) for insulin to a similar extent but had no effect on glucose AUC. Finally, subcutaneous injection of a microsphere-[Gln 28 ]exenatide conjugate containing an appropriate self-cleaving linker in the cat provides plasma [Gln 28 ]exenatide with a half-life of about 40 d vs 40 min with the injected free peptide. Hence, the large body of information available for exenatide can be used to facilitate clinical development of [Gln 28 ]exenatide as a treatment for feline diabetes, and the microsphere-[Gln 28 ]exenatide conjugate is quite suitable for once-monthly subcutaneous administration of the peptide in the cat., (Copyright © 2019 Elsevier Inc. All rights reserved.)

Purpose: Optimal efficacy of a macromolecular prodrug requires balancing the rate of drug release with the rate of prodrug elimination. Since circulating macromolecules have different elimination rates in different species, a prodrug optimal for one species will likely not be for another. The objectives of this work were (a) to develop an approach to optimize pharmacokinetics of a PEG~SN-38 prodrug in a particular species, (b) to use the approach to predict the pharmacokinetics of various prodrugs of SN-38 in the mouse and human, and (c) to develop a PEG~SN-38 conjugate that is optimized for mouse tumor models., Methods: We developed models that describe the pharmacokinetics of a drug released from a prodrug by the relationship between the rates of drug release and elimination of the prodrug. We tested the model by varying the release rate of SN-38 from PEG~SN-38 conjugates in the setting of a constant prodrug elimination rate in the mouse. Finally, we tested the antitumor efficacy of a PEG~SN-38 optimized for the mouse., Results: Optimization of a PEG~SN-38 prodrug was achieved by adjusting the rate of SN-38 release such that the ratio of t 1/2,β of released SN-38 to the t 1/2 of prodrug elimination was 0.2-0.8. Using this approach, we could rationalize the efficacy of previous PEGylated SN-38 prodrugs in the mouse and human. Finally, a mouse-optimized PEG~SN-38 showed remarkable antitumor activity in BRCA1-deficient MX-1 xenografts; a single dose gave tumor regression, suppression, and shrinkage of massive tumors., Conclusions: The efficacy of a macromolecular prodrug can be optimized for a given species by balancing the rate of drug release from the carrier with the rate of prodrug elimination.

Purpose: The short half lives of small molecules in the vitreous requires frequent repeated intravitreal injections that are impractical for treatment of chronic eye diseases. We sought to develop a method for increasing the intravitreal half-life of small-molecule drugs., Methods: We adapted a technology for controlled release of drugs from macromolecular carriers for use as a long-acting intravitreal delivery system for small molecules. As a prototype, a small molecule complement factor D inhibitor with an intravitreal half-life of 7 hours was covalently attached to a 4-arm PEG 40kDa by a self-cleaving β-eliminative linker with a cleavage half-life of approximately 1 week., Results: After intravitreal injection in rabbits, the drug was slowly released in the vitreous, and equilibrated with the retina and choroid. The intravitreal half-life of the intact PEG-drug conjugate in the rabbit was 7 days, and that of the released drug was 3.6 days. We simulated the anticipated pharmacokinetics of the delivery system in human vitreous, and estimated that the half-life of a 4-arm PEG 40kDa conjugate would be approximately 2 weeks, and that of the released drug would be approximately 5 days., Conclusions: We posit that a linker with a cleavage half life of 2 weeks would confer a half life of approximately 7 days to a released small molecule drug in humans, comparable to the half life of approved intravitreal injected macromolecular drugs., Translational Relevance: With this technology, a potent small molecule with an appropriate therapeutic window should be administrable by intravitreal injections in the human at once-monthly intervals.

We have developed a chemically-controlled drug delivery system in which a drug is covalently attached via a carbamate to hydrogel microspheres using a β-eliminative linker; rate-determining proton removal from a CH bond adjacent to an electron withdrawing group results in a β-elimination to cleave the carbamate and release the drug. After subcutaneous injection of the hydrogel-drug conjugate, the drug is slowly released into the systemic circulation and acquires an elimination t 1/2,β that matches the t 1/2 of linker cleavage. A similar β-eliminative linker with a slower cleavage rate is installed into crosslinks of the polymer to trigger gel degradation after drug release. We have now prepared β-eliminative linkers that contain deuterium in place of the hydrogen whose removal initiates cleavage. In vitro model systems of drug release and degelation show large primary deuterium kinetic isotope effects of k H /k D  ~ 2.5 to 3.5. Using a deuterated linker to attach the peptide octreotide to hydrogel-microspheres, the in vivo t 1/2,β of the drug was increased from ~1.5 to 4.5 weeks in the rat. Similarly, the in vivo time to biodegradation of hydrogels with deuterium-containing crosslinks could be extended ~2.5-fold compared to hydrogen-containing counterparts. Thus, the use of primary deuterium kinetic isotope effects in a single platform technology can control rates of β-elimination reactions in drug release and polymer biodegradation rates., (Copyright © 2018 Elsevier B.V. All rights reserved.)

