Search

Filter bags facilitate the measurement of amylase-treated neutral detergent fiber (aNDF) and in vitro (IV) undigested aNDF (uNDF) by eliminating the transfer of residues from beakers into filtration crucibles. The objectives of this study were to (1) determine effects of filter bags on recovery of aNDF and (2) evaluate effects of filter bags on IV uNDF. For study 1, 6 samples each of grass hay (GR), alfalfa (AL), and corn silage (CS) were selected. Large standard deviations (SD) of ash-free aNDF (aNDFom) for samples in each forage type indicated compositional diversity (15.1, 7.45, and 12.9% of DM for GR, AL, and CS, respectively), and starch SD for CS was 16.4% of DM. Samples were weighed into Berzelius beakers or filter bags [25-µm pores (F57) or 6-µm pores (F58); Ankom Technology, Macedon, NY] for measurement of aNDF and aNDFom. All samples were extracted with neutral detergent, thermostable α-amylase, and sodium sulfite, and then soaked in boiling water and then acetone. Residues from beakers were filtered through a sea sand-covered GF/D filter (Whatman, Marlborough, MA) in Gooch crucibles (CR). Filter bags were extracted in a pressurized chamber at 100°C. The aNDF values did not differ between F57 and CR, but F58 was greater than CR for CS and AL. For GR, F58 was greater than CR for aNDFom. For study 2, diverse samples with large SD of aNDFom (20.7, 7.45, and 12.9% of DM for GR, AL, and CS, respectively) were weighed as loose powder into medium bottles (LS) or F57 bags, which were weighted to prevent floating. Blended ruminal fluid from 3 steers fed a 30% aNDFom diet was used as inoculum. Three samples of 1 forage type were randomly assigned to 1 of 6 IV runs using both treatments (LS and F57), and 3 bottles of each sample-treatment combination were removed after 12 h and 2 were removed after 120 h to measure uNDF. For LS, residues were extracted as in study 1 for CR. For F57, bags were rinsed in cold water and extracted as described in study 1. After 12 h, uNDF of F57 was greater than LS in CS, AL, and overall types. Ash-free uNDF (uNDFom) after 12 h of F57 was greater than LS in CS and overall types. After 120 h, F57 was greater than LS for uNDF of CS, but no differences were detected for uNDFom. The SD of uNDFom, but not uNDF, was higher after 12 and 120 h for F57 compared with LS. From 6 to 96 h, overall gas production of F57 was less than LS, and F57 was less than LS for CS from 3 to 96 h. Overall, LS gave greater maximum and faster rates of gas production than F57, as did AL and CS, but lag did not vary. Results indicate that filter bags affected aNDF and aNDFom measurement and inhibited fermentation for some materials.

The effects of four contrasting diets were determined on populations of three species of ruminal cellulolytic bacteria (Ruminococcus albus, Ruminococcus flavefaciens, and Fibrobacter succinogenes) using oligonucleotide probes to rRNA. Diets based on alfalfa silage or corn silage as the primary fiber source were formulated to contain either 24 or 32% neutral detergent fiber measured after alpha-amylase treatment. The diets were fed twice daily to four ruminally fistulated, lactating Holstein cows in a trial using a Latin square design. The cows fed the alfalfa silage diets had higher dry matter intakes and milk production and smaller pH fluctuations than did cows fed the corn silage diets (0.3 vs. 0.8 units). The total populations of the three cellulolytic species at 3 h after feeding ranged from 0.3 to 3.9% of the bacterial domain; R. albus was generally the most abundant of the three species. The data are in general agreement with population assessments obtained by some traditional methods of culture enumeration. Although diet and individual cows had major effects on ruminal pH and volatile fatty acid concentrations and on milk production and composition, differences in cellulolytic populations that were attributable to individual cows were larger than those attributable to diet, suggesting that each cow maintained a unique assemblage of cellulolytic species.

