Search

Monoclinic $\beta$-Ga$_2$O$_3$ films grown on $c$-plane sapphire have been shown to exhibit six $(\bar{2}01)$-plane oriented domains, which are equally-spaced-by-rotation around the surface normal and equally-sized-by-volume that render the film optical response effectively uniaxial. We derive and discuss an optical model suitable for ellipsometry data analysis of such films. We model mid- and far-infrared ellipsometry data from undoped and electrically insulating films with an effective uniaxial dielectric tensor based on projections of all phonon modes within the rotation domains parallel and perpendicular to the sample normal, i.e., to the reciprocal lattice vector $\mathbf{g}_{\bar{2}01}$. Two effective response functions are described by model, and found sufficient to calculate ellipsometry data that best-match measured ellipsometry data from a representative film. We propose to render either effective dielectric functions, or inverse effective dielectric functions, each separately for electric field directions parallel and perpendicular to $\mathbf{g}_{\bar{2}01}$, by sums of Lorentz oscillators, which permit to determine either sets of transverse optical phonon mode parameters, or sets of longitudinal optical phonon mode parameters, respectively. Transverse optical modes common to both dielectric functions can be traced back to single crystal modes with $B_{\mathrm{u}}$ character, while modes with $A_{\mathrm{u}}$ character only appear within the dielectric function for polarization perpendicular to the sample surface. The thereby obtained parameter sets reveal all phonon modes anticipated from averaging over the six-fold rotation domains of single crystal $\beta$-Ga$_2$O$_3$, but with slightly shifted transverse optical, and completely different longitudinal optical phonon modes., Comment: 14 pgaes, 8 figures

Diffusion of native defects such as vacancies and their interactions with impurities are fundamental in semiconductor crystal growth, device processing, and long-term aging of equilibration and transient diffusion of vacancies are rarely investigated. We used aluminum-gallium oxide/gallium oxide superlattices (SLs) to detect and analyze transient diffusion of cation vacancies during annealing in O2 at 1000-1100 C. Using a novel finite difference scheme for the diffusion equation with time- and space-varying diffusion constant, we extract diffusion constants for Al, Fe, and cation vacancies under the given conditions, including the vacancy concentration dependence for Al. indicate that vacancies present in the substrate transiently diffuse through the SLs, interacting with Sn as it also diffuses. In the case of SLs grown on Sn-doped beta-gallium oxide substrates, gradients observed in the extent of Al diffusion indicate that vacancies present in the substrate transiently diffuse through the SLs, interacting with Sn as it also diffuses. In the case of SLs grown on (010) Fe-doped substrates, the Al diffusion is uniform through the SLs, indicating a depth-uniform concentration of vacancies. We find no evidence in either case for the introduction of gallium vacancies from the free surface at rates sufficient to affect Al diffusion down to ppm concentrations, which has important bearing on the validity of typically-made assumptions of vacancy equilibration. Additionally, we show that unintentional impurities in Sn-doped gallium oxide such as Fe, Ni, Mn, Cu, and Li also diffuse towards the surface and accumulate. Many of these likely have fast interstitial diffusion modes capable of destabilizing devices over time, thus highlighting the importance of controlling unintentional impurities in beta-gallium oxide wafers., Comment: 11 pages, 4 figures, references a supplimental which will be submitted seperately

