Microscopic mechanism of carbon oxides formation during long-flame coal oxidation at molecular scale.

• Release of CO and CO 2 at constant temperature with time follows two different rules. • C–H in side chains is oxidized into precursors of carbon oxides, C = O and –COO. • CO and CO 2 can be produced by stepwise decomposition at ambient temperature. • Production of CO and CO 2 by direct decomposition occurs only at high temperatures. Precursors of carbon oxides in coals are considered to be related to aldehyde group(–CHO) and carboxyl group (–COOH), but the way of decomposition of precursors to produce carbon oxides is not clear. Through theoretical analysis, experimental research and quantum chemical calculation at molecular scale, this paper explores the decomposition mode and products of carbon oxide precursors during coal spontaneous combustion (CSC). A programmed heating device was used to investigate the change rule of gas product concentration during the constant temperature oxidation of coals, and the microstructure of the coals was characterized by low-temperature nitrogen adsorption experiments (BET), X-ray Diffraction (XRD) and X-ray photoelectron spectrometer (XPS). The results of the study show that during coal oxidation, the inhomogeneous energy exchange between the coals and the external heat source results in the change of gas product concentration with time following two rules. BET experiments reveal that oxidation leads to the evolution of fine mesopores to macropores and an increase in the number of pores with diameters larger than 20 nm in the coals, which facilitates the transport of oxygen molecules through the pore structure. Within 200 °C, the microcrystalline structure of coals is basically unchanged, and the active structure C–C/C–H on the side chain is converted to –CHO and –COOH and then decomposed to produce carbon oxides. Quantum chemical calculation shows that the reaction energy barrier of carbonyl group and carboxyl group decomposed step by step to form carbon oxides is much smaller than that of direct decomposition, and carbon oxides and alkyl radicals can be produced even at room temperature by step decomposition. The research results provide theoretical guidance for the formation mechanism of carbon oxides during low temperature oxidation of coals. [ABSTRACT FROM AUTHOR]