We have developed a chemically controlled very long-acting delivery system to support once-monthly administration of a peptidic GLP-1R agonist. Initially, the prototypical GLP-1R agonist exenatide was covalently attached to hydrogel microspheres by a self-cleaving β-eliminative linker; after subcutaneous injection in rats, the peptide was slowly released into the systemic circulation. However, the short serum exenatide half-life suggested its degradation in the subcutaneous depot. We found that exenatide undergoes deamidation at Asn 28 with an in vitro and in vivo half-life of approximately 2 weeks. The [Gln 28 ]exenatide variant and exenatide showed indistinguishable GLP-1R agonist activities as well as pharmacokinetic and pharmacodynamic effects in rodents; however, unlike exenatide, [Gln 28 ]exenatide is stable for long periods. Two different hydrogel-[Gln 28 ]exenatide conjugates were prepared using β-eliminative linkers with different cleavage rates. After subcutaneous injection in rodents, the serum half-lives for the released [Gln 28 ]exenatide from the two conjugates were about 2 weeks and one month. Two monthly injections of the latter in the Zucker diabetic fatty rat showed pharmacodynamic effects indistinguishable from two months of continuously infused exenatide. Pharmacokinetic simulations indicate that the delivery system should serve well as a once-monthly GLP-1R agonist for treatment of type 2 diabetes in humans.

We developed two types of polyethylene glycol (PEG)-based surgical sealants, which we have termed the PER and PRO series. In one, the PRO series, an 8-arm PEG containing activated carbonyl end-groups was reacted with a 4-armed amino-PEG. In the second, the PER series, a 4-arm PEG containing bi-functional end groups with four azides and four activated esters was reacted by strain-promoted alkyne-azide cycloaddition with a 4-arm cyclooctyne-PEG to give a near-ideal Tetra-PEG hydrogel. The sealants showed predictably tunable strength, swelling, adhesion, and gelation properties. The gels were compared to commercially available PEG-based sealants and exhibit physical properties equivalent to or better than the standards. Variants of each gel-format were prepared that contained a β-eliminative cleavable linker in the crosslinks to control degradation rate. Linkers of this type self-cleave with half-lives spanning from hours to years, and offer the unique ability to precisely tune the degradation to match the healing process. In addition, these linkers could serve as cleavable tethers for controlled drug release. © 2016 Wiley Periodicals, Inc. J Biomed Mater Res Part B: Appl Biomater, 105B: 1602-1611, 2017., (© 2016 Wiley Periodicals, Inc.)

The utility of antigen-binding antibody fragments is often limited by their short half-lives. Half-life extension of such fragments is usually accomplished by attachment or binding to high-molecular-weight carriers that reduce the renal elimination rate. However, the higher hydrodynamic radius results in greater confinement in the vascular compartment and, thus, lower tissue distribution. We have developed a chemically controlled drug delivery system in which the drug is covalently attached to hydrogel microspheres by a self-cleaving β-eliminative linker; upon subcutaneous injection, the t 1/2,β of the released drug acquires the t 1/2 of linker cleavage. In the present work, we compared the pharmacokinetics of an anti-TNFα scFv, the same scFv attached to 40 kDa PEG by a stable linker, and the scFv attached to hydrogel microspheres by a self-cleaving linker. We also developed a general approach for the selective attachment of β-eliminative linkers to the N-termini of proteins. In rats, the scFv had a t 1/2,β of 4 h and a high volume of distribution at steady state (V d,SS ), suggesting extensive tissue distribution. The PEG-scFv conjugate had an increased t 1/2,β of about 2 days but showed a reduced V d,SS that was similar to the plasma volume. In contrast, the tissue-penetrable scFv released from the hydrogel system had a t 1/2,β of about 2 weeks. Thus, the cleavable microsphere-scFv conjugate releases its protein cargo with a prolonged half-life comparable to that of most full-length mAbs and in a form that has the high tissue distribution characteristic of smaller mAb fragments. Other antigen-binding antibody fragments should be amenable to the half-life extension approach described here.

We developed a long-acting drug-delivery system that supports subcutaneous administration of the peptidic somatostatin agonist octreotide-a blockbuster drug used to treat acromegaly and neuroendocrine tumors. The current once-a-month polymer-encapsulated octreotide, Sandostatin LAR, requires a painful intragluteal injection through a large needle by a health-care professional. To overcome such shortcomings, Tetra-PEG hydrogel microspheres were covalently attached to the α-amine of d-Phe(1) or the ε-amine of Lys(5) of octreotide by a self-cleaving β-eliminative linker; upon subcutaneous injection in the rat using a small-bore needle, octreotide was slowly released. The released drug from the ε-octreotide conjugate showed a remarkably long serum half-life that exceeded two months. The α-octreotide conjugate had a half-life of ∼2 weeks, and showed an excellent correlation of in vitro and in vivo drug release. Pharmacokinetic models indicate these microspheres should support once-weekly to once-monthly self-administered subcutaneous dosing in humans. The hydrogel-octreotide conjugate shows the favorable pharmacokinetics of Sandostatin LAR without its drawbacks.