We demonstrate a new substrate cleaning and buffer growth scheme in $\beta$-Ga$_2$O$_3$ epitaxial thin films using metalorganic vapor phase epitaxy (MOVPE). For the channel structure, a low-temperature (LT, 600 $^\circ$C) undoped Ga$_2$O$_3$ buffer is grown followed by transition layers to a high-temperature (HT, 810 $^\circ$C) Si-doped Ga$_2$O$_3$ channel layers without growth interruption. The (010) Ga$_2$O$_3$ Fe-doped substrate cleaning uses solvent cleaning followed by an additional HF (49% in water) treatment for 30 mins before the epilayer growth. This step is shown to compensate the parasitic Si channel at the epilayer-substrate interface that originates from the substrate polishing process or contamination from the ambient. SIMS analysis shows the Si peak atomic density at the substrate interface is several times lower than the Fe atomic density in the substrate - indicating full compensation. The elimination of the parasitic electron channel at the epi-substrate interface was also verified by electrical (capacitance-voltage profiling) measurements. In the LT-grown buffer layers, it is seen that the Fe forward decay tail from the substrate is very sharp with a decay rate of $\sim$ 9 nm$/$dec. These channels show record high electron mobility in the range of 196 - 85 cm$^2$/Vs in unintentionally doped and Si-doped films in the doping range of 2$\times$10$^{16}$ to 1$\times$10$^{20}$ cm$^{-3}$. Si delta-doped channels were also grown utilizing this substrate cleaning and the hybrid LT-buffers. Record high electron Hall mobility of 110 cm$^2$/Vs was measured for sheet charge density of 9.2$\times$10$^{12}$ cm$^{-2}$. This substrate cleaning combined with the LT-buffer scheme shows the potential of designing Si-doped $\beta$-Ga$_2$O$_3$ channels with exceptional transport properties for high performance gallium oxide-based electron devices., Comment: 20 pages, 10 figures

In this letter, fin-shape tri-gate $\beta$-Ga$_{2}$O$_{3}$ lateral MESFETs are demonstrated with a high power figure of merit of 0.95 GW/cm$^{2}$ - a record high for any $\beta$-Ga$_{2}$O$_{3}$ transistor to date. A low-temperature undoped buffer-channel stack design is developed which demonstrates record high Hall and drift electron mobilities in doped $\beta$-Ga$_{2}$O$_{3}$ channels allowing for low ON resistances R$_{ON}$ in $\beta$-Ga$_{2}$O$_{3}$ MESFETs. Fin-widths (W$_{fin}$) were 1.2-1.5 $\mu$m and there were 25 fins (N$_{fin}$) per device with a trench depth of $\sim$1$\mu$m. A $\beta$-Ga$_2$O$_3$ MESFET with a source-drain length of 6.4 $\mu$m exhibits a high ON current (187 mA/mm), low R$_{ON}$ (20.5 $\Omega$.mm) and a high average breakdown field (4.2 MV/cm). All devices show very low reverse leakage until catastrophic breakdown for breakdown voltages scaled from 1.1kV to $\sim$3kV. This work demonstrates the potential of channel engineering in improving $\beta$-Ga$_{2}$O$_{3}$ device performance toward lower conduction losses for low-to-medium voltage applications., Comment: 4 pages, 5 pages

Field-plated (FP) depletion-mode MOVPE-grown $\beta$-Ga$_2$O$_3$ lateral MESFETs are realized with superior reverse breakdown voltages and ON currents. A sandwiched SiN$_x$ dielectric field plate design was utilized that prevents etching-related damage in the active region and a deep mesa-etching was used to reduce reverse leakage. The device with L$_{GD}$ = 34.5 $\mu$m exhibits an ON current (I$_{DMAX}$) of 56 mA/mm, a high I$_{ON}$/I$_{OFF}$ ratio $>$ 10$^8$ and a very low reverse leakage until catastrophic breakdown at $\sim$ 4.4kV. The highest measurable V$_{BR}$ recorded was 4.57 kV (L$_{GD}$ = 44.5 $\mu$m). An LFOM of 132 MW/cm$^2$ was calculated for a V$_{BR}$ of $\sim$ 4.4 kV. The reported results are the first $>$ 4kV-class Ga$_2$O$_3$ transistors to surpass the theoretical FOM of Silicon. These are also the highest I$_{DMAX}$ and lowest R$_{ON}$ values achieved simultaneously for any $\beta$-Ga$_2$O$_3$ device with V$_{BR}$ $>$ 4kV to date. This work highlights that high breakdown voltages (V$_{BR}$), high lateral figure of merit (LFOM) and high ON currents can be achieved simultaneously in $\beta$-Ga$_2$O$_3$ lateral transistors., Comment: 4 pages, 5 figures

