Search

The economic importance that myticulture is conquering in Santa Catarina State (South of Brazil) explains the crescent search for new coastal sites for farming. Physiological and biochemical studies of the mussel Perna perna are important to the establishment of methodologies for program assessment and environmental monitoring, allowing to infer about site quality and possible influences of xenobiotic agents on coastal areas. In order to evaluate effects caused by lead poisoning (1.21 mumol.L-1), the mussels were maintained at constant temperature (25ºC) and fed with Chaetoceros gracilis for 15 days. The control group was acclimatized in sea water 30?. At the end of this period time, physiological measurements were carried out along with statistic analysis for filtration rates, lead assimilation and overall respiratory activity. The mechanism of multixenobiotic resistance (MXR) was particularly evaluated in standardized gill fragments using rhodamine B accumulation and its quantification under fluorescence optical microscopy. Regarding the control group, results had shown that the mussels maintenance in a lead-poisoned environment caused higher filtration rates (1.04 and 2.3 and L.h-1.g-1; p < 0.05) and lower assimilation rates (71.96% and 54.1%, respectively). Also it was confirmed a lesser rhodamine B accumulation in the assays under influence of lead, suggesting that this metal induces the MXR mechanism expression in mussel P. perna. These results indicate that such physiological and biochemical alterations in the mussels can modify the energy fluxes of its metabolism, resulting in possible problems on the coastal systems used as cultivating sites.

Cell cultures of Mandevilla velutina have proved to be an interesting production system for biomass and secondary metabolites able to inhibit the hypotensive activity of bradykinin, a nonapeptide generated in plasma during tissue trauma. The crude ethyl acetate extract of cultured cells contains about 31- to 79-fold more potent anti-bradykinin compounds (e.g., velutinol A) than that obtained with equivalent extracts of tubers. Somaclonal variation may be an explanation for the wide range of inhibitor activity found in the cell cultures. The heterogeneity concerning morphology, differentiation, carbon dissimilation, and velutinol A production in M. velutina cell cultures is reported. Cell cultures showed an asynchronous growth and cells in distinct developmental stages. Meristematic cells were found as the major type, with several morphological variations. Cell aggregates consisting only of meristematic cells, differentiated cells containing specialized cell structures such as functional chloroplasts (cytodifferentiation) and cells with embryogenetic characteristics were observed. The time course for sucrose metabolism indicated cell populations with significant differences in growth and metabolic rates, with the highest biomass-producing cell line showing a cell cycle 60% shorter and a metabolic rate 33.6% higher than the control (F2 cell population). MALDI-TOF mass spectrometric analysis of velutinol A in selected cell lines demonstrated the existence of velutinol A producing and nonproducing somaclones. These results point to a high genetic heterogeneity in general and also in terms of secondary metabolite content.

Kinetic conditions were established for the depolymerization of cassava starch for the production of maltodextrins and glucose syrups. Thin-layer chromatography and high-performance liquid chromatography analyses corroborated that the proper H3PO4 strength and thermopressurization range (e.g., 142-170 degrees C; 2.8-6.8 atm) can be successfully explored for such hydrolytic purposes of native starch granules. Because phosphoric acid can be advantageously maintained in the hydrolysate and generates, after controlled neutralization with ammonia, the strategic nutrient triplet for industrial fermentations (C, P, N), this pretreatment strategy can be easily recognized as a recommended technology for hydrolysis and upgrading of starch and other plant polysaccharides. Compared to the classic catalysts, the mandatory desalting step (chloride removal by expensive anion-exchange resin or sulfate precipitation as the calcium-insoluble salt) can be avoided. Furthermore, properly diluted phosphoric acid is well known as an allowable additive in several popular soft drinks such as colas since its acidic feeling in the mouth is compatible and synergistic with both natural and artificial sweeteners. Glycosyrups from phosphorolyzed cassava starch have also been upgraded to high-value single-cell protein such as the pigmented yeast biomass of Xanthophyllomyces dendrorhous (Phaffia rhodozyma), whose astaxanthin (diketo-dihydroxy-beta-carotene) content may reach 0.5-1.0 mg/g of dry yeast cell. This can be used as an ideal complement for animal feeding as well as a natural staining for both fish farming (meat) and poultry (eggs).