We have developed a unique long-acting drug-delivery system for the GLP-1 agonist exenatide. The peptide was covalently attached to Tetra-PEG hydrogel microspheres by a cleavable β-eliminative linker; upon s.c. injection, the exenatide is slowly released at a rate dictated by the linker. A second β-eliminative linker with a slower cleavage rate was incorporated in polymer cross-links to trigger gel degradation after drug release. The uniform 40 μm microspheres were fabricated using a flow-focusing microfluidic device and in situ polymerization within droplets. The exenatide-laden microspheres were injected subcutaneously into the rat, and serum exenatide measured over a one-month period. Pharmacokinetic analysis showed a t1/2,β of released exenatide of about 7 days which represents over a 300-fold half-life extension in the rat and exceeds the half-life of any currently approved long-acting GLP-1 agonist. Hydrogel-exenatide conjugates gave an excellent Level A in vitro-in vivo correlation of release rates of the peptide from the gel, and indicated that exenatide release was 3-fold faster in vivo than in vitro. Pharmacokinetic simulations indicate that the hydrogel-exenatide microspheres should support weekly or biweekly subcutaneous dosing in humans. The rare ability to modify in vivo pharmacokinetics by the chemical nature of the linker indicates that an even longer acting exenatide is feasible.

We have previously developed a linker technology for half-life extension of peptides, proteins and small molecule drugs (1). The linkers undergo β-elimination reactions with predictable cleavage rates to release the native drug. Here we utilize this technology for half-life extension of the 38 amino acid HIV-1 fusion inhibitor TRI-1144. Conjugation of TRI-1144 to 40 kDa PEG by an appropriate β-eliminative linker and i.v. administration of the conjugate increased the in vivo half-life of the released peptide from 4 to 34 h in the rat, and the pharmacokinetic parameters were in excellent accord with a one-compartment model. From these data we simulated the pharmacokinetics of the PEG-TRI-1144 conjugate in humans, predicting a t1/2,β of 70 h for the released peptide, and that a serum concentration of 25 nM could be maintained by weekly doses of 8 μmol of the conjugate. Using a non-circulating carrier (2) similar simulations indicated a t1/2,β of 150 h for the peptide released from the conjugate and that dosing of only 1.8 μmol/week could maintain serum concentrations of TRI-1144 above 25 nM. Hence, releasable β-eliminative linkers provide significant half-life extension to TRI-1144 and would be expected to do likewise for related peptides., (Copyright © 2015 Elsevier B.V. All rights reserved.)

We have developed an approach to prepare drug-releasing Tetra-PEG hydrogels with exactly four cross-links per monomer. The gels contain two cleavable β-eliminative linkers: one for drug attachment that releases the drug at a predictable rate, and one with a longer half-life placed in each cross-link to control biodegradation. Thus, the system can be optimized to release the drug before significant gel degradation occurs. The synthetic approach involves placing a heterobifunctional connector at each end of a four-arm PEG prepolymer; four unique end-groups of the resultant eight-arm prepolymer are used to tether a linker-drug, and the other four are used for polymerization with a second four-arm PEG. Three different orthogonal reactions that form stable triazoles, diazines, or oximes have been used for tethering the drug to the PEG and for cross-linking the polymer. Three formats for preparing hydrogel-drug conjugates are described that either polymerize preformed PEG-drug conjugates or attach the drug postpolymerization. Degradation of drug-containing hydrogels proceeds as expected for homogeneous Tetra-PEG gels with minimal degradation occurring in early phases and sharp, predictable reverse gelation times. The minimal early degradation allows design of gels that show almost complete drug release before significant gel-drug fragments are released.

Michael-addition of a thiol to a maleimide is commonly used for bioconjugation of drugs to macromolecules. Indeed, both current FDA-approved antibody-drug conjugates-Brentuximab vedotin and Trastuzumab emtansine-and one approved PEGylated conjugate-Cimzia-contain a thiol-maleimide adduct. However, the ultimate in vivo fate of such adducts is to undergo disruptive cleavage by thiol exchange or stabilizing ring opening. Therapeutic efficacy of a conjugate can be compromised by thiol exchange and the released drug may show toxicities. However, if the succinimide moiety of a maleimide-thiol conjugate is hydrolyzed, the ring-opened product is stabilized toward cleavage. We determined rates of ring-opening hydrolysis and thiol exchange of a series of N-substituted succinimide thioethers formed by maleimide-thiol conjugation. Ring-opening of conjugates prepared with commonly used maleimides were too slow to serve as prevention against thiol exchange. However, ring-opening rates are greatly accelerated by electron withdrawing N-substituents, and ring-opened products have half-lives of over two years. Thus, conjugates made with electron-withdrawing maleimides may be purposefully hydrolyzed to their ring-opened counterparts in vitro to ensure in vivo stability.