The objective of this study was to investigate whether prediction of fermentation potential (FP) of dry and high-moisture (HM) corns could be improved by using a concept of effective (e) mean particle size (MPS). A set of FP standards was created by processing a single lot of Reid Yellow Dent (RYD) corn to achieve MPS of 3,778, 2,786, 2,282, 1,808, 1,410, 806, 586, 378, 308, 226, and 105 μm. In vitro gas production of RYD standards was measured, and peak absolute rate (PAR) of gas production (mL/0.2 g of DM/h) was used to establish a standard relationship between PAR and MPS. To identify factors other than MPS affecting FP, the MPS and nutrient composition of 36 diverse samples of dry (n=18) and HM (n=18) corns were determined. Composition included dry matter (DM), crude protein, soluble crude protein, neutral detergent fiber, starch, NH₃-N, prolamin protein, and fat. In vitro gas production of undried, unground dry and HM corns was measured, and PAR, time of peak absolute rate (h), maximum cumulative gas production (mL/0.2 g of DM), gas production fractional rate (h⁻¹), and lag (h) were determined. Nonlinear relationships between MPS, defined as the dependent variable, and PAR, as an independent variable, were used to identify FP deviations unexplained by MPS. When no variation in nutritional composition was present (RYD standards), the relationship between PAR and MPS was described by an exponential decay model [RYD_MPS=9,006 × e((-0.452 × PAR)); R²=0.96]. For diverse dry and HM corn populations, the variation in MPS explained by PAR was diminished (R²=0.50). To investigate factors that diminish the relationship between MPS and PAR in diverse corns, relative residual (rr) MPS was determined [rrMPS = (MPS - RYD_MPS)/MPS], where RYD_MPS was predicted from the PAR of diverse dry and HM corn. The rrMPS was most highly related to prolamin protein [rrMPS(dry)=0.58-0.15 × (prolamin protein, % of DM); R²=0.43] and NH₃-N [rrMPS(HM)=0.21+0.08 × (NH₃-N, % of total N); R²=0.46] for dry and HM corns, respectively. An eMPS was calculated as eMPS = MPS - MPS × rrMPS, where rrMPS was predicted from prolamin protein or NH₃-N concentration in dry and HM corn, respectively. The natural logarithm of eMPS accounted for 84% of the variability in PAR and 53% of the variability in the fractional rate of gas production. Calculating eMPS by adjusting the MPS of dry corn for prolamin and HM corn for NH₃-N concentration improved the assessment of industry corn FP.

Pycnometers were used in this series of experiments to measure the specific gravity of the solid fraction in forage particles and to assess the effect of solubilization of DM on functional specific gravity and the specific gravity of the solid fraction. The removal of cell contents by either neutral detergent extraction or DM solubilization decreased functional specific gravity and the specific gravity of the solid fraction of particles. Solutes increased the specific gravity of gas-free distilled water in proportion to the amount of soluble DM dissolved. The average specific gravity of the solids in particles extracted by neutral detergent and the insoluble DM in alfalfa particles averaged 1.48 and 1.50, respectively. The effect of forage species and method of forage preservation on specific gravity of the solids in forage particles was minimal. However, during partial solubilization of DM, the loss of mass averaged 1.9 times the loss of volume, indicating that minerals were the primary solute responsible for the change in specific gravity of particles. The biological meaning of functional specific gravity is unclear because it excludes the liquid associated with particles. However, functional specific gravity of stem particles passing a 425-µm sieve was identical to specific gravity of the solids, indicating the absence of gas in these particles.

Macerated (shredded) forage has been shown to have two important properties: drying rates several times those of conventional forage and dry matter digestibilities 10–15% higher than conventional forage. A field-drying process was developed which consists of mowing, macerating, pressing the forage into thin cohesive mats, and placing these on the stubble. A small prototype machine was constructed to carry out these processes concurrently. Equipment was also developed to harvest the forage mats either for dry hay or for silage. Ensiled macerated lucerne fermented twice as fast as conventional lucerne. Feeding trials with sheep, goats, and dairy cattle verified the higher digestibility of macerated as compared with unmacerated lucerne. Heat treatment of hay increased the “escape” or “bypass” protein of lucerne, which is expected to improve efficiency of protein utilization by ruminants. The increase in escape protein due to heat treatment was approximately 50% greater for macerated lucerne than for conventional lucerne.