The microheterogeneous native amylolytic complex secreted by the isolate A6 of Lactobacillus plantarum revealed a selective enzyme specificity loss when submitted to a limited proteolysis under a suboptimum pH condition. A clear electrophoretic profile change toward just one shorter, more acidic, and equally active polypeptide fragment resulted from the pronase E pretreatment. Although the whole enzyme activity remained apparently unaffected for soluble starch, the native parallel activity on intact and non-gelatinized starch granules either from cereals or tubers was dramatically reduced. This phenomenon was more clearly documented by scanning electron microscopy using the easiest accessible native substrate: wheat starch granules. The anion-exchange-purified native enzymes from L. plantarum displayed a different optimum pH curve when compared with the thermotolerant alpha-amylase from Bacillus licheniformis. The alpha-amylases from the lactic-acid-producing A6 isolate presented an electrophoretic profile easily distinguishable from those from B. liqueniformis and B. subtilis species.

Brazil is the largest producer of bioethanol, and sugarcane is the main raw material. Bioethanol is produced by both batch and continuous processes, and in some cases, flocculating yeast is used. This article analyzes the Brazilian Ethanol Program. For the 1996-1997 harvest, Brazil produced 14.16 billion L of ethanol and 13.8 million metric t of sugar, from 286 million metric t of sugarcane. These products were produced by 328 industries in activity, with 101 autonomous ethanol plants producing only ethanol, and 227 sugar mills producing sugar and ethanol. The sugar-ethanol market reaches about 7.5 billion US$/yr, accounting for direct and indirect revenues.

Microbial inulinases are an important class of industrial enzymes that have gained much attention recently. Inulinases can be produced by a host of microorganisms, including fungi, yeast, and bacteria. Among them, however, Aspergillus sp. (filamentous fungus) and Kluyveromyces sp. (diploid yeast) are apparently the preferred choices for commercial applications. Among various substrates (carbon source) employed for their production, inulin-containing plant materials offer advantages in comparison to pure substrates. Although submerged fermentation has been universally used as the technique of fermentation, attempts are being made to develop solid-state fermentation technology also. Inulinases catalyze the hydrolysis of inulin to D-fructose (fructose syrup), which has gained an important place in human diets today. In addition, inulinases are finding other newer applications. This article reviews more recent developments, especially those made in the past decade, on microbial inulinases--its production using various microorganisms and substrates. It also describes the characteristics of various forms of inulinases produced as well as their applications.

Since natural substances like pseudoxanthins exert a positive effect on the cellulogenic ability of Acetobacter xylinum when producing cellulosic pellicles suitable for skin burn therapy, new defined and complex modulators were sought. Ca2+ and Mg2+ (4 mM) were strongly stimulatory. Na+ had no effect and K+ was inhibitory. Ammonium dihydrogen phosphate (0.12 g/L) ensured the same nitrogen supply as the same concentration of yeast extract as measured by cellomembrane dry wt./yield albeit higher yeast extract supplies produced thicker membranes. Corn steep liquor (CSL) was also progressively beneficial from 0.125 to 0.5 mL/L, and this yield could be further improved by the combination of CSL with a tea infusion (source of caffeine). Uridine (precursor for UDP-Glc, sugar donor in cellulose biosynthesis), guanine, guanosine, and its butirylated derivatives (precursors for the positive modulator of cellulose synthetase, di-cGMP) resulted in only moderate stimulation. Sodium phytate and betaine were also slightly stimulatory. The fibrilar product from a new Acetobacter isolate (Ax-M) was characterized as cellulose by comparison with the solid-state(13)C-NMR of algal cellulose. Its X-ray diffractogram was a confirmatory analysis. After incorporation of tamarind xyloglucan to previously air-dried cellulosic pellicles, diffractometry displayed only slight differences. Mercerized (5M NaOH) fresh cellulosic biofilms underwent drastic size reduction (3.5-fold), turning compact nut still flexible if maintained wet.

Glucose dehydrogenase (GDH) from Bacillus megaterium was immobilized using aminopropyl controlled-pore silica (CPS, average pore sizes of 170 and 500 A) as a support and glutaraldehyde as a bifunctional crosslinking agent. The CPS-immobilized enzyme could be reused 12 times and the best results were obtained using aminopropyl CPS-500 and bovine serum albumin as a feeder for stabilizing the protein layer on the support. DEAE-Sephadex (A-25 and A-50) was also used as a support for immobilizing GDH, with yields of around 42% for A-25 and 25-30% for A-50. The effect of pH on the immobilization procedure showed pH 6.5 to be better than pH 7.5 with respect to the recovery of enzyme activity. Both preparations of DEAE-Sephadex immobilized GDH could be reused several times and were thermostable at 40 degrees C for 7 h. The kinetic parameters as Michaelis constant and maximum rate were determined for the immobilized enzyme and compared with those for the freeform.