We have recently reported a chemical approach for half-life extension that utilizes β-eliminative linkers to attach amine-containing drugs or prodrugs to macromolecules. The linkers release free drug or prodrug over periods ranging from a few hours to over 1 year. We adapted these linkers for use with phenol-containing drugs. Here, we prepared PEG conjugates of the irinotecan (CPT-11) active metabolite SN-38 via a phenyl ether that release the drug with predictable long half-lives. Pharmacokinetic studies in the rat indicate that, in contrast to other SN-38 prodrugs, the slowly released SN-38 shows a very low C(max), is kept above target concentrations for extended periods, and forms very little SN-38 glucuronide (the precursor of enterotoxic SN-38). The low SN-38 glucuronide is attributed to low hepatic uptake of SN-38. These macromolecular prodrugs have unique pharmacokinetic profiles that may translate to less intestinal toxicity and interpatient variability than the SN-38 prodrugs thus far studied.

RluB catalyses the modification of U2605 to pseudouridine (Ψ) in a stem-loop at the peptidyl transferase center of Escherichia coli 23S rRNA. The homolog RluF is specific to the adjacent nucleotide in the stem, U2604. The 1.3 Å resolution crystal structure of the complex between the catalytic domain of RluB and the isolated substrate stem-loop, in which the target uridine is substituted by 5-fluorouridine (5-FU), reveals a covalent bond between the isomerized target base and tyrosine 140. The structure is compared with the catalytic domain alone determined at 2.5 Å resolution. The RluB-bound stem-loop has essentially the same secondary structure as in the ribosome, with a bulge at A2602, but with 5-FU2605 flipped into the active site. We showed earlier that RluF induced a frame-shift of the RNA, moving A2602 into the stem and translating its target, U2604, into the active site. A hydrogen-bonding network stabilizes the bulge in the RluB-RNA but is not conserved in RluF and so RluF cannot stabilize the bulge. On the basis of the covalent bond between enzyme and isomerized 5-FU we propose a Michael addition mechanism for pseudouridine formation that is consistent with all experimental data.

We recently reported a chemical approach for half-life extension that utilizes sets of releasable linkers to attach drugs to macromolecules via a cleavable carbamate group (Santi et al., Proc. Nat. Acad. Sci. U.S.A. 2012, 109, 6211-6216). The linkers undergo a β-elimination cleavage to release the free, native amine-containing drug. A limitation of the technology is the requirement for an amino group on the drug in order to form the carbamate bond, since most small molecules do not have an amine functional group. Here, we describe an approach to adapt these same β-elimination carbamate linkers so they can be used to connect other acidic heteroatoms, in particular, phenolic hydroxyl groups. The approach utilizes a methylene adaptor to connect the drug to the carbamate nitrogen, and an electron-withdrawing group attached to carbamate nitrogen to stabilize the system against a pH-independent spontaneous cleavage. Carbamate cleavage is driven by β-elimination to give a carboxylated aryl amino Mannich base which rapidly collapses to give the free drug, an aryl amine, and formaldehyde.

Many drugs and drug candidates are suboptimal because of short duration of action. For example, peptides and proteins often have serum half-lives of only minutes to hours. One solution to this problem involves conjugation to circulating carriers, such as PEG, that retard kidney filtration and hence increase plasma half-life of the attached drug. We recently reported an approach to half-life extension that uses sets of self-cleaving linkers to attach drugs to macromolecular carriers. The linkers undergo β-eliminative cleavage to release the native drug with predictable half-lives ranging from a few hours to over 1 y; however, half-life extension becomes limited by the renal elimination rate of the circulating carrier. An approach to overcoming this constraint is to use noncirculating, biodegradable s.c. implants as drug carriers that are stable throughout the duration of drug release. Here, we use β-eliminative linkers to both tether drugs to and cross-link PEG hydrogels, and demonstrate tunable drug release and hydrogel erosion rates over a very wide range. By using one β-eliminative linker to tether a drug to the hydrogel, and another β-eliminative linker with a longer half-life to control polymer degradation, the system can be coordinated to release the drug before the gel undergoes complete erosion. The practical utility is illustrated by a PEG hydrogel-exenatide conjugate that should allow once-a-month administration, and results indicate that the technology may serve as a generic platform for tunable ultralong half-life extension of potent therapeutics.