We demonstrate over 3 kV gate-pad-connected field plated (GPFP) $\beta$-Ga$_2$O$_3$ lateral MESFETs with high lateral figure of merit (LFOM) using metalorganic vapor phase epitaxy (MOVPE) grown channel layers and regrown ohmic contact layers. Using an improved low-temperature MOVPE selective area epitaxy process, we show that a total contact resistance to the channel as low as 1.4 $\Omega$.mm can be achieved.The GPFP design adopted here using PECVD (plasma-enhanced chemical vapor deposition) deposited SiN$_x$ dielectric and SiN$_x$/SiO$_2$ wrap-around passivation exhibits up to ~14% improved R$_{ON}$, up to ~70% improved breakdown voltage (V$_{BR}$ = V$_{DS}$ - V$_{GS}$) resulting in up to $\sim$3$\times$ higher LFOM compared to non-FP $\beta$-Ga$_2$O$_3$ lateral MESFETs. The V$_{BR}$ (~2.5 kV) and LFOM (355 MW/cm$^2$) measured simultaneously in our GPFP $\beta$-Ga$_2$O$_3$ lateral MESFET (with L$_{GD}$ = 10 $\mu$m) is the highest value achieved in any depletion-mode $\beta$-Ga$_2$O$_3$ lateral device., Comment: 6 pages, 5 figures

This paper presents vertical (001) oriented $\beta$-Ga$_2$O$_3$ field plated (FP) Schottky barrier diode (SBD) with a novel extreme permittivity dielectric field oxide. A thin drift layer of 1.7 $\mu m$ was used to enable a punch-through (PT) field profile and very low differential specific on-resistance (R$_{on-sp}$) of 0.32 m$\Omega$-cm$^{2}$. The extreme permittivity field plate oxide facilitated the lateral spread of the electric field profile beyond the field plate edge and enabled a breakdown voltage ($V_{br}$) of 687 V. The edge termination efficiency increases from 13.5 $\%$ for non-field plated structure to 63 $\%$ for high permittivity field plate structure. The surface breakdown electric field was extracted to be 5.45 MV/cm at the center of the anode region using TCAD simulations. The high permittivity field plated SBD demonstrated a record high Baliga figure of merit (BFOM) of 1.47 GW/cm$^{2}$ showing the potential of Ga$_2$O$_3$ power devices for multi-kilovolt class applications.

High-quality dielectric-semiconductor interfaces are critical for reliable high-performance transistors. We report the in-situ metalorganic chemical vapor deposition (MOCVD) of Al$_2$O$_3$ on $\beta$-Ga$_2$O$_3$ as a potentially better alternative to the most commonly used atomic layer deposition (ALD). The growth of Al$_2$O$_3$ is performed in the same reactor as Ga$_2$O$_3$ using trimethylaluminum and O$_2$ as precursors without breaking the vacuum at a growth temperature of 600 $^0$C. The fast and slow near interface traps at the Al$_2$O$_3$/ $\beta$-Ga$_2$O$_3$ interface are identified and quantified using stressed capacitance-voltage (CV) measurements on metal oxide semiconductor capacitor (MOSCAP) structures. The density of shallow and deep level initially filled traps (D$_{it}$) are measured using ultra-violet (UV) assisted CV technique. The average D$_{it}$ for the MOSCAP is determined to be 7.8 $\times$ 10$^{11}$ cm$^{-2}$eV$^{-1}$. The conduction band offset of the Al$_2$O$_3$/ Ga$_2$O$_3$ interface is also determined from CV measurements and found out to be 1.7 eV which is in close agreement with the existing literature reports of ALD Al$_2$O$_3$/ Ga$_2$O$_3$ interface. The current-voltage characteristics are also analyzed and the average breakdown field is extracted to be approximately 5.8 MV/cm. This in-situ Al$_2$O$_3$ dielectric on $\beta$-Ga$_2$O$_3$ with improved dielectric properties can enable Ga$_2$O$_3$-based high performance devices.