Astaxanthin is a diketo-dihydroxy-carotenoid produced by Phaffia rhodozyma, a basidiomicetous yeast. A low-cost fermentation medium consisting of raw sugarcane juice and urea was developed to exploit the active sucrolytic/urelolytic enzyme apparatus inherent to the yeast. As compared to the beneficial effect of 0.1 g% urea, a ready nitrogen source, mild phosphoric pre inversion of juice sucrose to glucose and fructose, promptly fermentable carbon sources, resulted in smaller benefits. Corn steep liquor (CSL) was found to be a valuable supplement for both yeast biomass yield (9.2 g dry cells/L) and astaxanthin production (1.3 mg/g cells). Distillery effluent (vinace), despite only a slightly positive effect on yeast growth, allowed for the highest pigment productivity (1.9 mg/g cells). Trace amounts of Ni2 (1 mg/L, as a cofactor for urease) resulted in controversial effects, namely, biomass decrease and astaxanthin increase, with no effect on the release (and uptake) of ammonium ion from urea. Since the synthesized astaxanthin is associated with the yeast cell and the pigment requires facilitated release for aquaculture uses (farmed fish meat staining), an investigation of the yeast cell wall was undertaken using detergent-treated cells. The composition of the rigid yeast envelope was found to be heterogeneous. Its partial acid or enzymatic depolymerization revealed glucose and xylose as common monomeric units of the cell-wall glycopolymers. Yeast cell-wall partial depolymerization with appropriate hydrolases may improve the pigment bioavailability for captive aquatic species and poultry.

The 2M1 strain of Aspergillus sp., which showed high extracellular xylanolytic activities in a pre-screening, was studied. Oat-spelt, birch, eucalyptus and pine xylans were used as xylanolytic inductors. The following activities were found at 50 degrees C in the presence of 1% xylan: 120 units/ml (oat-spelt xylan), 132 units/ml (birch xylan), 107 units/ml (eucalyptus xylan), 67 units/ml (pine xylan) and 137 units/ml (larch-wood xylan). Xylanase induced by pine xylan exhibited a higher stability than those induced by the other xylans. The stability was improved by addition of glycerol. In the crude extract, reagents which were found to affect xylanase activity were 1-ethyl-3-(3-dimethylaminopropyl)carbodi-imide for amidation of carboxylic groups and N-bromosuccinimide at a concentration of 0.5 mM for indole oxidation. Methylene Blue, butane-2,3-dione, N-acetylimidazole, chloramine-T and iodoacetate had little effect on the enzyme activity (more than 97% of the original activity remained).

Growth of the yeast Phaffia rhodozyma was carried out in a simplified medium based on less expensive nutrient sources, such as diluted sugar cane juice, urea, and sodium phosphate. The usual content of the astaxanthin, an oxygenated pink carotenoid useful for fish flesh staining, was improved along with with good cell yields (respective values of > 1300 micrograms/g cells and > 5 g cells/L were observed). Yeast invertase and urease must therefore play an important role in the implementation of low-cost culture media.

Crop residues, such as sugar cane bagasse (SCB), have been largely used for cattle feeding. However, the close association that exists among the three major plant cell-wall components, cellulose, hemicellulose, and lignin, limits the efficiency by which ruminants can degrade these materials. Previously, we have shown that pretreatment with 3% (w/w) phosphoric acid, under relatively mild conditions, increased considerably the nutritional value for SCB. However, in this preliminary study, pretreated residues were not washed prior to in situ degradability assays because we wanted to explore the high initial solvability of lowmol-wt substances that were produced during pretreatment. We have now studied the suitability of water-and/or alkali-washed residues to in situ ruminal digestion. Alkali washing increased substrate cellulose content by removing most of the lignin and other residual soluble substances. As a result the ruminal degradability of these cleaner materials had first-order rate constants five times higher than those substrates with higher lignin content (e.g., stem-exploded bagasse). However, alkali washing also increased the time of ruminal lag phase of the cellulosic residue, probably because of hemicellulose and/or lignin removal and to the development of substrates with higher degree of crystallinity. Therefore, longer lag phases appear to be related to low microbial adherence after extensive water and alkali extraction, as Novell as to the slower process of cellulase induction during ruminal growth. The kinetic data on ruminal digestion were shown to be very well adjusted by a nonlinear model. Although pretreatment enhances substrate accessibility, the occurrence of an exceedingly high amount of lignin byproducts within the pretreated material reduces considerably its potential degradability.