Conjugation to macromolecular carriers is a proven strategy for improving the pharmacokinetics of drugs, with many stable polyethylene glycol conjugates having reached the market. Stable conjugates suffer several limitations: loss of drug potency due to conjugation, confining the drug to the extracellular space, and the requirement for a circulating conjugate. Current research is directed toward overcoming such limitations through releasable conjugates in which the drug is covalently linked to the carrier through a cleavable linker. Satisfactory linkers that provide predictable cleavage rates tunable over a wide time range that are useful for both circulating and noncirculating conjugates are not yet available. We describe such conjugation linkers on the basis of a nonenzymatic β-elimination reaction with preprogrammed, highly tunable cleavage rates. A set of modular linkers is described that bears a succinimidyl carbonate group for attachment to an amine-containing drug or prodrug, an azido group for conjugation to the carrier, and a tunable modulator that controls the rate of β-eliminative cleavage. The linkers provide predictable, tunable release rates of ligands from macromolecular conjugates both in vitro and in vivo, with half-lives spanning from a range of hours to >1 y at physiological pH. A circulating PEG conjugate achieved a 56-fold half-life extension of the 39-aa peptide exenatide in rats, and a noncirculating s.c. hydrogel conjugate achieved a 150-fold extension. Using slow-cleaving linkers, the latter may provide a generic format for once-a-month dosage forms of potent drugs. The releasable linkers provide additional benefits that include lowering C(max) and pharmacokinetic coordination of drug combinations.

Inhibition of the protein chaperone Hsp90 is a promising new approach to cancer therapy. We describe the preparation of potent non-benzoquinone ansamycins. One of these analogues, generated by feeding 3-amino-5-chlorobenzoic acid to a genetically engineered strain of Streptomyces hygroscopicus, shows high accumulation and long residence time in tumor tissue, is well-tolerated upon intravenous dosing, and is highly efficacious in the COLO205 mouse tumor xenograft model.

Chemobiosynthesis has been used to prepare analogs of erythromycins having unique functional groups at the 15-position. Using diketide thioester feeding to genetically engineered Streptomyces coelicolor, analogs of 6-deoxyerythronolide B were prepared having 15-fluoro, 15-chloro, and 15-azido groups. Bioconversion using a genetically engineered mutant of Saccharopolyspora erythraea was used to produce 15-fluoroerythromycin A and 15-azidoerythromycin A. These new erythromycin analogs provide antibacterial macrolides with unique physicochemical properties and functional groups that allow for selective derivatization.

Three new ascomycins produced by genetic engineering of Streptomyces hygroscopicus ATCC 14891 have been purified and characterized. Replacement of the 13-methoxyl group of ascomycin was accomplished by substitution of the corresponding acyltransferase domain of the polyketide synthase with a domain specific for either malonyl-CoA or methylmalonyl-CoA. The strain containing the methylmalonyl-specific acyltransferase domain produced a compound with properties consistent with those expected for 13-demethoxy-13-methylascomycin. NMR analysis revealed this material to be predominantly the cis amide rotamer, similar to ascomycin. The strain containing the malonyl-specific acyltransferase domain produced a mixture of two compounds, 13-demethoxyascomycin and the 9,14-hemiacetal isomer of 13-demethoxyascomycin, in nearly equal amounts. NMR analysis revealed both compounds to be predominantly the trans amide rotamers.

Chemobiosynthesis (J. R. Jacobsen, C. R. Hutchinson, D. E. Cane, and C. Khosla, Science 277:367-369, 1997) is an important route for the production of polyketide analogues and has been used extensively for the production of analogues of 6-deoxyerythronolide B (6-dEB). Here we describe a new route for chemobiosynthesis using a version of 6-deoxyerythronolide B synthase (DEBS) that lacks the loading module. When the engineered DEBS was expressed in both Escherichia coli and Streptomyces coelicolor and fed a variety of acyl-thioesters, several novel 15-R-6-dEB analogues were produced. The simpler "monoketide" acyl-thioester substrates required for this route of 15-R-6-dEB chemobiosynthesis allow greater flexibility and provide a cost-effective alternative to diketide-thioester feeding to DEBS KS1(o) for the production of 15-R-6-dEB analogues. Moreover, the facile synthesis of the monoketide acyl-thioesters allowed investigation of alternative thioester carriers. Several alternatives to N-acetyl cysteamine were found to work efficiently, and one of these, methyl thioglycolate, was verified as a productive thioester carrier for mono- and diketide feeding in both E. coli and S. coelicolor.

An array of 15-amido substituted erythromycin A compounds was synthesized using a chemobiosynthesis approach. It was found that while the in vitro antibacterial activities of aryl amides were inferior to erythromycin A, substituted benzylamides showed equivalent and in some cases improved activity against the macrolide-resistant strains. The 15-amidoerythromycins represent a new class of antibacterial macrolides.