The effect of 3 fermentation methods, in situ (IS) in 4 lactating cows (average pH of 5.8), in vitro (IVn) with media pH of 6.8, or in vitro (IVa) with media pH adjusted to 6.0 using citric acid, on fiber degradation parameters was studied using feeds ground to different particle sizes. Corn silage (CS), grass silage (GS), barley grain (B), sugar beet pulp (BP), and rapeseed cake (RC) were ground using a shear mill. Silages were ground through 8-, 4-, 2-, or 1-mm screens, B and BP through 4-, 2-, or 1-mm screens, and RC through 2- or 1-mm screens. The amylase-treated NDF (aNDF) content of samples ground using a 1-mm screen was 399, 431, 197, 480, and 251 g/kg of DM for CS, GS, B, BP, and RC, respectively, but increased with increasing screen size. Materials were incubated for 0, 6, 12, 24, 48, and 96 h IS, IVn, or IVa. Inoculum for IVn and IVa was prepared as a composite from the cows used for IS. The potentially degradable aNDF (D(0)), indegradable aNDF (I), lag time (L), and fractional rate of degradation of potential degradable aNDF (k(d)) were estimated using PROC NLIN in SAS. Except for RC, fermentation methods affected most degradation parameters, especially k(d) and L. The IVn, IVa, and IS methods resulted in k(d) values of 0.291, 0.105, 0.080 h(-1) and 0.262, 0.107, 0.103 h(-1) for BP and RC, respectively, demonstrating a decreasing rate of degradation for these feeds when fermented under suboptimal pH. In CS, GS, and B, no difference was found in k(d) between the IVn and IVa methods, which suggests that differences in pH did not alter k(d) in vitro. The k(d) values obtained for CS, GS, and B were 0.058, 0.109, 0.168, and 0.028, 0.054, and 0.069 h(-1) for the IVn and IS methods, respectively, indicating that the IS method using cows fed at production levels can underestimate the potential rate of NDF degradation. Using the IVa method, L was 12.1, 9.1, 7.8, and 2.5 h for CS, GS, BP, and RC, respectively, which was higher than L obtained from the IVn and IS methods for all feeds except B, where L in all methods were near the parameter boundary of zero hour in NLIN. It was concluded that fermentation methods were more important than grinding screen size on estimates for feed aNDF degradation and that the individual aNDF degradation parameters for the 5 feeds were affected differently by fermentation methods.

Kinetics of hydration of ground hay and silage particles (2-mm screen), determined by a pycnometric technique, was best described by a two- and one-pool exponential model, respectively. Fractional rates of hydration of the large pool, detected in hay particles only, and of the small pool present in both hay and silage particles averaged .135 and .021 min-1, respectively. When hydration was complete, liquid associated with particles averaged 1.16, 1.90, and .83 g/g of insoluble DM for bromegrass hay, alfalfa hay, and alfalfa silage, respectively. Functional specific gravity, which accounts for the effect of associated gas volume, averaged 1.54, 1.46, and 1.54, but unit specific gravity, calculated to include the effect of gases and liquid of hydration, averaged 1.22, 1.14, and 1.26 for bromegrass hay, alfalfa hay, and alfalfa silage, respectively. Preservation of forage as silage not only lowered gas volume, but also reduced water-holding capacity, both of which contribute to greater unit specific gravity and faster rate of escape from the rumen. In addition, estimates of unit specific gravity of approximately 1.2 indicate that even in the absence of associated gas, hydrated forage particles would tend to escape the rumen at a slower rate than that achieved by more dense particles.

This experiment investigated the relationship between kinetics of digestion and change in specific gravity during in situ incubation. Nine cows were fed three sources of fiber (corn silage, alfalfa silage, or alfalfa hay) in diets formulated to contain 25, 30, or 35% NDF in three simultaneous 3 x 3 Latin squares. Method of alfalfa preservation did not influence rate of digestion or rate of increase in specific gravity of forage particles measured by a flotation technique. Prior to incubation, specific gravity of forage particles was in increasing order: alfalfa hay, alfalfa silage, and then corn silage. Essentially, all particles with a specific gravity less than 1.0 shifted to a higher specific gravity fraction by hydration within the first 4 h of incubation. From 4 to 56 h of incubation, percentage of residual DM that settled in solution having specific gravity of 1.3 increased linearly from 21 to 27% for corn silage but exponentially from 3 to 20% for alfalfa forages. Fractional rates of DM and NDF digestion and increase in percentage of residual DM having a specific gravity greater than 1.3 increased with the amount of fiber in the alfalfa diets and were correlated positively, suggesting that rate of increase in specific gravity, which affects rate of passage from the rumen, is influenced by rate of digestion of forage particles.