Toxins, enzymes, and biologically active peptides are the main components of snake venoms from the genus Bothrops. Following the venom inoculation, the local effects are hemorrhage, edema, and myonecrosis. Nineteen different species of Brazilian Bothrops were screened for protein content and L-amino acid oxidase activity. B. cotiara, formerly found in the South of Brazil, is now threatened with extinction. Its venom contains a highly hemorrhagic fraction and, as expected from the deep yellow color of the corresponding lyophilized powder, a high L-amino acid oxidase (LAO) activity was also characterized. Flavin adenine dinucleotide (FAD) is its associate coenzyme. B. cotiara venom LAO catalyzed the oxidative deamination of several L-amino acids, and the best substrates were methionine, leucine, tryptophan, and phenylalanine, hence, its potential application for the use of biosensors for aspartame determination and for the removal of amino acids from plasma. High levels for LAO were also found in other species than B. cotiara. In addition, the technique of isoelectric focusing (IEF) was employed as a powerful tool to study the iso- or multi-enzyme distribution for LAO activity in the B. cotiara snake venom.

Bacteria collected from rotting dahlia tubers, instead of degrading inulin to D-fructose, preferentially formed the known DFA III (beta-2.1': alpha-2',3 difructofuranose anhydride), inulobiose, higher inulo-oligosaccharides, and exoheteropolysaccharides. Owing to the morphological and Gram staining variability, the bacterial isolates designated YLW and CRM were examined to differentiate them from a reference strain Arthrobacter ureafaciens. The comparative analyses were whole DNA random amplification by Taq polymerase (RAPD-PCR protocol), culture media DFA III content in culture media, chromatographic profile of oligosaccharides formed, and exopolysaccharide fractionation/fragmentation. A comparative study in liquid shake cultures showed that the isolate YLW was faster than the reference strain in the production of DFA III when the inulin/yeast extract ratio was maintained at 10 in the medium, although a similar maximum yield was displayed with both bacteria (13-14 mg of DFA/mL cell free media from the initial 30 mg/mL of inulin load). Doubling the yeast extract input, an even faster onset of DFA III production occurred with YLW but with no further improvement in the maximum yield. Both strains further degraded the resulting DFA during the stationary growth phase. The main ability of CRM when grown on inulin was the production of exopolysaccharides, although culture condition variation also allowed DFA III production, which was accompanied by somewhat lower amounts of its reducing analog, inulobiose.

Caffeine and related xanthines were identified as potent stimulators for the bacterial cellulose production in A. xylinum. These compounds are present in several plants whose infusions are useful as culture-medium supplements for this acetobacterium. The proposed target for these native purine-like inhibitory substances is the novel diguanyl nucleotide phosphodiesterase(s) that participate(s) in the bacterial cellulogenic complex. A better understanding of this feature of A. xylinum physiology may facilitate the preparation of bacterial cellulose pellicles, which are applied as a biotechnological tool in the treatment of skin burns and other dermal injuries.

An enzymic activity, obtained from Neurospora crassa, catalyzing the incorporation of [14C]glucose from ADP-[14C]glucose into a glucan of the glycogen type, is described. The properties of the ADPglucose : glycogen glucosyltransferase as compared with those of the already known UDP glucose : glycogen glucosyltransferase were studied. The radioactive products obtained with UDP-14C]glucose or ADP-[14C]glucose released all the radioactivity as maltose after alpha or beta amylase treatment. Glucose 6-phosphate stimulated the synthetase when UDP-[14C]glucose was the substrate but the stimulation was much greater with ADP-[14C]glucose as glucosyl donor. Glucose 6-phosphate plus EGTA gave maximal stimulation. The system was completely dependent &on the presence of a 'primer' of the alpha 1 leads to 4 glucan type.