The API-MS spectra of 6-deoxyerythronolide B (6-dEB) and a number of its analogs have been studied to gain information into the fragmentation patterns of 6-deoxyerythronolides under atmospheric pressure ionization conditions. The API-MS spectrum of 6-dEB shows five major families of fragments. The spectra of a series of desmethyl-6-dEBs allow assignment of these fragment families to structural subunits as well as provide information regarding the fragmentation mechanisms. The spectrum of [9-(18)O]-6-dEB is consistent with loss of the ketone oxygen during the first dehydration, and the spectra of other oxygen-modified analogs implicate the non-obligate formation of a 5,9-hemiacetal in the initial stages of fragmentation. These results taken together are used to propose a model for the fragmentation of 6-dEB and its analogs under API conditions.

The fragmentation of delta-lactones, particularly triketide lactones, has been studied to provide information on the behavior of polyketides under atmospheric pressure ionization mass spectrometry (API-MS). The principal fragmentation patterns of triketide lactones are characterized by two sequential dehydrations followed by loss of CO to give hydrocarbon fragments. A particular goal of this study was an understanding of the origins of the two water molecules from the dehydrations. 18O- and 2H-isotope labeling experiments with delta-valerolactone suggest a mechanism for lactone fragmentation in which ionization by proton transfer is followed by rapid equilibration of ring-opened and ring-closed forms, which results in exchange of the ionizing proton into the hydrocarbon framework of the compound and randomization of the oxygens of the lactone. Subsequent fragmentation primarily involves sequential loss of water and CO. Similar experiments with the more complex triketide lactones show that their mass spectra share common features with that of delta-valerolactone, together with an additional water loss from the 3-hydroxyl group.

Cassette replacement of acyltransferase (AT) domains in 6-deoxyerythronolide B synthase (DEBS) with heterologous AT domains with different substrate specificities usually yields the predicted polyketide analogues. As reported here, however, several AT replacements in module 4 of DEBS failed to produce detectable polyketide under standard conditions, suggesting that module 4 is sensitive to perturbation of the protein structure when the AT is replaced. Alignments between different modular polyketide synthase AT domains and the Escherichia coli fatty acid synthase transacylase crystal structure were used to select motifs within the AT domain of module 4 to re-engineer its substrate selectivity and minimize potential alterations to protein folding. Three distinct primary regions of AT4 believed to confer specificity for methylmalonyl-CoA were mutated into the sequence seen in malonyl-CoA-specific domains. Each individual mutation as well as the three in combination resulted in functional DEBSs that produced mixtures of the natural polyketide, 6-deoxyerythronolide B, and the desired novel analogue, 6-desmethyl-6-deoxyerythronolide B. Production of the latter compound indicates that the identified sequence motifs do contribute to AT specificity and that DEBS can process a polyketide chain incorporating a malonate unit at module 4. This is the first example in which the extender unit specificity of a PKS module has been altered by site-specific mutation and provides a useful alternate method for engineering AT specificity in the combinatorial biosynthesis of polyketides.

A ketolide was prepared from 14,15-dehydroerythromycin A by two different routes. The first approach involving oxidation of the 3-OH of 3-descladinosyl-14,15-dehydroerythromycin A 2'-O-acetate gave unexpectedly high levels of 3,11-double oxidation. This may be due to greater formation of the 9,12-hemiketal in 14,15-dehydroerythromycin A and concomitant exposure of the 11-OH group for oxidation. NMR studies of 14,15-dehydroerythromycin A support this hypothesis, revealing a 9:1 ratio of 9-ketone to 9,12-hemiketal in CDCl3 and a 1:1 ratio in CD3OD as contrasted with the corresponding tautomer ratios of 30:1 in CDCl3, and 6: 1 in CD3OD with erythromycin A. Alteration of the 13-substituent on the erythronolide A ring from ethyl to vinyl thus favors formation of the 9,12-hemiketal. A second route to the ketolides was developed based on these findings, in which the 11-OH is eliminated prior to oxidation of the 3-OH.

The Escherichia coli lipA gene product has been genetically linked to carbon-sulfur bond formation in lipoic acid biosynthesis [Vanden Boom, T. J., Reed, K. E., and Cronan, J. E., Jr. (1991) J. Bacteriol. 173, 6411-6420], although in vitro lipoate biosynthesis with LipA has never been observed. In this study, the lipA gene and a hexahistidine tagged lipA construct (LipA-His) were overexpressed in E. coli as soluble proteins. The proteins were purified as a mixture of monomeric and dimeric species that contain approximately four iron atoms per LipA polypeptide and a similar amount of acid-labile sulfide. Electron paramagnetic resonance and electronic absorbance spectroscopy indicate that the proteins contain a mixture of [3Fe-4S] and [4Fe-4S] cluster states. Reduction with sodium dithionite results in small quantities of an S = 1/2 [4Fe-4S](1+) cluster with the majority of the protein containing a species consistent with an S = 0 [4Fe-4S](2+) cluster. LipA was assayed for lipoate or lipoyl-ACP formation using E. coli lipoate-protein ligase A (LplA) or lipoyl-[acyl-carrier-protein]-protein-N-lipoyltransferase (LipB), respectively, to lipoylate apo-pyruvate dehydrogenase complex (apo-PDC) [Jordan, S. W., and Cronan, J. E. (1997) Methods Enzymol. 279, 176-183]. When sodium dithionite-reduced LipA was incubated with octanoyl-ACP, LipB, apo-PDC, and S-adenosyl methionine (AdoMet), lipoylated PDC was formed. As shown by this assay, octanoic acid is not a substrate for LipA. Confirmation that LipA catalyzes formation of lipoyl groups from octanoyl-ACP was obtained by MALDI mass spectrometry of a recombinant PDC lipoyl-binding domain that had been lipoylated in a LipA reaction. These results provide information about the mechanism of LipA catalysis and place LipA within the family of iron-sulfur proteins that utilize AdoMet for radical-based chemistry.