We report on the growth and characterization of Ge-doped \b{eta}-Ga2O3 thin films using a solid germanium source. \b{eta}-Ga2O3 thin films were grown using a low-pressure chemical vapor deposition (LPCVD) reactor with either an oxygen or gallium delivery tube. Films were grown on 6 degree offcut sapphire and (010) \b{eta}-Ga2O3 substrates with growth rates between 0.5 - 22 {\mu}m/hr. By controlling the germanium vapor pressure, a wide range of Hall carrier concentrations between 10^17 - 10^19 cm-3 were achieved. Low-temperature Hall data revealed a difference in donor incorporation depending on the reactor configuration. At low growth rates, germanium occupied a single donor energy level between 8 - 10 meV. At higher growth rates, germanium doping predominantly results in a deeper donor energy level at 85 meV. This work shows the effect of reactor design and growth regime on the kinetics of impurity incorporation. Studying donor incorporation in \b{eta}-Ga2O3 is important for the design of high-power electronic devices., Comment: 16 pages,4 figures

We report on the demonstration of metalorganic vapor phase epitaxy-regrown (MOVPE) ohmic contacts in an all MOVPE-grown $\beta$-Ga$_2$O$_3$ metal-semiconductor field effect transistor (MESFET). The low-temperature (600$^{\circ}$C) heavy (n$^{+}$) Si-doped regrown layers exhibit extremely high conductivity with sheet resistance of 73 $\Omega$/$\square$ and record low metal/n$^{+}$-Ga$_2$O$_3$ contact resistance of 80 m$\Omega$.mm and specific contact resistivity of 8.3$\times$10$^{-7}$ $\Omega$.cm$^{2}$ were achieved. The fabricated MESFETs exhibit a maximum drain-to-source current of 130 mA/mm, a high I$_{ON}$/I$_{OFF}$ of $>$10$^{10}$ with a high power FOM of 25 MW/cm$^{2}$ were achieved without any field plates. Nanoparticle-assisted Raman thermometry, thermal modeling, and infrared thermography were performed to assess the device self-heating under the high current and power conditions. This demonstration shows the promise of MOVPE technique for the realization of high-performance lateral $\beta$-Ga$_2$O$_3$ devices and also highlights the need for device-level thermal management.

The quasi-static anisotropic permittivity parameters of electrically insulating gallium oxide (beta-Ga2O3) were determined by terahertz spectroscopy. Polarization-resolved frequency domain spectroscopy in the spectral range from 200 GHz to 1 THz was carried out on bulk crystals along different orientations. Principal directions for permittivity were determined along crystallographic axes c, and b, and reciprocal lattice direction a*. No significant frequency dispersion in the real part of dielectric permittivity was observed in the measured spectral range. Our results are in excellent agreement with recent radio-frequency capacitance measurements as well as with extrapolations from recent infrared measurements of phonon mode and high frequency contributions, and close the knowledge gap for these parameters in the terahertz spectral range. Our results are important for applications of beta-Ga2O3 in high-frequency electronic devices, Comment: Main Manuscript is 6 pages long with 3 figures and 1 table. The submission also contains a Supplementary Info section

By combining temperature-dependent resistivity and Hall effect measurements, we investigate donor state energy in Si-doped \b{eta}-Ga2O3 films grown using metal-organic vapor phase epitaxy (MOVPE). High magnetic field Hall effect measurements (H = +/-90 kOe) showed non-linear Hall resistance for T < 150 K revealing two-band conduction. Further analyses revealed carrier freeze-out characteristics in both bands yielding donor state energies of ~ 33.7 and ~ 45.6 meV. The former is consistent with the donor energy of Si in \b{eta}-Ga2O3 whereas the latter suggests a residual donor state, likely associated with a DX center. This study provides a critical insight into the impurity band conduction and the defect energy states in \b{eta}-Ga2O3 using high-field magnetotransport measurements., Comment: 14 pages

