Search

Background: Manufacturers’ recommendations on cleaning of tracheostomy tubes focus on general warning information and non-specific manual cleaning procedures. The aim of this experimental study was to evaluate different reprocessing methods and to determine the mechanical integrity and functionality of tracheostomy tubes following reprocessing.Methods: Sixteen cuffed or un-cuffed tracheostomy tubes obtained from hospital in-patients were reprocessed using one of the following reprocessing methods: a) manual brushing and rinsing with tap water, brushing followed by disinfection with a glutaraldehyde solution, c) manual brushing followed machine-based cleaning in a dishwasher, and d) manual brushing followed by ultrasound cleaning in a commercially available ultrasound device. Microbial burden of the tubes before and after reprocessing was assessed by measurement of microbial colony-forming units per mL (CFU/mL) of rinsing fluid. After cleaning, tracheostomy tubes were investigated for loss of functionality. Findings: Manual brushing and rinsing with tap water reduced microbial colonization in average by 10 CFU/mL, but with poor reproducibility and reliability. Complete microbial reduction was achieved only with additional chemical or machine-based thermal disinfection. Ultrasound sonification yielded no further microbial reduction after manual brushing. Conclusion: Manual brushing alone will not result in complete eradication of microorganism colonising cuffed or un-cuffed tracheostomy tubes. However, manual cleaning followed by chemical or thermal disinfection may be regarded as safe and reproducible reprocessing method. If a machine-based reprocessing method is used for cuffed tubes, the cuffs’ ventilation hose must be secured in a safe position prior to thermal disinfection.

Introduction: The conventional rigid-90° and rigid-70° laryngostroboscopy has been so far considered the gold standard in assessing the vibratory behavior of the vocal folds and the glottal closure configuration during phonation. Meanwhile, this rigid laryngostroboscopy is more and more replaced by flexible chip-on-tip systems. The aim of this study was to evaluate the influence of these different endoscopic techniques on glottal closure configuration and on visibility of the complete focal fold length including anterior commissure during phonation. Methods: Twenty-one euphonic subjects were enrolled (mean age 34.6 ± 9.5; m = 10, f = 11). They were examined with the three laryngoscopic techniques (conventional rigid-90°, rigid-70°, and flexible chip-on-tip laryngoscopy during low and high voice pitch with soft and loud voice intensity). For evaluating the degree of glottal closure, a modified classification of Södersten et al. was applied and the visibility of the anterior commissure was evaluated. The correlation of the three endoscopic techniques was assessed with Cohen and Fleiss' kappa. Results: In even low loud phonation, the rigid-90° and rigid-70° endoscopies revealed a complete closure of the glottis in only 47.6% of subjects but with flexible endoscopy in 81%. The complete vocal fold length with anterior commissure was best visible with flexible endoscopy in 90.5% in low-soft and high-soft phonation. The rigid-90° endoscopy showed a slight agreement in comparison with the flexible endoscopy in regard to the types of vocal fold closure with a Cohen's kappa coefficient k = 0.199. The rigid-90° endoscopy showed an almost perfect agreement with k = 0.84 when compared to the rigid-70° endoscopy. The flexible endoscopy compared to the rigid-70° endoscopy showed a fair agreement with k = 0.346. Conclusion: We found mainly corresponding results in both rigid-90° and rigid-70° endoscopic techniques which can be explained by the same transoral approach with the tongue pulled out, whereas the flexible transnasal endoscopy mainly gives a better view on the anterior commissure. The influence of transorally or transnasally guided endoscopic techniques needs to be considered in interpretation of laryngostroboscopic parameters like vocal fold closure and supraglottal hyperactivity. [ABSTRACT FROM AUTHOR]