Modular polyketide synthases (PKS) are large multifunctional proteins which direct the condensation of activated short chain carboxylic acids into products of defined length and functionality using a dedicated set of active sites, or module, for each step in the polymerization. The structure of the product is directly related to the number, content and sequence of modules in a PKS. Technology is described which allows the rational manipulation of the biosynthesis of these compounds and enables the generation of specific novel polyketide structures. Examples of polyketide drugs whose structures may be manipulated using this technology are given.

The properties of a new class of phospholipids, alkyl phosphocholine triesters, are described. These compounds were prepared from phosphatidylcholines through substitution of the phosphate oxygen by reaction with alkyl trifluoromethylsulfonates. Their unusual behavior is ascribed to their net positive charge and absence of intermolecular hydrogen bonding. The O-ethyl, unsaturated derivatives hydrated to generate large, unilamellar liposomes. The phase transition temperature of the saturated derivatives is very similar to that of the precursor phosphatidylcholine and quite insensitive to ionic strength. The dissociation of single molecules from bilayers is unusually facile, as revealed by the surface activity of aqueous liposome dispersions. Vesicles of cationic phospholipids fused with vesicles of anionic lipids. Liquid crystalline cationic phospholipids such as 1, 2-dioleoyl-sn-glycero-3-ethylphosphocholine triflate formed normal lipid bilayers in aqueous phases that interacted with short, linear DNA and supercoiled plasmid DNA to form a sandwich-structured complex in which bilayers were separated by strands of DNA. DNA in a 1:1 (mol) complex with cationic lipid was shielded from the aqueous phase, but was released by neutralizing the cationic charge with anionic lipid. DNA-lipid complexes transfected DNA into cells very effectively. Transfection efficiency depended upon the form of the lipid dispersion used to generate DNA-lipid complexes; in the case of the O-ethyl derivative described here, large vesicle preparations in the liquid crystalline phase were most effective.

The post-polyketide synthase (PKS) biosynthetic tailoring of macrolide antibiotics usually involves one or more oxidation reactions catalyzed by cytochrome P450 monooxygenases. As the specificities of members from this class of enzymes vary significantly among PKS gene clusters, the identification and study of new macrolide P450s are important to the growing field of combinatorial biosynthesis. We have isolated the cytochrome P450 gene picK from Streptomyces venezuelae which is responsible for the C-12 hydroxylation of narbomycin to picromycin. The gene was located by searching regions proximal to modular PKS genes with a probe for macrolide P450 monooxygenases. The overproduction of PicK with a C-terminal six-His affinity tag (PicK/6-His) in Escherichia coli aided the purification of the enzyme for kinetic analysis. PicK/6-His was shown to catalyze the in vitro C-12 hydroxylation of narbomycin with a kcat of 1.4 s-1, which is similar to the value reported for the related C-12 hydroxylation of erythromycin D by the EryK hydroxylase. The unique specificity of this enzyme should be useful for the modification of novel macrolide substrates similar to narbomycin, in particular, ketolides, a promising class of semisynthetic macrolides with activity against erythromycin-resistant pathogens.