In this work, we use photoluminescence spectroscopy (PL) to monitor changes in the UV, UV', blue, and green emission bands from n-type (010) Ga2O3 films grown by metalorganic vapor phase epitaxy (MOVPE) induced by annealing at different temperatures under O2 ambient. Annealing at successively higher temperatures decreases the overall PL yield and UV intensity at nearly the same rates, indicating the increase in formation of at least one non-radiative defect type. Simultaneously, the PL yield ratios of blue/UV and green/UV increase, suggesting that defects associated with these emissions increase in concentration with O2 annealing. Utilizing the different absorption coefficients of 240 and 266 nm polarization-dependent excitation, we find an overall activation energy for the generation of non-radiative defects of 0.69 eV in the bulk but 1.55 eV near the surface. We also deduce activation energies for the green emission-related defects of 0.60 eV near the surface and 0.89-0.92 eV through the films, whereas the blue-related defects have activation energy in the range 0.43-0.62 eV for all depths. Lastly, we observe hillock surface morphologies and Cr diffusion from the substrate into the film for temperatures above 1050 oC. These observations are consistent with the formation and diffusion of VGa and its complexes as a dominant process during O2 annealing, but further work will be necessary to determine which defects and complexes provide radiative and non-radiative recombination channels and the detailed kinetic processes occurring at surfaces and in bulk amongst defect populations., Comment: 14 pages, 3 figures

We report on the growth and characterization of metalorganic vapor-phase epitaxy-grown \b{eta}-(AlxGa1-x)2O3/\b{eta}-Ga2O3 modulation-doped heterostructures. Electron channel is realized in the heterostructure by utilizing a delta-doped \b{eta}-(AlxGa1-x)2O3 barrier. Electron channel characteristics are studied using transfer length method, capacitance-voltage and Hall measurements. Hall sheet charge density of 1.06 x 1013 cm-2 and mobility of 111 cm2/Vs is measured at room temperature. Fabricated transistor showed peak current of 22 mA/mm and on-off ratio of 8 x 106. Sheet resistance of 5.3 k{\Omega}/Square is measured at room temperature, which includes contribution from a parallel channel in \b{eta}-(AlxGa1-x)2O3., Comment: 22 pages, 4 figures

We report on low-temperature MOVPE growth of silicon delta-doped \b{eta}-Ga2O3 films with low FWHM. The as-grown films are characterized using Secondary-ion mass spectroscopy, Capacitance-Voltage and Hall techniques. SIMS measurements show that surface segregation is the chief cause of large FWHM in MOVPE-grown films. The surface segregation coefficient (R) is observed to reduce with reduction in the growth temperature. Films grown at 600 {\deg}C show an electron concentration of 9.7 x 1012 cm-2 and a FWHM of 3.2 nm. High resolution scanning/transmission electron microscopy of the epitaxial film did not reveal any significant observable degradation in crystal quality of the delta sheet and surrounding regions. Hall measurements of delta-doped film on Fe-doped substrate showed a sheet charge density of 6.1 x 1012 cm-2 and carrier mobility of 83 cm2/V. s. Realization of sharp delta doping profiles in MOVPE-grown \b{eta}-Ga2O3 is promising for high performance device applications., Comment: 10 pages, 5 figures

In this work, we report on the growth of high-mobility $\beta$-Ga$_2$O$_3$ homoepitaxial thin films grown at a temperature much lower than the conventional growth temperature window for metalorganic vapor phase epitaxy. Low-temperature $\beta$-Ga$_2$O$_3$ thin films grown at 600$^{\circ}$C on Fe-doped (010) bulk substrates exhibits remarkable crystalline quality which is evident from the measured room temperature Hall mobility of 186 cm$^2$/Vs for the unintentionally doped films. N-type doping is achieved by using Si as a dopant and controllable doping in the range of 2$\times$10$^{16}$ - 2$\times$10$^{19}$ cm$^{-3}$ is studied. Si incorporation and activation is studied by comparing silicon concentration from secondary ion mass spectroscopy (SIMS) and electron concentration from temperature-dependent Hall measurements. The films exhibit high purity (low C and H concentrations) with a very low concentration of compensating acceptors (2$\times$10$^{15}$ cm$^{-3}$) even at this growth temperature. Additionally, abrupt doping profile with forward decay of $\sim$ 5nm/dec (10 times improvement compared to what is observed for thin films grown at 810$^{\circ}$C) is demonstrated by growing at a lower temperature., Comment: 5 pages, 6 figures