Three nitrogen-balance trials were used to measure nitrogen utilization in lactating dairy cows. In each trial, the basic diet was a complete feed containing 55% corn silage and 45% grain mixture (dry-matter basis). The crude protein contents of the complete diets in trials 1, 2, and 3 were 12, 13, and 15%, respectively. Four high-producing Holstein cows similar in age and producing ability and within 30 to 45 days postpartum were used in each 12-wk trial in a Latin-square experimental design. Urea was the treatment variable supplying approximately 0, 8, 16, or 24% of the total dietary nitrogen. The measured solubility of the nitrogen in the diets ranged from 31.5 to 48.7%. The data were fitted to a multiple linear-regression model to determine coefficients of nitrogen utilization. The utilization coefficients for soluble nitrogen and insoluble nitrogen were relatively constant across the three trials, but in each trial the utilization coefficient for insoluble nitrogen was greater than for soluble nitrogen.

Fifteen lactating Holstein cows in a 3×3 Latin square experiment determined effects of ground newspaper in the diet. Test components of the rations were: A) 20% cottonseed hulls; B) 10% paper and 10% cottonseed hulls; C) 20% paper. All animals received 2.3kg of long alfalfa hay daily. Proximate analysis and gross energy determinations indicated that the paper rations contained more crude fiber, ether extract, and gross energy and less crude protein and ash. Ink in the paper apparently caused higher gross energy values and probably increased ether extract. Estimates of dry matter digestibility by an in vitro technique were not significantly different being 77.4, 77.4, and 77.5 for the control, 10% paper, and 20% paper rations. Average daily ration intakes were significantly different among rations with intakes of 21.5, 17.0, and 12.5kg per day for the control, 10% paper, and 20% paper. Paper at 20% of the ration significantly lowered actual milk yields but did not significantly lower fat-corrected milk yield during the six weeks. Average daily fat-corrected milk yields for control, 10% paper, and 20% paper treatments were 15.9, 16.9, and 16.3kg. Milk fat percentages were 2.6, 3.1, and 3.4 with significant differences between treatments. Milk protein and solids-not-fat were not significantly different; however, there was an inverse linear response between treatment and milk protein percentage. There were small differences in ruminal volatile fatty acids with a significantly lower pH for the 20% paper compared with the control. Paper at 10% in the ration would maintain milk fat percentage without reducing actual milk production during six weeks.

Metabolizable protein and selected metabolizable amino acid requirements for lactating cows were described, and tentative values were established for differnt yields of milk.A new expression"urea fermentation potential of feeds," describes urea use in lactation rations for partial satisfaction of protein and amino acid requirements. Tentative urea fermentation values were established for the more common cattle feedstuffs. Four lactation rations were formulated with different fermentation values to illustrate the variable feeding value of urea in satisfying amino acid requirements at different yields of lactation. Urea had the highest feeding value in lower-protein rations when fed to cows with medium to low yields of milk.Conversely, urea, by the metabolizable protein system, had little or no feeding value in lactation rations having more than about12% protein on a dry matter basis or in rations supporting lactations in excess of 25 to 30 kg of milk per cow per day.

In vitro dry matter disappearances were determined for 11 paper sources and three complete rations containing 0, 10, and 20% newsprint. Inoculum was from an alfalfa hay-fed steer. Alfalfa hay, brome hay, and Solka Floc were reference substrates. Brown wrapping paper and brown cardboard had the highest dry matter disappearances of 90.8 and 77.8%; whereas four glossy or slick magazine papers had significantly lower values of 46.1, 45.1, 41.3, and 41.0%. Newsprint with black ink, without ink, and with colored inks had dry matter disappearances of 33.2, 32.6, and 26.5%, which were significantly lower than those of the glossy magazine papers. Lowest dry matter disappearances of 24.0 and 20.1% were from two magazine papers. The complete rations had 77.9, 80.1, and 81.8% dry matter disappearances for the 0, 10 and 20% paper rations. These data indicate substantial differences in digestibilities of various paper sources.

Sensory testing revealed that 10 and 20% newsprint in the rations of cows had no significant effect on flavor of milk. However, significant inherent differences were observed in the flavor of milk from groups of matched cows.