The stereochemistry of the diastereomers of a DNA duplex with the 2,2,2-trichloro-1,1,-dimethylethyl (TCDME) phosphotriester backbone substitution has been assigned by the use of 2D NMR spectroscopy. The duplex [G1G2A3A4G5p(TCDME)C6T7A8G9G10]-[C11C12T13A14G15C16 T17T18C19C20] is a substrate of the restriction endonuclease Alu I, with placement of the TCDME group at the G5-C6 cleavage site of one strand. The stereochemical orientation of the TCDME group in relation to the structure of the double helix regulates the ability of Alu I to hydrolyze the complementary recognition site. The phosphotriester group of the isomer 1 duplex blocks cleavage of the complementary strand, while that of the isomer 2 duplex allows cleavage to proceed. Within the phosphotriester recognition site, no hydrolysis is detected nor is any seen when the single-stranded DNA substrate is utilized. Data from the 2D NOESY spectra demonstrate that both DNA duplexes retain basic B-form geometry. The isomer 1 duplex shows NOE cross-relaxation from the protons of the two methyl groups of the TCDME modification (1.99, 2.00 ppm) to the G5 H3'(5.30 ppm), G5 H4' (4.53 ppm), and C6 H5'/H5" (4.52, 4.62 ppm) protons. The isomer 2 duplex shows NOE cross-relaxation from the methyl protons of the TCDME modification (2.01, 2.03 ppm) to the C6 H6 (7.15 ppm), C6 H4' (4.30 ppm), C6 H5'/H5" (4.48, 4.62 ppm), G5 H3' (5.26 ppm), and G5 H4' (4.48 ppm) protons. Thus the NOE cross-relaxation between the methyl protons of the TCDME modification and the C6 H6 and C6 H4' protons in isomer 2 is not found in the spectra of the isomer 1 duplex. These NMR data confirm the stereochemical assignment of the chirality of the TCDME phosphotriester group in isomer 1 as the Sp configuration and in isomer 2 as the Rp configuration. The Sp isomer features the TCDME group pointing away from the helix, while the Rp isomer shows the TCDME group pointing towards the major groove. Thus through the use of 2D NMR techniques, the stereochemistry of chiral phosphotriester linkages may be assigned in chemically modified DNA.

The DNA hairpins d[CGATCG-Tn-CGATCG] (n = 3, 4) have been studied by NMR in order to gain information on hairpin conformation and flexibility. Resonance assignments were made using a combination of DQF-COSY, DQF-COSY[31P], NOESY, and 1H-31P-COSY. These data also provide approximate coupling constant information which points out exceptionally flexible regions of the phosphate backbone. The data for both hairpins reveal substantial flexibility within the loop segments. For n = 4, NOESY data alone are insufficient to distinguish between two loop-folding motifs, although coupling constant data favor a conformation in which Tb is folded toward the minor groove and is highly exposed to solvent. This is in agreement with chemical shift data and susceptibility to modification by KMnO4. The phosphate backbone between Tc and Td is exceptionally flexible, undergoing a facile exchange between (beta t,gamma+) and (beta+,gamma t) conformers. A similar flexible phosphate is observed between Tc and C7 when n = 3. Differences in stem conformation and dynamics in both hairpins are restricted to the two base pairs adjacent to the stem-loop junction. The C7pG8 stem phosphate appears to flip easily between (zeta-,alpha-) and (zeta-,alpha t) conformers when n = 4 but not when n = 3. Hairpin loop size thus affects the conformational flexibility of the adjacent stem segment.

The Cys-His-Asp catalytic triad found in dienelactone hydrolase (DLH) is unusual for several reasons. It has not been observed in other hydrolytic enzymes and it is virtually inactive when it is produced by site-directed mutagenesis in the proteases. We propose a model to explain why this triad is catalytically active in DLH but not in the proteases. In the resting state of DLH, His202 forms an ion pair with Asp171 and Cys123 exists as a thiol. The resting state thiol does not interact with His202 in the active site but instead forms a hydrogen bond with Glu36 in the interior of the molecule. In the absence of substrate, Glu36 is also ion paired with Arg206. When substrate binds, Arg206 forms a second ion pair with the anionic substrate and the Arg206/Glu36 ion pair weakens. The destabilized Glu36 carboxylate shifts towards and deprotonates the Cys123 thiol, thereby activating the nucleophile. As the thiolate anion is not energetically favoured in the hydrophobic interior of the enzyme, it swings into the active site where it can be stabilized by the His202 imidazolium and the dipole of helix C. The Cys123 thiolate which now lies adjacent to the acyl carbon of the substrate, is thus generated only in the presence of substrate. The mode of thiolate activation reduces the susceptibility of DLH towards thiol alkylating agents.

Dienelactone hydrolase (DLH), an enzyme from the beta-ketoadipate pathway, catalyzes the hydrolysis of dienelactone to maleylacetate. Our inhibitor binding studies suggest that its substrate, dienelactone, is held in the active site by hydrophobic interactions around the lactone ring and by the ion pairs between its carboxylate and Arg-81 and Arg-206. Like the cysteine/serine proteases, DLH has a catalytic triad (Cys-123, His-202, Asp-171) and its mechanism probably involves the formation of covalently bound acyl intermediate via a tetrahedral intermediate. Unlike the proteases, DLH seems to protonate the incipient leaving group only after the collapse of the first tetrahedral intermediate, rendering DLH incapable of hydrolyzing amide analogues of its ester substrate. In addition, the triad His probably does not protonate the leaving group (enolate) or deprotonate the water for deacylation; rather, the enolate anion abstracts a proton from water and, in doing so, supplies the hydroxyl for deacylation.