We report on the modeling of polarization-induced two-dimensional electron gas (2DEG) formation at ${\epsilon}$-AlGaO3 / ${\epsilon}$-Ga2O3 heterointerface and the effect of spontaneous polarization (Psp) reversal on 2DEG density in ${\epsilon}$-Ga2O3 /${\epsilon}$-AlGaO3 / ${\epsilon}$-Ga2O3 double heterostructures. Density-functional theory (DFT) is utilized to calculate the material properties of ${\epsilon}$-Ga2O3 and ${\epsilon}$-AlGaO3 alloys. Using Schrodinger-Poisson solver along with DFT calculated parameters, the 2DEG density is calculated as a function of barrier type and thickness. By optimizing the layer thicknesses of ${\epsilon}$-Ga2O3/${\epsilon}$-AlGaO3/${\epsilon}$-Ga2O3 heterostructures, charge contrast ratios exceeding 1600 are obtained. This computational study indicates the high potential for ${\epsilon}$-Ga2O3-based heterostructure devices for non-volatile memories and neuromorphic applications.

This paper reports on the modulation of Schottky barrier heights (SBH) on three different orientations of $\beta$-Ga$_2$O$_3$ by insertion of an ultra-thin SiO$_2$ dielectric interlayer at the metal-semiconductor junction, which can potentially lower the Fermi-level pinning (FLP) effect due to metal-induced gap states (MIGS). Pt and Ni metal-semiconductor (MS) and metal-interlayer-semiconductor (MIS) Schottky barrier diodes were fabricated on bulk n-type doped $\beta$-Ga$_2$O$_3$ single crystal substrates along the (010), (-201) and (100) orientations and were characterized by room temperature current-voltage (I-V) and capacitance-voltage (C-V) measurements. Pt MIS diodes exhibited 0.53 eV and 0.37 eV increment in SBH along the (010) and (-201) orientations respectively as compared to their respective MS counterparts. The highest SBH of 1.81 eV was achieved on the (010)-oriented MIS SBD using Pt metal. The MIS SBDs on (100)-oriented substrates exhibited a dramatic increment ($>$1.5$\times$) in SBH as well as reduction in reverse leakage current. The use of thin dielectric interlayers can be an efficient experimental method to modulate SBH of metal/Ga$_2$O$_3$ junctions., Comment: 8 pages, 10 figures, 2 tables

We report on silicon delta doping of metalorganic vapor-phase epitaxy-grown \b{eta}-Ga2O3 thin films using silane precursor. Delta-doped \b{eta}-Ga2O3 epitaxial films are characterized using capacitance-voltage profiling and secondary-ion mass spectroscopy. Electron sheet charge density in the range of 2.9e12 cm-2 to 8e12 cm-2 with a half width at half maximum ranging from 6.2 nm to 3.5 nm is measured. We also demonstrate a high density (6.4e12 cm-2) degenerate two-dimensional electron gas using a delta-doped \b{eta}-(Al0.26Ga0.74)2O3/\b{eta}-Ga2O3 heterostructure.The total charge could also include a contribution from a parallel channel in the \b{eta}-(Al0.26Ga0.74)2O3 alloy barrier.

We report on n-type degenerate doping in MOVPE grown \b{eta}-(Al0.26Ga0.74)2O3 epitaxial thin films and modulation doping in \b{eta}-(Al0.26Ga0.74)2O3/\b{eta}-Ga2O3 heterostructure. Alloy composition is confirmed using HRXRD measurements. Carrier concentration in the thin films is proportional to the silane molar flow. Room temperature hall measurements showed a high carrier concentration of 6x1018-7.3x1019 cm-3 with a corresponding electron mobility of 53-27 cm2/V.s in uniformly-doped \b{eta}-(Al0.26Ga0.74)2O3 layers. Modulation doping is used to realize a total electron sheet charge of 2.3x1012 cm-2 in a \b{eta}-(Al0.26Ga0.74)2O3/\b{eta}-Ga2O3 heterostructure using a uniformly-doped \b{eta}-(Al0.26Ga0.74)2O3 barrier layer and a thin spacer layer.